2322170 ADAPTER-TIP Caterpillar parts
374D L, 374F L, 385B, 385C, 385C FS, 385C L, 390D, 390D L, 390F L
Rating:
Alternative (cross code) number:
CA2322170
232-2170
2322170
CA2322170
232-2170
2322170
Weight: 182 pounds 82 kg.
EXCAVATOR, FRONT SHOVEL,
Compatible equipment models: 2322170:
Information:
Introduction (Power Supplies)
The 3056E Engine has four supplies to the following components:
ECM
Fuel Injection Pump
Pressure sensors
Air inlet heaterECM Power Supply
Illustration 1 g00908039
Schematic for ECMThe power supply to the ECM and the system is drawn from the 24 volt or the 12 volt battery. The power supply for the ECM has the following components:
Battery
disconnect switch
Key start switch
Fuses
Ground bolt
ECM connector
Machine interface connectorNote: The ground bolt is the only component that is mounted on the engine.The Schematic for the ECM shows the main components for a typical power supply circuit. Battery voltage is normally connected to the ECM. The input from the key start switch turns on the ECM .The wiring harness can be bypassed for troubleshooting purposes.The display screen on the Caterpillar electronic technician (Cat ET) can be used in order to check the voltage supply. Note: Two wires are used to reduce resistance.Power Supply for the Fuel Injection Pump
Illustration 2 g00895884
Schematic for the fuel injection pump
Illustration 3 g00896034
Connection for the fuel injection pump (J40/P40)
Illustration 4 g00896003
Connector for the fuel injection pump (J40) (1) Can L (2) Can H (3) Extra connection (4) Extra Connection (5) Fuel shutoff (6) Battery - (7) Battery + (8) Engine Position (9) Extra connectionThe power supply for the ECM comes from the Machine interface connector. The machine interface connector receives power from the power relay.Power Supply for the Pressure Sensors
Illustration 5 g00896073
Schematic for pressure sensorsThe ECM supplies 5.0 0.2 DC volts through the ECM connector to each sensor. The power supply is protected against short circuits. A short in a sensor or a wiring harness will not cause damage to the ECM.Power supply of the Air Inlet Heater
Illustration 6 g00919204
Schematic for air inlet heaterThe Air inlet heater is powered from the power relay that is controlled by the ECM. A resistor is used On 24V systems .
The 3056E Engine has four supplies to the following components:
ECM
Fuel Injection Pump
Pressure sensors
Air inlet heaterECM Power Supply
Illustration 1 g00908039
Schematic for ECMThe power supply to the ECM and the system is drawn from the 24 volt or the 12 volt battery. The power supply for the ECM has the following components:
Battery
disconnect switch
Key start switch
Fuses
Ground bolt
ECM connector
Machine interface connectorNote: The ground bolt is the only component that is mounted on the engine.The Schematic for the ECM shows the main components for a typical power supply circuit. Battery voltage is normally connected to the ECM. The input from the key start switch turns on the ECM .The wiring harness can be bypassed for troubleshooting purposes.The display screen on the Caterpillar electronic technician (Cat ET) can be used in order to check the voltage supply. Note: Two wires are used to reduce resistance.Power Supply for the Fuel Injection Pump
Illustration 2 g00895884
Schematic for the fuel injection pump
Illustration 3 g00896034
Connection for the fuel injection pump (J40/P40)
Illustration 4 g00896003
Connector for the fuel injection pump (J40) (1) Can L (2) Can H (3) Extra connection (4) Extra Connection (5) Fuel shutoff (6) Battery - (7) Battery + (8) Engine Position (9) Extra connectionThe power supply for the ECM comes from the Machine interface connector. The machine interface connector receives power from the power relay.Power Supply for the Pressure Sensors
Illustration 5 g00896073
Schematic for pressure sensorsThe ECM supplies 5.0 0.2 DC volts through the ECM connector to each sensor. The power supply is protected against short circuits. A short in a sensor or a wiring harness will not cause damage to the ECM.Power supply of the Air Inlet Heater
Illustration 6 g00919204
Schematic for air inlet heaterThe Air inlet heater is powered from the power relay that is controlled by the ECM. A resistor is used On 24V systems .
Cat SIS web machinery list:
Parts adapter Caterpillar catalog:
5P9617
ADAPTER
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H NA, 12K, 12M, 135H, 135H NA, 140G, 140H, 140H NA, 140K, 140K 2, 140M, 143H, 14H, 160H, 160K, 163H, 16H, 16M, 215D, 225, 225D, 229, 229D, 231D, 235,...
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H NA, 12K, 12M, 135H, 135H NA, 140G, 140H, 140H NA, 140K, 140K 2, 140M, 143H, 14H, 160H, 160K, 163H, 16H, 16M, 215D, 225, 225D, 229, 229D, 231D, 235,...
5P3501
ADAPTER
215B, 225, 235, 235B, 235C, 235D, 245B, 245D, 24H, 30/30, 3126, 3126B, 3126E, 320D, 320D FM, 325C FM, 3304B, 3306, 3306B, 3306C, 330C FM, 3406, 3406B, 3406C, 3406E, 3408, 3408C, 3412, 3456, 35, 3512, ...
215B, 225, 235, 235B, 235C, 235D, 245B, 245D, 24H, 30/30, 3126, 3126B, 3126E, 320D, 320D FM, 325C FM, 3304B, 3306, 3306B, 3306C, 330C FM, 3406, 3406B, 3406C, 3406E, 3408, 3408C, 3412, 3456, 35, 3512, ...
9X0262
ADAPTER
120H, 120K, 120K 2, 12H, 12K, 12M, 135H, 140G, 140H, 140K, 140K 2, 140M, 140M 2, 143H, 14H, 14M, 160H, 160K, 160M, 160M 2, 163H, 16H, 16M, 2290, 2390, 2391, 2491, 24H, 24M, 2590, 30/30, 3114, 3116, 31...
120H, 120K, 120K 2, 12H, 12K, 12M, 135H, 140G, 140H, 140K, 140K 2, 140M, 140M 2, 143H, 14H, 14M, 160H, 160K, 160M, 160M 2, 163H, 16H, 16M, 2290, 2390, 2391, 2491, 24H, 24M, 2590, 30/30, 3114, 3116, 31...
2P8421
ADAPTER-O-RING
1090, 1190, 1190T, 120M, 120M 2, 1290T, 12M, 12M 2, 12M 3, 12M 3 AWD, 1390, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14M, 153, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H NA, 16M, 173B, 183B, 193, 2590, 308...
1090, 1190, 1190T, 120M, 120M 2, 1290T, 12M, 12M 2, 12M 3, 12M 3 AWD, 1390, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14M, 153, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H NA, 16M, 173B, 183B, 193, 2590, 308...
8T2353
ADAPTER
120G, 120H, 120K, 120K 2, 12G, 12H, 12H NA, 12K, 12M, 12M 2, 130G, 135H, 140G, 140H, 140H NA, 140K, 140K 2, 140M, 140M 2, 143H, 14G, 14H, 14H NA, 160G, 160H, 160K, 160M 2, 163H, 16G, 216, 228, 2290, 2...
120G, 120H, 120K, 120K 2, 12G, 12H, 12H NA, 12K, 12M, 12M 2, 130G, 135H, 140G, 140H, 140H NA, 140K, 140K 2, 140M, 140M 2, 143H, 14G, 14H, 14H NA, 160G, 160H, 160K, 160M 2, 163H, 16G, 216, 228, 2290, 2...
4P2383
ADAPTER
16H NA, 24M, 3406B, 3406C, 3406E, 3456, 375 L, 385B, 5080, 5090B, 583R, 583T, 587R, 587T, 621B, 621F, 621G, 623F, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 637E, 637G, 651B, 657B, 657E, 657G,...
16H NA, 24M, 3406B, 3406C, 3406E, 3456, 375 L, 385B, 5080, 5090B, 583R, 583T, 587R, 587T, 621B, 621F, 621G, 623F, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 637E, 637G, 651B, 657B, 657E, 657G,...
6V7420
ADAPTER
120G, 120H, 120K, 120K 2, 12K, 135H, 140K, 140K 2, 143H, 14H, 160K, 163H NA, 16G, 16M, 216, 236, 247, 267, 287, 305.5, 308D, 3126B, 3126E, 322C, 322C FM, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 32...
120G, 120H, 120K, 120K 2, 12K, 135H, 140K, 140K 2, 143H, 14H, 160K, 163H NA, 16G, 16M, 216, 236, 247, 267, 287, 305.5, 308D, 3126B, 3126E, 322C, 322C FM, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 32...
3P1823
ADAPTER-PIPE
10-20B, 120G, 12G, 12H, 12H ES, 12H NA, 130G, 140G, 140H, 140H ES, 140H NA, 143H, 14G, 14H NA, 160G, 160H, 160H ES, 160H NA, 163H NA, 235, 245, 24M, 311D LRR, 311F LRR, 320 L, 3208, 320B FM LL, 320C F...
10-20B, 120G, 12G, 12H, 12H ES, 12H NA, 130G, 140G, 140H, 140H ES, 140H NA, 143H, 14G, 14H NA, 160G, 160H, 160H ES, 160H NA, 163H NA, 235, 245, 24M, 311D LRR, 311F LRR, 320 L, 3208, 320B FM LL, 320C F...
6I0724
ADAPTER-PLUG
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 324E, 324E L, 324E LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330C, 330C FM, 330C L, 330C MH, 330...
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 324E, 324E L, 324E LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330C, 330C FM, 330C L, 330C MH, 330...
3P1932
ADAPTER
120H, 120K, 120K 2, 120M, 120M 2, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H NA, 14M, 160H, 160H ES...
120H, 120K, 120K 2, 120M, 120M 2, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H NA, 14M, 160H, 160H ES...
6I8804
ADAPTER
375 L, 385B, 385C, 385C L, 994, 994D, 994F, 994H
375 L, 385B, 385C, 385C L, 994, 994D, 994F, 994H
1711704
ADAPTER-TIP
385B, 385C, 385C FS, 5090B, 992G
385B, 385C, 385C FS, 5090B, 992G
2642175
ADAPTER-TIP
385B, 385C L, 390D, 390D L
385B, 385C L, 390D, 390D L
2642156
ADAPTER-TIP
365B II, 365C, 374D L, 374F L, 385B, 385C L
365B II, 365C, 374D L, 374F L, 385B, 385C L
1959154
ADAPTER-TIP
365B, 365B II, 365C, 365C L, 374D L, 374F L, 385B, 385C, 385C L, 390D, 390D L, 390F L
365B, 365B II, 365C, 365C L, 374D L, 374F L, 385B, 385C, 385C L, 390D, 390D L, 390F L
2642155
ADAPTER-TIP
365B II, 365C, 374D L, 374F L, 385B, 385C L
365B II, 365C, 374D L, 374F L, 385B, 385C L
1659406
ADAPTER
385B
385B
1719467
ADAPTER
385B
385B
4Q2870
ADAPTER
325C, 330C
325C, 330C
2642136
ADAPTER-TIP
336D L, 336D2, 336D2 L, 336E LN, 345C, 345D, 345D L, 349D L, 349E L, 349E L VG, 349F L, 365B II, 365C
336D L, 336D2, 336D2 L, 336E LN, 345C, 345D, 345D L, 349D L, 349E L, 349E L VG, 349F L, 365B II, 365C
2642135
ADAPTER-TIP
336D L, 336D2, 336D2 L, 336E LN, 345C, 345D, 345D L, 349D L, 349E L, 349E L VG, 349F L, 365B II, 365C
336D L, 336D2, 336D2 L, 336E LN, 345C, 345D, 345D L, 349D L, 349E L, 349E L VG, 349F L, 365B II, 365C
2154436
ADAPTER AS
330C L
330C L
1134704
ADAPTER
385B
385B
2642176
ADAPTER-TIP
385B, 385C L, 390D, 390D L
385B, 385C L, 390D, 390D L