AXLE GP 2082565 - Caterpillar

Battery
Battery Charging
The battery pack in the sulfur analyzer consists of two, 2 Volt, 8.5 ampere hour gel cell batteries, connected in parallel. It has an adequate charge capacity to power the analyzer for many hours before a recharge is necessary.The battery charger operates on 120 or 230 Volts AC, and will charge the batteries to their full capacity in 14-20 hours. Do not charge the batteries for an extended period of time, as this could cause damage to them.Battery Test Using A Voltmeter
Using a voltmeter across sockets A and C of the igniter power cable, press the igniter push button. If the voltage is 2.05 Volts DC or less, charge the batteries. A fully charged set of batteries should indicate 2.13 Volts DC at the terminals.120 Volt Operation
The charger is shipped from the factory for use on 120 Volt power, 60 Hz operation. Plug the charger power cord into any 120 Volt, 60 Hz outlet and turn the battery charger ON/OFF switch to the ON position.230 Volt Operation
1. Cut off the 120 Volt plug from the end of the charger power cord and connect the 230 Volt plug. 2. Use a screwdriver blade to remove plug (1). 3. Move switch (2) for the battery charger to the 230 Volt position. Install plug (1).4. Connect the battery charger power cord to a 230 Volt 50/60 Hz outlet and turn the battery charger ON/OFF switch to the ON position.Battery Circuit Schematic
Replacement Sulfur Dioxide Gas Detector Tube Ordering Information
Replacement 8T5177 Sulfur Dioxide Gas Detector Tubes can be ordered from the Caterpillar Parts Dept. using the normal parts ordering procedure. Detector tubes can also be ordered from:Matheson Gas Products
Manhattan Road & Richards Street
P.O. Box 96
Joliet, IL 60434
Phone: (815) 727-4848
Order: Kitigawa Precision Gas Detector Tubes No. 103SC
The Kitigawa Precision Gas Detector Tubes, No. 103SC, can also be ordered from Matheson Gas Product Branch Offices at the following addresses:United States
East
Matheson Gas Products
Buffalo, New York
Direct Line to Twinsburg, Ohio
Phone: (716) 832-9286
Matheson Gas Products
Bridgeport, New Jersey 08014
603 Heron Drive
P.O. Box 38
Phone: (609) 462-2770
Matheson Gas Products
Baltimore, Maryland 21227
6655 Amberton Drive, Unit O
Phone: (301) 796-0517
Matheson Gas Products
East Rutherford, New Jersey 07073
932 Paterson Plank Road
P.O. Box 85
Phone: (201) 933-2400
Telex: 424546 MATSON
Matheson Gas Products
Gloucester, Massachusetts 01930
61 Grove Street
P.O. Box 1147
Phone: (617) 283-7700
Matheson Gas Products
Morrow, Georgia 30260
6874 South Main Street
P.O. Box 136
Phone: (404) 961-7891
Matheson Gas Products
Pittsburgh, Pennsylvania
Direct Line to Twinsburg, Ohio
Phone: (412) 261-2782
Midwest
Matheson Gas Products
Baton Rouge, Louisiana
Direct Line to Gonzales, Louisiana
Phone: (504) 343-0364
Matheson Gas Products
Chicago, Illinois
Direct Line to Joliet, Illinois
Phone: (312) 242-1321
Matheson Gas Products
Dayton, Ohio 45424
8135 Uehling Lane
Phone: (513) 236-3021
Matheson Gas Products
Gonzales, Louisiana 70737
1931 South Southland Avenue
Phone: (504) 644-5303
Matheson Gas Products
Joliet, Illinois 60434
Manhattan Road & Richards Street
P.O. Box 96
Phone: (815) 727-4848
Matheson Gas Products
Twinsburg, Ohio 44087
1650 Enterprise Parkway
P.O. Box 358
Phone: (216) 425-4406
West
Matheson Gas Products
Cucamonga, California 91730
8800 Utica Avenue
Phone: (714) 987-4611
Matheson Gas Products
Newark, California 94560
6775 Central Avenue
Phone: (415) 793-2559
Matheson Gas Products
LaPorte, Texas 77571
1920 West Fairmont Parkway
P.O. Box 908
Phone: (713) 471-2544
Matheson Gas Products
Phoenix, Arizona
Direct Line to Cucamonga, CA
Phone: (602) 894-1387
To order replacement sulfur dioxide gas detector tubes outside the U.S.A., order Kitigawa Precision Gas