3508114 BRACKET AS Caterpillar parts
312E, 312E L, 316E L, 318E L
Rating:
Alternative (cross code) number:
CA3508114
350-8114
3508114
CA3508114
350-8114
3508114
Weight: 1 pounds 0 kg.
EXCAVATOR,
Number on catalog scheme:
21
For full view, you need register
Information:
TECHNICAL INFORMATION BULLETIN MAY 29, 2002
ENGINES 3196 (2XR),
C-12 (9HP) MARINE ENGINES
Component Code 1059SUBJECT: EXHAUST MANIFOLD GASKET
PROBLEM:
The 100-6437 Exhaust Manifold Gasket that was used on these engines may allow an exhaust leak. The most frequent location of the leak is at the exhaust port of the number 2 cylinder
SOLUTION:
A new exhaust manifold gasket is now being used in the production of these engines. The new gasket is in effect with 3196 (2XR04843-Up) and C-12 (9HP00077) Marine Engines. This new exhaust manifold gasket is not yet available from the Parts System. An Engine News article will announce the availability of the new gasket.
Leaks at the exhaust manifolds can be confirmed by using a "white paper test". Place a piece of white card stock underneath each exhaust manifold port. The card stock must be positioned within one inch of the joint between the exhaust manifold and the cylinder head. Use a fixture to hold the card stock in position. Start the engine and run the engine for 20 to 30 seconds. Stop the engine and remove the card stock. There should be NO soot appearing on the card stock.
Until the new exhaust manifold gasket is available, the following repair procedure is recommended.
Note: Six 100-6437 Exhaust Manifold Gaskets are required for this procedure.
Note: Use the applicable Disassembly and Assembly Module as a guide for this procedure.
Remove the exhaust manifold assembly from the engine.
Clean the surfaces of the exhaust manifold and the cylinder head that contact the exhaust manifold gasket.
Assemble two 100-6437 Exhaust Manifold Gaskets together with the raised beads on the gasket toward the outside. Use several small beads of "super glue" to fasten the gaskets together. This will keep the gaskets in alignment until the exhaust manifold is installed. Repeat this procedure in order to provide 3 gasket assemblies.
Put the new exhaust manifold gasket assemblies (3) in position on the exhaust manifold (1).
Apply 5P-3931 Anti-Seize Compound to the threads of the 24 bolts (2) that fasten the exhaust manifold to the cylinder head. Install the 24 bolts (2) and washers. Tighten the 24 bolts (2) in the sequence shown in the illustration. Tighten the 24 bolts to a torque of 55 ± 10 N×m (41 ± 7 lb ft).
RIGHT SIDE VIEW
1. Exhaust Manifold, 2. 24 Bolts and Washers,
3. Exhaust Manifold Gasket
COPYRIGHT 2002 CATERPILLAR
ALL RIGHTS RESERVED
Caterpillar parts catalog:
Parts bracket Caterpillar catalog:
3603201
BRACKET GP-SUPPORT
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
3819267
BRACKET
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 416F, 420F, 428F, 430F, 432F, 434F, 444F, 450F, C4.4, C4.4XQ100, C4.4XQ80, CB-44B, CB-54B, CP-54B, CP-68B, CP-74B, CS-54B, CS-56B, CS-64B, CS-66B, CS-7...
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 416F, 420F, 428F, 430F, 432F, 434F, 444F, 450F, C4.4, C4.4XQ100, C4.4XQ80, CB-44B, CB-54B, CP-54B, CP-68B, CP-74B, CS-54B, CS-56B, CS-64B, CS-66B, CS-7...
1640643
BRACKET AS
307C, 307D, 311C, 311D LRR, 311F LRR, 312C L, 312D, 312D L, 312E L, 315C, 315D L, 316E L, 318C, 318E L, 319D L, 319D LN, 320C, 320D, 320D L, 322C, 324D, 324D L, 325C, 325D L, 329D, 329D L, 330C L, 330...
307C, 307D, 311C, 311D LRR, 311F LRR, 312C L, 312D, 312D L, 312E L, 315C, 315D L, 316E L, 318C, 318E L, 319D L, 319D LN, 320C, 320D, 320D L, 322C, 324D, 324D L, 325C, 325D L, 329D, 329D L, 330C L, 330...
1892693
BRACKET AS
307C, 307D, 311C, 311D LRR, 311F LRR, 312C L, 312D, 312D L, 312E, 312E L, 313D, 315C, 315D L, 316E L, 318C, 318E L, 319D L, 319D LN, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320...
307C, 307D, 311C, 311D LRR, 311F LRR, 312C L, 312D, 312D L, 312E, 312E L, 313D, 315C, 315D L, 316E L, 318C, 318E L, 319D L, 319D LN, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320...
3473895
BRACKET
311D LRR, 312D, 312D L, 312D2, 312E, 312E L, 314D CR, 314D LCR, 314E LCR, PIN GRAB
311D LRR, 312D, 312D L, 312D2, 312E, 312E L, 314D CR, 314D LCR, 314E LCR, PIN GRAB
3346558
BRACKET
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
3602676
BRACKET AS
316E L, 318E L
316E L, 318E L
3602702
BRACKET AS
316E L, 318E L
316E L, 318E L
3245732
BRACKET
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F ...
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F ...
3573885
BRACKET AS
312E, 312E L
312E, 312E L
3508095
BRACKET
316E L, 318E L
316E L, 318E L
3280401
BRACKET
312E, 312E L, 316E L, 318E L, 320E L, 320E LN, 320E LRR, 323E L, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E L, 349E L HVG, 349E L VG, 349F L, 374F L...
312E, 312E L, 316E L, 318E L, 320E L, 320E LN, 320E LRR, 323E L, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E L, 349E L HVG, 349E L VG, 349F L, 374F L...
3280186
BRACKET AS-BASE
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 34...
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 34...
3280060
BRACKET AS
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 34...
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 34...
3508105
BRACKET AS
316E L, 318E L
316E L, 318E L
3508102
BRACKET AS
316E L, 318E L
316E L, 318E L
1532447
BRACKET AS
120M 2, 12M 2, 12M 3, 12M 3 AWD, 140M 2, 140M 3, 140M 3 AWD, 160M 2, 160M 3, 160M 3 AWD, 16M, 312E, 312E L, 316E L, 318E L, 321D LCR, 345B II, 345B II MH, 345D, 345D L, 349D, 349D L, 365B, 365B II, 36...
120M 2, 12M 2, 12M 3, 12M 3 AWD, 140M 2, 140M 3, 140M 3 AWD, 160M 2, 160M 3, 160M 3 AWD, 16M, 312E, 312E L, 316E L, 318E L, 321D LCR, 345B II, 345B II MH, 345D, 345D L, 349D, 349D L, 365B, 365B II, 36...
3690022
BRACKET AS
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
3640350
BRACKET AS
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
3640278
BRACKET AS
312E, 312E L, 316E L, 318E L
312E, 312E L, 316E L, 318E L
3606284
BRACKET AS
316E L, 318E L
316E L, 318E L
3508116
BRACKET AS
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L