3340257 BUMPER Caterpillar parts
303.5C, 303.5D, 303.5E, 303C CR, 303E CR, 304C CR, 304D CR, 304E, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 306E, 307E, 308D, 308E, 308E CR, 308E SR, 308E2 CR
Rating:
Alternative (cross code) number:
CA3340257
334-0257
3340257
CA3340257
334-0257
3340257
Weight: 0.15 pounds 0 kg.
MINI HYD EXCAVATOR,
Compatible equipment models: 3340257:
Number on catalog scheme:
3
For full view, you need register
Information:
Illustration 1 g01321566
Transmission Solenoids are located on the left side of the transmission.
(1) "Transmission solenoid 1" (forward high)
(2) "Transmission solenoid 2" (forward low)
(3) "Transmission solenoid 3" (reverse)
(4) "Transmission solenoid 4" (2nd speed)
(5) "Transmission solenoid 5" (3rd speed)
(6) "Transmission solenoid 6" (1st speed)
(7) "Transmission solenoid 7" (low range)
(8) "Transmission solenoid 8" (high range)
Illustration 2 g02111493
Connections of the "Transmission Solenoid 4".
This diagnostic code is associated with the "Transmission Solenoid 4". The FMI 06 diagnostic code means that the "Transmission/Chassis ECM" has determined that the current of the solenoid circuit is above normal.Some possible causes of this diagnostic code are listed below:
The energize circuit of the solenoid is shorted to ground.
The ECM has failed. This is unlikely. Before performing this procedure, inspect the harness connectors that are involved in the circuit. Poor connections can often be the cause of a problem in an electrical circuit. Verify that all connections in the circuit are clean, that all connections are secure and that all connections are in good condition. If a problem with a connection is found, correct the problem and verify that this diagnostic code is active before performing this procedure. Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Note: The resistance of the solenoid coil should be 8.7 .4 ohms at 25 °C (77.0 °F).Test Step 1. CHECK THE SOLENOID
Turn the disconnect switch and the key start switch to the ON position. Do not start the engine.
Observe the status of the diagnostic code.
Disconnect the solenoid with the active diagnostic code from the machine harness. Expected Result:The active CID 1404 FMI 06 diagnostic code changes to a CID 1403 FMI 05 diagnostic code when the solenoid is disconnected.Results:
YES - The active CID 1404 FMI 06 diagnostic code changes to a CID 1404 FMI 05 diagnostic code when the solenoid is disconnected. The circuit is correct.Repair: The solenoid has failed. Repeat this test "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid.STOP
NO - The CID 1404 FMI 06 remains active when the solenoid is disconnected. The solenoid is not causing the problem. Proceed to Test Step 2.Test Step 2. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT TO GROUND
Turn the key start switch and the disconnect switch to the OFF position.
The solenoid remains disconnected from the machine harness.
Disconnect the machine harness connectors J1 and J2 from the "Transmission/Chassis ECM".
At the machine harness connectors for the ECM, measure the resistance from the contact J1-52 (wire 900-PU(Purple)) to frame ground. Measure the resistance from the contact J1-52 (wire 900-PU(Purple)) to all of the other J1 and J2 contacts that are used in the connectors of the "Transmission/Chassis ECM". Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - One or more of the resistance measurements is less than 5000 ohms.
Cat SIS web machinery list:
Parts bumper Caterpillar catalog:
3158672
BUMPER
312C, 312D, 315C, 315D L, 319C, 319D, 320C, 322C, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325D, 325D L, 329D L, 330C, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D,...
312C, 312D, 315C, 315D L, 319C, 319D, 320C, 322C, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325D, 325D L, 329D L, 330C, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D,...
1677062
BUMPER AS
318C, 320C, 320C FM, 320C L, 322C, 325C, 330C L
318C, 320C, 320C FM, 320C L, 322C, 325C, 330C L
1703015
BUMPER
312E, 312E L, 316E L, 318C, 318E L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 322C, 322C FM, 323D L, 323D LN, ...
312E, 312E L, 316E L, 318C, 318E L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 322C, 322C FM, 323D L, 323D LN, ...
2198277
BUMPER AS
318C, 345C, 345D, 345D L, 349D, 349D L
318C, 345C, 345D, 345D L, 349D, 349D L
2185199
BUMPER AS
318C, 320D, 320D L, 320D2, 320D2 L, 320E, 320E L, 323D L, 323D LN, 323D SA, 323D2 L
318C, 320D, 320D L, 320D2, 320D2 L, 320E, 320E L, 323D L, 323D LN, 323D SA, 323D2 L
1865614
BUMPER AS
318C, 320C, 320D L, 320D LRR, 320D RR, 320E LRR, 320E RR, 322C, 324D, 324D L, 324D LN, 324E L, 325C, 325C L, 325D, 325D L, 329D, 329D L, 329E, 329E L, 330C L, 330D, 330D L, 330D LN, 336D, 336D L, 336D...
318C, 320C, 320D L, 320D LRR, 320D RR, 320E LRR, 320E RR, 322C, 324D, 324D L, 324D LN, 324E L, 325C, 325C L, 325D, 325D L, 329D, 329D L, 329E, 329E L, 330C L, 330D, 330D L, 330D LN, 336D, 336D L, 336D...
2847081
BUMPER AS
315D L, 319D L, 319D LN
315D L, 319D L, 319D LN
2847077
BUMPER AS
312D, 312D L, 315D L, 319D L, 319D LN
312D, 312D L, 315D L, 319D L, 319D LN
2769254
BUMPER
303.5E, 304C CR, 304E, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 308E, 308E CR, 308E SR, 308E2 CR
303.5E, 304C CR, 304E, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 308E, 308E CR, 308E SR, 308E2 CR
5V3854
BUMPER
1090, 1190, 1190T, 1290T, 1390, 2290, 2390, 2391, 2491, 2590, 311C, 315B FM L, 320B FM LL, 322 FM L, 322 LN, 322B L, 324D L, 325, 325 L, 325B L, 330, 330 FM L, 330 L, 330B L, 330D, 330D FM, 330D L, 33...
1090, 1190, 1190T, 1290T, 1390, 2290, 2390, 2391, 2491, 2590, 311C, 315B FM L, 320B FM LL, 322 FM L, 322 LN, 322B L, 324D L, 325, 325 L, 325B L, 330, 330 FM L, 330 L, 330B L, 330D, 330D FM, 330D L, 33...
2787020
BUMPER
M313D, M315D, M315D 2, M316C, M316D, M317D 2, M318C, M318D, M318D MH, M322C, M322D, M322D MH
M313D, M315D, M315D 2, M316C, M316D, M317D 2, M318C, M318D, M318D MH, M322C, M322D, M322D MH
2748781
BUMPER
303.5C, 303.5D, 303.5E, 303C CR, 303E CR, 304C CR, 304D CR, 304E, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 307E, 308E, 308E CR, 308E SR, 308E2 CR
303.5C, 303.5D, 303.5E, 303C CR, 303E CR, 304C CR, 304D CR, 304E, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 307E, 308E, 308E CR, 308E SR, 308E2 CR