2892478 CLIP Caterpillar parts
420E, 430E, 613G, 914G, AP-300D, AP555E, BG500E, C3.3, C4.4, C6.6, CW-34, D3K XL, D4K XL, D5K LGP, IT14G, IT14G2, M313D, M315D, M315D 2, M317D 2, SPF343C
Rating:
Alternative (cross code) number:
CA2892478
289-2478
2892478
CA2892478
289-2478
2892478
Weight: 0.01 pounds 0 kg.
ASPHALT PAVER, WHEELED EXCAVATOR,
Compatible equipment models: 2892478:
Number on catalog scheme:
7
For full view, you need register
Information:
Illustration 1 g01118122
Schematic of the Solenoid Valve (Automatic Lubrication)
This diagnostic code is recorded when the ECM reads the voltage of the solenoid circuit as being above normal.The possible causes for this diagnostic code are listed:
The circuit of the solenoid is shorted to the + battery.
The solenoid has failed.
The ECM has failed. This is unlikely.Note: Ensure that the CID 0378 FMI 03 for the solenoid is active.System Response:The Autolube system may run continuously.Test Step 1. CHECK THE SOLENOID CIRCUIT FOR A SHORT TO THE + BATTERY.
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness from the solenoid.
Disconnect the machine harness connectors J1 and J2 from the ECM.
At machine harness connector J1 and J2, measure the resistance from the signal contact J1-10 (wire 801-PK(Pink)) to all contacts that are used in the machine harness connectors for the ECM. Expected Result:The resistance should be greater than 5000 ohms for each measurement.Results:
OK - The resistance is greater than 5000 ohms. The machine harness is correct. Proceed to test step 2.
NOT OK - The resistance is NOT correct. There is a short in the machine harness. The short is between signal contact J1-10 (wire 801-PK(Pink)) and the circuit with the low resistance measurement.Repair: Repair the harness or replace the harness.STOPTest Step 2. CHECK IF THE DIAGNOSTIC CODE REMAINS.
Inspect the contacts and clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Clear all inactive diagnostic codes.
Operate the machine.
Observe the status of CID 0378 FMI 03 for the solenoid. Expected Result:The CID 0378 FMI 03 for the solenoid is NOT present. Results:
OK - The diagnostic code is NOT present. The diagnostic code does not exist at this time. The initial diagnostic code was probably caused by a poor electrical connection or a short at one of the harness connectors that was disconnected and reconnected. Resume normal machine operation.STOP
NOT OK - The diagnostic code has not been corrected. The ECM may have failed.Repair: It is unlikely that the ECM has failed. Exit this procedure and perform this CID 0378 FMI 03 again. If the cause of the diagnostic code is not found, replace the ECM. See Testing and Adjusting, "Electronic Control Module (ECM) - Replace".STOP
Cat SIS web machinery list:
Parts clip Caterpillar catalog:
120M, 12M, 212, 2470C, 3054, 3054C, 320D GC, 320D L, 320D2, 320D2 L, 323D L, 553C, 613G, 924H, 924HZ, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP-800, AP1000E, AP1055E, BG600D, BG655D, C3.3, C4.4, C...
345C, 3512, 3512B, 3512C, 3516B, 3516C, 3618, 5110B, 5130, 5130B, 5230, 5230B, 525D, 535D, 545D, 555D, 621G, 621H, 621K, 623G, 623H, 623K, 623K LRC, 627G, 627H, 627K, 627K LRC, 631D, 631E, 631G, 633E ...
345C, 3512, 3512B, 3512C, 3516B, 3516C, 3618, 5110B, 5130, 5130B, 5230, 5230B, 525D, 535D, 545D, 555D, 621G, 621H, 621K, 623G, 623H, 623K, 623K LRC, 627G, 627H, 627K, 627K LRC, 631D, 631E, 631G, 633E ...
120H, 120H ES, 120H NA, 135H, 135H NA, 3114, 3116, 330D MH, 3406, 3406B, 3406C, 3406E, 3412, 3412C, 3412D, 3456, 375, 375 L, 5080, 518, 518C, 528, 572G, 583K, 814F II, 815F II, 816F II, 824G, 824G II,...
3408B, 3412, 3412E, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, C30, C32, PM3508, PM3512, PM3516, PP3516, SPF343, SPF343C, SPS343, SPT343, TH48-E80, TH55-E70
245, 245B, 245D, 3208, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 3618, 621, 621B, 623, 623B, 627, 627B, 631C, 657E, 814F, 814F II, 815F, 815F II, 816F, 816F I...
1090, 120, 120H, 120M, 120M 2, 12F, 12G, 12H, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 140, 140H, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14E, 14H, 14M, 16, 160H, 160M, 160M 2, 160M 3, 160M 3 AWD, 16...
10-20B, 120H, 120H ES, 120H NA, 120M, 120M 2, 12H, 12H ES, 12H NA, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 135H NA, 140H, 140H ES, 140H NA, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H NA, 14M, 160H, 160H ...
120H, 120M, 120M 2, 12H, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 140H, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H, 14M, 160H, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H, 16H, 16M, 24M, 345C, 345C L, 349E L H...
120M, 12M, 559, 613G, 924H, 924HZ, 928H, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP1000E, AP1055E, BG600D, BG655D, C6.6, CP-56, CP-64, CP-76, CS-56, CS-56B, CS-64, CS-68B, CS-74, CS-74B, CS-78B, D5...
303.5C, 303.5D, 303.5E, 303C CR, 303E CR, 304C CR, 304D CR, 304E, 305.5, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 306, 306E, 307B, 307C, 307D, 307E, 308C, 308D, 308E, 308E CR, 308E SR, 308E2 CR, 311B, ...
303.5, 304.5, 307C, 307D, 308C, 308D, 311B, 311C, 311D LRR, 311F LRR, 312B, 312B L, 312C, 312C L, 312D, 312D L, 312D2, 312D2 GC, 312D2 L, 312E, 312E L, 313B, 313D, 313D2, 313D2 LGP, 314C, 314D CR, 314...
120G, 12F, 12G, 130G, 140G, 14E, 14G, 16, 16G, 3406B, 416E, 416F, 420E, 420F, 422E, 422F, 428E, 428F, 430E, 430F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 5230, 5230B, 621, 623, 627, 631C, 637, 641, ...
2075370
CLIP
324D FM, 416E, 416F, 420E, 420F, 422E, 422F, 428E, 428F, 430E, 430F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 587R, 657G, 793F CMD, 826K, 953D, 963D, 973D, 980H, D10R, D6R II, D7R II
324D FM, 416E, 416F, 420E, 420F, 422E, 422F, 428E, 428F, 430E, 430F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 587R, 657G, 793F CMD, 826K, 953D, 963D, 973D, 980H, D10R, D6R II, D7R II
1090, 1190, 1190T, 120K, 120K 2, 120M, 1290T, 12K, 12M, 140K, 140K 2, 14M, 160K, 2290, 2390, 2391, 2491, 308D, 3412, 3412C, 3412E, 416E, 420E, 422E, 428E, 430E, 432E, 434E, 442E, 444E, 511, 521, 521B,...
12H, 1390, 140H, 143H, 160H, 163H, 24M, 2590, 312, 3126B, 315, 317, 320 L, 322 FM L, 416E, 420E, 430E, 5110B, 541, 541 2, 551, 552, 552 2, 611, 613G, 615C, 725, 730, 735, 740, 784B, 784C, 785B, 785C, ...
120M, 12M, 2590, 301.4C, 301.5, 301.7D, 301.7D CR, 302.2D, 302.4D, 302.5, 302.7D, 307, 318C, 319C, 320C, 320C FM, 325D L, 325D MH, 330D L, 345C, 345C L, 345C MH, 349F L, 385C, 385C FS, 385C L, 385C L ...
2018339
CLIP
416E, 420E, 430E, 953D, 963D
416E, 420E, 430E, 953D, 963D
12K, 12M, 140G, 140K, 140K 2, 140M, 140M 2, 160K, 160M, 160M 2, 432E, 442E, 770, 770G, 772, 772G, 772G OEM, 793F AC, 963D, 973D, C140-16, C32
2958141
CLIP
420F, 428E, 428F, 430F, 432E, 432F, 434F, 442E, 444F, 906H, 906H2, 907H, 907H2, 908H, 908H2, 910K, 914K
420F, 428E, 428F, 430F, 432E, 432F, 434F, 442E, 444F, 906H, 906H2, 907H, 907H2, 908H, 908H2, 910K, 914K
277C, 826H, 836H, 953D, 963D, 973D, 980H, 980K, 980K HLG, 980M, 982M, 993K, AP-600D, AP-655D, AP1000E, AP1055E, AP555E, BG1000E, BG1055E, BG500E, CB-214E, CB-22, CB-334E, CB-34, CB-534B, CB-534C, CB-5...
2243349
CLIP
3126E, 422E, 422F, 428E, 428F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, C32, C7, CD-54B, CP-433E, CP-44, CS-44, CS-533E
3126E, 422E, 422F, 428E, 428F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, C32, C7, CD-54B, CP-433E, CP-44, CS-44, CS-533E
1090, 1190, 1190T, 120H, 120H ES, 120H NA, 120M, 1290T, 12H, 12H ES, 12H NA, 12M, 135H, 135H NA, 140H, 140H ES, 140H NA, 140M 2, 143H, 14M, 160H, 160H ES, 160H NA, 160M 2, 163H NA, 2290, 2390, 2391, 2...
120H, 120M, 120M 2, 12H, 12K, 12M, 12M 2, 12M 3 AWD, 135H, 140H, 140K, 140K 2, 140M, 140M 2, 140M 3 AWD, 143H, 14H, 14M, 160H, 160K, 160M, 160M 2, 160M 3 AWD, 163H, 16H, 16M, 24M, 303, 303.5C, 304C CR...