7X7702 CONDUIT-FLEXIBLE Caterpillar parts
12M 2, 12M 3, 12M 3 AWD, 140M 2, 140M 3, 140M 3 AWD, 160M 2, 160M 3, 160M 3 AWD, 24H, 349E, 349E L, 349E L HVG, 349E L VG, 349F L, 422E, 428E, 428F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 446B, 568...
Rating:
Alternative (cross code) number:
CA7X7702
7X-7702
7X7702
CA7X7702
7X-7702
7X7702
Weight: 0.01 pounds 0 kg.
Information:
ID
23.35
mm
TYPE
000000000005
UNIT MEASURE
CM
ARTICULATED TRUCK, WHEELED EXCAVATOR,
Compatible equipment models: 7X7702:
Information:
Illustration 1 g01206575
Schematic of the Solenoid Valves (Ride Control)This diagnostic code is associated with the Ride Control Solenoid Valve #3. The FMI 05 means that the ECM has determined that the current of Ride Control Solenoid Valve #3 is below normal.The possible causes of the diagnostic code are listed:
The energizer circuit of Ride Control Solenoid Valve #3 is open.
The return circuit of Ride Control Solenoid Valve #3 is open.
Ride Control Solenoid Valve #3 has failed.
The ECM has failed. This is unlikely.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 2684 FMI 05 is active before performing this procedure.Note: Use the 146-4080 Digital Multimeter for the measurements in this procedure.System Response:When this diagnostic code occurs, the ride control function will stick in a balance position. The other two ride control solenoids are not energized. The operator does not have ride control that is independent of the switch setting.Test Step 1. CHECK THE SOLENOID.
Turn the disconnect switch and the key start switch to the ON position. Do not start the engine.
Disconnect Ride Control Solenoid Valve #3 from the machine harness.
At the machine harness connector for the solenoid, place a jumper wire from contact 2 to contact 1.
Observe the status of the CID 2684 FMI 05.Expected Result:The CID 2684 FMI 05 remains active. The FMI has not changed and the "05" is still active.Results:
YES - The diagnostic code remains active. The jumper wire does not affect the diagnostic code. Proceed to Test Step 2.
NO - The diagnostic is no longer active. The solenoid has failed.Repair: The solenoid has failed. Repeat this Test Step "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid. Verify that the new solenoid corrects the problem.STOPTest Step 2. CHECK THE HARNESS FOR AN OPEN
Turn the key start switch and the disconnect switch to the OFF position.
Ride Control Solenoid Valve #3remains disconnected from the machine harness.
Disconnect the machine harness connector(s) from the ECM.
At the machine harness connector for Ride Control Solenoid Valve #3, place a jumper wire from contact 2 to contact 1.
At the machine harness connector for the ECM, measure the resistance from J2-3 (wire A958-WH) to contact J2-4 (wire J815-BK).Expected Result:The resistance is less than 5.0 ohms.Results:
OK - The resistance is less than 5.0 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - The resistance is greater than 5000 ohms. The resistance measurement is not correct. There is an open circuit in the machine harness.Repair: The open is in wire A958-WH or in J815-BK. Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE IS STILL ACTIVE.
Inspect the contacts and clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Determine if the CID 2684 FMI 05 is active.Expected Result:The CID 2684 FMI 05
Cat SIS web machinery list:
Parts conduit Caterpillar catalog:
6V5817
CONDUIT-FLEXIBLE
216, 236, 267, 287, 3114, 3116, 3208, 320D2, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3408B, 3408C, 3412, 3412C, 3456, 35, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3606, 3608, 3612, 3616, 45...
216, 236, 267, 287, 3114, 3116, 3208, 320D2, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3408B, 3408C, 3412, 3412C, 3456, 35, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3606, 3608, 3612, 3616, 45...
6V5818
CONDUIT-FLEXIBLE
140G, 140M, 3054, 3056, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3456, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 963, 973, ...
140G, 140M, 3054, 3056, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3456, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 963, 973, ...
6V5819
CONDUIT-FLEXIBLE
307E, 308E, 308E CR, 308E SR, 308E2 CR, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612,...
307E, 308E, 308E CR, 308E SR, 308E2 CR, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612,...
2319895
CONDUIT-FLEXIBLE
3406C, 3412C, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 824K, 825K, 826K, 834K, 836K, 988K, AP-600D, AP-655D, AP555E, AS4251C, C175-16, C175-20, C18, C280-12,...
3406C, 3412C, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 824K, 825K, 826K, 834K, 836K, 988K, AP-600D, AP-655D, AP555E, AS4251C, C175-16, C175-20, C18, C280-12,...
5P0695
CONDUIT
120M, 215, 215B, 225, 225D, 227, 229, 231D, 235, 235B, 235C, 235D, 245, 245B, 245D, 24H, 3208, 325C, 325D MH, 3304, 3306, 3306B, 330B L, 330C MH, 345B, 345B II MH, 385C L MH, 5110B, 5130, 5130B, 515, ...
120M, 215, 215B, 225, 225D, 227, 229, 231D, 235, 235B, 235C, 235D, 245, 245B, 245D, 24H, 3208, 325C, 325D MH, 3304, 3306, 3306B, 330B L, 330C MH, 345B, 345B II MH, 385C L MH, 5110B, 5130, 5130B, 515, ...
5P1276
CONDUIT
215, 320B FM LL, 320C FM, 325B L, 325C, 325D MH, 3304, 3306, 330B L, 330C MH, 330D MH, 3406, 3412, 345B, 345B II MH, 345C MH, 365B, 365B II, 365C L MH, 375 L, 385C L MH, 5130, 5130B, 776C, 776D, 777D,...
215, 320B FM LL, 320C FM, 325B L, 325C, 325D MH, 3304, 3306, 330B L, 330C MH, 330D MH, 3406, 3412, 345B, 345B II MH, 345C MH, 365B, 365B II, 365C L MH, 375 L, 385C L MH, 5130, 5130B, 776C, 776D, 777D,...
5P0696
CONDUIT 61 cm(24.01 in.)
3304, 3306, 3406, 3412, 5110B, 627G, 637G, 826G II, 826H, 836G, 836H, D11R, D343, D7E, D7E LGP
3304, 3306, 3406, 3412, 5110B, 627G, 637G, 826G II, 826H, 836G, 836H, D11R, D343, D7E, D7E LGP
5P0694
CONDUIT
345B, 345B II MH, 385C L MH, 5130B, 5230, 561C, 561D, 583K, 814, 815, 816, 824B, 943, 953, 977K, 977L, 983B, 988, 992, D5, D5B, D6C, D6D, D7F, D7G, D8H, D9G, G3508, M325C MH, W345B II
345B, 345B II MH, 385C L MH, 5130B, 5230, 561C, 561D, 583K, 814, 815, 816, 824B, 943, 953, 977K, 977L, 983B, 988, 992, D5, D5B, D6C, D6D, D7F, D7G, D8H, D9G, G3508, M325C MH, W345B II
9X8705
CONDUIT-FLEXIBLE
561N, 904B, 950H, 953D, 962H, 966H, 972H, 973D, 980H, D10T2, D11T, D5N, D6K, D6K LGP, D6K XL, D6N, D6R III, D6T, D9T, IT62H, MH3037, MH3049, MH3059, PL61
561N, 904B, 950H, 953D, 962H, 966H, 972H, 973D, 980H, D10T2, D11T, D5N, D6K, D6K LGP, D6K XL, D6N, D6R III, D6T, D9T, IT62H, MH3037, MH3049, MH3059, PL61
2514514
CONDUIT
D6N
D6N
2514515
CONDUIT
D6K, D6K LGP, D6K XL, D6K2, D6K2 LGP, D6N, PL61
D6K, D6K LGP, D6K XL, D6K2, D6K2 LGP, D6N, PL61
3108320
CONDUIT
953D, 963D, D5R LGP, D6K, D6K LGP, D6K XL, D6K2 LGP, D6N, D6N LGP, D6N OEM, PL61
953D, 963D, D5R LGP, D6K, D6K LGP, D6K XL, D6K2 LGP, D6N, D6N LGP, D6N OEM, PL61
5N8360
CONDUIT-FLEXIBLE
3116, 3126, 3208, 3306, 3516, D6R, G3516, PM3516
3116, 3126, 3208, 3306, 3516, D6R, G3516, PM3516
6V5819
CONDUIT-FLEXIBLE
307E, 308E, 308E CR, 308E SR, 308E2 CR, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612,...
307E, 308E, 308E CR, 308E SR, 308E2 CR, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612,...
6V5818
CONDUIT-FLEXIBLE
140G, 140M, 3054, 3056, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3456, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 963, 973, ...
140G, 140M, 3054, 3056, 3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3412, 3412C, 3456, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 963, 973, ...
6V5817
CONDUIT-FLEXIBLE
216, 236, 267, 287, 3114, 3116, 3208, 320D2, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3408B, 3408C, 3412, 3412C, 3456, 35, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3606, 3608, 3612, 3616, 45...
216, 236, 267, 287, 3114, 3116, 3208, 320D2, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3408B, 3408C, 3412, 3412C, 3456, 35, 3508, 3508B, 3508C, 3512, 3512B, 3516, 3516B, 3606, 3608, 3612, 3616, 45...
4183946
CONDUIT GP-ELECTRICAL
C15 I6, C18 I6, C9
C15 I6, C18 I6, C9
4397923
CONDUIT GP-ELECTRICAL
XQC1600
XQC1600
1305724
CONDUIT
45, 55
45, 55
1305726
CONDUIT
45, 55
45, 55
1297628
CONDUIT
45, 55
45, 55
1305725
CONDUIT
45, 55
45, 55
8C5064
CONDUIT-FLEXIBLE
216B, 226B, 232B, 242B, 247B, 257B, 311C, 312C L, 315C, 318C, 320C, 320C FM, 320C L, 322C, 325C, 330C, 330C L, 3406E, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 35, 365C, 365C L, 36...
216B, 226B, 232B, 242B, 247B, 257B, 311C, 312C L, 315C, 318C, 320C, 320C FM, 320C L, 322C, 325C, 330C, 330C L, 3406E, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 35, 365C, 365C L, 36...
8C5063
CONDUIT-FLEXIBLE
24H, 303.5C, 303.5D, 303C CR, 304D CR, 305.5D, 305D CR, 307C, 308E, 308E2 CR, 311C, 311D LRR, 312D, 312D L, 312D2 L, 313D, 315D L, 318D L, 319D, 319D L, 319D LN, 320C, 320D, 320D FM, 320D FM RR, 320D ...
24H, 303.5C, 303.5D, 303C CR, 304D CR, 305.5D, 305D CR, 307C, 308E, 308E2 CR, 311C, 311D LRR, 312D, 312D L, 312D2 L, 313D, 315D L, 318D L, 319D, 319D L, 319D LN, 320C, 320D, 320D FM, 320D FM RR, 320D ...