1648270 CONTROL GP-ENGINE & HYD PUMP Caterpillar parts
315B L
Rating:
Alternative (cross code) number:
CA1648270
164-8270
1648270
CA1648270
164-8270
1648270
Weight: 9 pounds 4 kg.
EXCAVATOR,
Compatible equipment models: 1648270:
Number on catalog scheme:
4
For full view, you need register
Information:
Personal injury or death may result from failure to adhere to the following procedures.Fuel leaked or spilled onto hot surfaces or electrical components can cause a fire.Clean up all leaked or spilled fuel. Do not smoke while working on the fuel system.Turn the disconnect switch OFF or disconnect the battery when changing fuel filters.
Prime the fuel system in order to purge trapped air and in order to fill the fuel filter.
Illustration 1 g03355827
Fuel system priming pump switch
The switch for the fuel system priming pump is located near the hinge of the engine access door on the right-hand side of the machine. Open the right-hand engine access door in order to operate the fuel system priming pump switch.Note: The engine start switch must be in the OFF position in order to prime the fuel system.
Illustration 2 g03355843
(1) Primary fuel filter/water separator bleeder valve
(2) Primary fuel filter/water separator bleeder valve drain hose
Locate the primary fuel filter/water separator. The primary fuel filter/water separator is mounted on the inboard vertical surface of the fuel tank.
Direct the open end of primary fuel filter/water separator bleeder valve drain hose (2) into a suitable container. Open primary fuel filter/water separator bleeder valve (1) in order to allow air to be purged from the filter.
Hold the priming pump switch upward in order to activate the electric fuel priming pump. The priming pump will fill the engine fuel lines and the fuel filters with fuel.
As the air is purged from the fuel system, fuel pressure will increase.
Once the air is purged from the tank lines and the filter, close the bleeder valve on the primary fuel filter. Dispose of all fluids that are collected from the bleeder valve drain hose according to local regulations.
Listen for the electric fuel priming pump to come under load. Do not continue priming the fuel system after the priming pump is under load. Do not operate the priming pump for more than 2 minutes.
If the engine starts but the engine runs rough, continue to run the engine at low idle until the engine runs smoothly.
If the engine does not start after several attempts, consult your Cat dealer.
Caterpillar parts catalog:
Parts control Caterpillar catalog:
1582187
CONTROL GP-JOYSTICK
312B L, 315B L, 317B LN, 318B
312B L, 315B L, 317B LN, 318B
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 322C, 325B L, 325C, 330B L, 330C L, 330C MH, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
1501387
CONTROL GP-AIR & TEMPERATURE
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 385B, 5090B, 5110B, M325B, W330B, W345B II
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 385B, 5090B, 5110B, M325B, W330B, W345B II
312B L, 315B L, 317B LN, 318B, 320B, 322B LN, 325B L, 330B L, 345B L
1555847
CONTROL AR-AUXILIARY
315B L, 317B LN
315B L, 317B LN
2059855
CONTROL AR-BOOM
315B L, 317B LN
315B L, 317B LN
2059861
CONTROL AR-BOOM
315B L, 317B LN
315B L, 317B LN
1361017
CONTROL AR-COUPLER
315B L
315B L
1523144
CONTROL AR-COUPLER
315B L, 318B
315B L, 318B
311B, 312B L, 315B L, 317B LN, 318B, 320B, 320B FM LL, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 365B L, 385B, 5090B, 5110B, M325B, W330B, W345B II
1550303
CONTROL-MOTOR
315B L
315B L
311B, 312B L, 315B L, 317B LN, 318B, 320B, 320B FM LL, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 365B L, 385B, 5090B, 5110B, M325B, W330B, W345B II
1749106
CONTROL GP-HANDLE
312B L, 315B L, 317B LN, 318B, 320B, 322B LN, 325B L, 330B L, 345B II, 345B L, 365B, 365B II, 385B
312B L, 315B L, 317B LN, 318B, 320B, 322B LN, 325B L, 330B L, 345B II, 345B L, 365B, 365B II, 385B
2043560
CONTROL GP-AIR & TEMPERATURE
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
1501388
CONTROL GP-AIR CONDITIONER
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
312B L, 315B L, 317B LN, 318B, 320B, 322B L, 322B LN, 325B L, 330B L, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 385B, 5090B, 5110B, M325B, W330B, W345B II
1550304
CONTROL UNIT
317B LN, 318B
317B LN, 318B
1519367
CONTROL GP-ENG & HYD PUMP ELEK
317B LN, 318B
317B LN, 318B
2077393
CONTROL UNIT
315B L
315B L
1550303
CONTROL-MOTOR
315B L
315B L