CYLINDER PACK AS 10R8410 - Caterpillar

Failure to follow all safety guidelines prescribed in this document and by governing authorities and regulatory agencies may result in severe injury or death of personnel or machine damage.
Personal injury or death can result from improper maintenance procedures. To avoid injury or death, follow the procedures exactly as stated below.
Climbing equipment may be required to access this service point. Refer to the Operation and Maintenance Manual, "Mounting and Dismounting" topic for safety information.
Before servicing/performing maintenance on the machine, electrical power must be physically disconnected; battery plugs must be disconnected from the batteries, or the trailing cable must be unplugged, and warning tags and padlocks shall be applied by a certified electrician. Certified electricians shall perform or direct any electrical work, including any energized testing, repair work in controllers, motors, or other approved compartments, and shall insure that all compartments are properly closed and inspected prior to re-energization. All applicable lock out and tag out procedures must be followed.
Wiring Table
Table 1
Label Wire Id Wire End Signal Name
72 300 R-T1 PRIMARY FUEL TANK LEVEL LOW
73 301 R-T2 PRIMARY FUEL TANK LOW SHUTDOWN
74 302 R-T3 COOLANT LEVEL LOW
75 303 R-T4 COOLANT LEVEL LOW SHUTDOWN
76 304 R-T5 AIR SHUTOFF DAMPER CLOSED
77 305 R-T6 GEN BREAKER CLOSED
78 306 R-T7 UTILITY BREAKER CLOSED
79 307 R-T8 ATS IN NORMAL POSITION
80 308 R-T9 ATS IN EMERGENCY POSITION
81 309 R-T10 SPARE
82 310 R-T11 SPARE
83 311 R-T12 SPARE
84 312 R-T13 PRIMARY FUEL TANK LEVEL LOW
85 313 R-T14 PRIMARY FUEL TANK LOW SHUTDOWN
86 314 R-T15 COOLANT LEVEL LOW
87 315 R-T16 COOLANT LEVEL SHUTDOWN
88 316 R-T17 COOLANT TEMP HIGH N/O
89 317 R-T18 COOLANT TEMP HIGH N/C
90 318 R-T19 COOLANT TEMP HIGH COM
91 319 R-T20 COOLANT TEMP HIGH N/O
92 320 R-T21 OIL PRESSURE LOW N/C
93 321 R-T22 OIL PRESSURE LOW COM
94 322 R-T23 OIL PRESSURE LOW N/O
95 323 R-T24 COOLANT TEMP LOW N/C
96 324 R-T25 COOLANT TEMP LOW COM
97 325 R-T26 FUEL PUMP RELAY CUTOUT
98 326 R-T27 GENERATOR CONTROL NOT IN AUTO N/C
99 327 R-T28 GENERATOR CONTROL NOT IN AUTO COM
100 328 R-T29 GENERATOR CONTROL NOT IN AUTO N/O
101 329 R-T30 OIL PRESSURE LOW SHUTDOWN N/C
102 330 R-T31 OIL PRESSURE LOW SHUTDOWN COM
103 331 R-T32 OIL PRESSURE LOW SHUTDOWN N/O
104 332 R-T33 COOLANT TEMP HIGH SHUTDOWN N/C
105 333 R-T34 COOLANT TEMP HIGH SHUTDOWN COM
106 334 R-T35 COOLANT TEMP HIGH SHUTDOWN N/O
107 335 R-T36 ENGINE OVERCRANK N/C
108 336 R-T37 ENGINE OVERCRANK COM
109 337 R-T38 ENGINE OVERCRANK N/O
110 338 R-T39 ENGINE OVERSPEED N/C
111 339 R-T40 ENGINE OVERSPEED COM
CLNGND 200 R-T42 GROUND