3490089 GLASS Caterpillar parts
M313D, M315D, M316D, M318D, M318D MH, M322D, M322D MH, M325D L MH, M325D MH
Rating:
Alternative (cross code) number:
CA3490089
349-0089
3490089
CA3490089
349-0089
3490089
Weight: 22 pounds 10 kg.
EXCAVATOR, WHEELED EXCAVATOR,
Compatible equipment models: 3490089:
Number on catalog scheme:
6
For full view, you need register
Information:
Illustration 1 g01989834
Connections of the implement lockout solenoidThis diagnostic code is associated with the implement lockout solenoid. The FMI 03 means that the ECM has determined that the voltage of the solenoid circuit is above normal.The possible causes of this diagnostic code are listed below:
The solenoid has failed.
The energizer circuit of the solenoid is shorted to the +battery circuit.
The ECM has failed. This is unlikely. Note: The following test procedure may create other diagnostic codes. Clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 0882 FMI 03 is active before performing this procedure.Note: Use a digital multimeter for the measurements in this procedure.Test Step 1. CHECK THE SOLENOID CIRCUIT FOR A SHORT TO THE +BATTERY CIRCUIT
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness from the solenoid and the ECM.
At the machine harness connector for the ECM, measure the resistance from contact J1-24 (wire P988-OR) to all contacts that are used in the machine harness connectors for the ECM.Expected Result:Each resistance measurement should be greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 2.
NOT OK - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness. The short is between contact J1-24 (wire P988-OR) and the circuit with the low resistance measurement. Repair the machine harness or replace the machine harness.STOPTest Step 2. CHECK THE OPERATION OF THE ECMThe disconnect switch and the key start switch remain in the OFF position. The machine harness connectors for the solenoid and the ECM remain disconnected.
At the J1 connector for the ECM, use a wire removal tool to remove wire P988-OR from contact J1-24.
Reconnect the machine harness J1 and J2 connectors to the ECM.
Turn the disconnect switch and the key start switch to the ON position.
Observe the status of the active diagnostic code.Expected Result:The FMI 03 changes to an FMI 05 after the wire is disconnected.Results:
YES - The FMI 03 changes to a FMI 05 after the wire is disconnected. The ECM has responded correctly to the condition of an open circuit. Reinstall the disconnected wire to the correct space in the ECM connector before proceeding to the next Test Step. Proceed to Test Step 3.
NO - The FMI 03 remains active. The status of the active diagnostic code did not change when the wire was disconnected from the ECM.Repair: The ECM has not responded correctly to the condition of an open circuit. The operation of the ECM is not correct. Prior to replacing an ECM, always contact your dealership's Technical Communicator for possible consultation with Caterpillar. This consultation may greatly reduce repair time. If the ECM requires replacing, refer to Testing and Adjusting, "Electronic Control Module (ECM) - Replace".STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE IS STILL ACTIVE
Inspect the harness connectors. Clean the contacts of the harness connectors and check the wires for
Caterpillar parts catalog:
Parts glass Caterpillar catalog:
307C, 307D, 311C, 311D LRR, 311F LRR, 312C, 312C L, 312D, 312D L, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 315C, 315D L, 318C, 318D L, 318D2 L, 319C, 319D, 319D L, 320C, 320D, 320D FM, 320D G...
307C, 307D, 311C, 311D LRR, 312C L, 312D, 315C, 315D L, 318C, 319D L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D LRR, 320D RR, 322C, 323D L, 324D, 324D L, 325C, 325D, 325D L, 325D MH, 329D L, 330C L, ...
311D LRR, 311F LRR, 312C, 312C L, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315C, 315D L, 318C, 318D L, 318D2 L, 319C, 319D, 319D L, 320C, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR,...
312C, 315C, 318C, 319C, 319D, 320C, 322C, 323D L, 323D LN, 324D, 324D LN, 325C, 325D, 325D L, 329D L, 330C, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 3...
312C, 312D, 315C, 315D L, 318C, 319C, 319D, 320C, 322C, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325D, 325D L, 329D L, 330C, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L,...
311D LRR, 311F LRR, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315D L, 318D L, 318D2 L, 319D, 319D L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2 L, 323D L, 323D LN, 324D, 324D ...
311D LRR, 312D, 315D L, 319D L, 320D, 320D FM, 320D LRR, 320D RR, 323D L, 324D, 324D L, 325D, 325D L, 325D MH, 329D L, 330D, 330D L, 330D MH, 336D, 345C, 345C L, 345C MH, 345D, 345D L, 349D, 349D L, 3...
319D, 323D L, 323D LN, 324D, 324D LN, 325D, 325D L, 329D L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 385C, 385C L, M313D, M315D, M316D, M31...
312D, 315D L, 319D, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325D, 325D L, 329D L, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 37...
312D, 315D L, 319D, 323D L, 324D, 324D L, 324D LN, 325D, 325D L, 329D L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 374D L, 385C, 385C L, 385...
2521246
GLASS AS
323D L, 323D LN, 324D, 324D LN, 325D, 325D L, 330D, 330D L, 330D LN, 345C, 345C L, 365C, 365C L, 365C L MH, 385C, 385C FS, 385C L, M325D L MH, M325D MH, M330D
323D L, 323D LN, 324D, 324D LN, 325D, 325D L, 330D, 330D L, 330D LN, 345C, 345C L, 365C, 365C L, 365C L MH, 385C, 385C FS, 385C L, M325D L MH, M325D MH, M330D
2609296
GLASS
M325D L MH, M325D MH, M330D, MH3037, MH3049, MH3059
M325D L MH, M325D MH, M330D, MH3037, MH3049, MH3059
3457836
GLASS
M313D, M315D, M316D, M318D, M318D MH, M322D, M322D MH, M325D L MH, M325D MH
M313D, M315D, M316D, M318D, M318D MH, M322D, M322D MH, M325D L MH, M325D MH
312D, 315D L, 319D, 323D L, 324D, 324D L, 324D LN, 325D, 325D L, 329D L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 374D L, 385C, 385C L, 385...
312D, 315D L, 319D, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325D, 325D L, 329D L, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 37...
319D, 323D L, 323D LN, 324D, 324D LN, 325D, 325D L, 329D L, 330D, 330D L, 330D LN, 330D MH, 336D L, 336D LN, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 385C, 385C L, M313D, M315D, M316D, M31...
2627934
GLASS
312D, 315D L, 319D, 323D L, 323D LN, 324D, 324D LN, 325D, 325D L, 329D L, 330D, 330D L, 330D LN, 330D MH, 336D L, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 39...
312D, 315D L, 319D, 323D L, 323D LN, 324D, 324D LN, 325D, 325D L, 329D L, 330D, 330D L, 330D LN, 330D MH, 336D L, 345C, 345C L, 345D, 345D L, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 39...
311D LRR, 312D, 315D L, 319D L, 320D, 320D FM, 320D LRR, 320D RR, 323D L, 324D, 324D L, 325D, 325D L, 325D MH, 329D L, 330D, 330D L, 330D MH, 336D, 345C, 345C L, 345C MH, 345D, 345D L, 349D, 349D L, 3...
3836932
GLASS
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
3836929
GLASS
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
3836931
GLASS
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
3846534
GLASS
312D, 312D2 GC, 313D, 313D2, 318D L, 318D2 L, 320D GC, 320D2 GC
312D, 312D2 GC, 313D, 313D2, 318D L, 318D2 L, 320D GC, 320D2 GC
3836933
GLASS
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
312D, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 318D L, 318D2 L, 320D, 320D GC, 320D L, 320D2, 320D2 GC, 320D2 L, 323D L, 323D2 L, 324D, 326D L, 329D, 336D, 336D L, 336D2, 336D2 L, 340D L, 340...
3535917
GLASS
M313D, M315D, M316D, M318D, M318D MH, M322D, M322D MH
M313D, M315D, M316D, M318D, M318D MH, M322D, M322D MH