2602277 GUARD AS-TRACK GUIDE Caterpillar parts
324D, 324D L, 324E
Rating:
Alternative (cross code) number:
CA2602277
260-2277
2602277
CA2602277
260-2277
2602277
Weight: 105 pounds 47 kg.
EXCAVATOR,
Compare Prices: .
As an associate, we earn commssions on qualifying purchases through the links below
Number on catalog scheme:
1
For full view, you need register
Information:
Illustration 1 g06316858
Schematic of the "Transmission Solenoid Valve 5"
This diagnostic code is associated with the "Transmission Solenoid Valve 5". The FMI 06 diagnostic code means that the ECM has determined that there is a short to ground in the solenoid circuit.The possible causes of this diagnostic code are listed below:
The energize circuit of the solenoid is shorted to ground.
The solenoid has failed.
The Chassis ECM has failed. A failure of the ECM is unlikely.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 1405 FMI 06 is active before performing this procedure.Note: Use a Digital Multimeter for the measurements in this procedure.Test Step 1. CHECK THE SOLENOID.
Turn the disconnect switch and the key start switch to the ON position. Do not start the engine.
Observe the status of the diagnostic code.
Disconnect the solenoid with the active diagnostic code from the machine harness.Expected Result:The CID 1405 FMI 06 diagnostic code changes to a CID 1405 FMI 05 diagnostic code when the solenoid is disconnected.Results:
YES - The CID 1405 FMI 06 diagnostic code changes to a CID 1405 FMI 05 when the solenoid is disconnected. The circuit is correct.Repair: The solenoid has failed. Replace the solenoid. Verify that the new solenoid corrects the problem.STOP
NO - The CID 1405 FMI 06 diagnostic code remains active. Proceed to Test Step 2.Test Step 2. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT TO GROUND.
Turn the key start switch and the disconnect switch to the OFF position.
The solenoid remains disconnected from the machine harness.
Disconnect the machine harness connectors from the ECM.
At the machine harness connector, measure the resistance from the signal contact J1-51 (wire J834-PU(Purple)) to all contacts that are used in the machine harness connectors for the ECM.Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness. The short is between J1-51 (wire J834-PU(Purple)) and the circuit with the low-resistance measurement.Repair: Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE REMAINS.
Inspect the harness connectors. Clean the contacts of the harness connectors. Check the wires for damage to the insulation that is caused by excessive heat, battery acid, or chafing.
Perform a 45 N (10 lb) pull test on each of the wires that are associated with the circuit.
Reconnect all harness connectors. Make sure that the connectors are fully seated. Observe that the clips for each connector are fastened securely.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Check the status of the CID 1405 FMI 06 diagnostic code.Expected Result:The CID 1405 FMI 06 diagnostic code is active.Results:
YES - The CID 1405 FMI 06 is active. The diagnostic code has not been
Caterpillar parts catalog:
Parts guard Caterpillar catalog:
3168965
GUARD AS
312D L, 312E L, 315D L, 316E L, 318E L, 319D LN, 320D, 320D L, 324D L, 329D, 336D, 336E L, 345D L, 349D L
312D L, 312E L, 315D L, 316E L, 318E L, 319D LN, 320D, 320D L, 324D L, 329D, 336D, 336E L, 345D L, 349D L
3406511
GUARD AS
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E RR, 323D LN, 324D L, 324E, 324E L, 324E LN, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 32...
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E RR, 323D LN, 324D L, 324E, 324E L, 324E LN, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 32...
3423750
GUARD AS
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E RR, 323D LN, 324D L, 324E, 329D, 329E, 336D, 336E, 336E H, 345D L, 349D L, 349E
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E RR, 323D LN, 324D L, 324E, 329D, 329E, 336D, 336E, 336E H, 345D L, 349D L, 349E
3467438
GUARD
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LN, 336F L, 349E, 349E L, ...
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LN, 336F L, 349E, 349E L, ...
2302890
GUARD AS-RADIATOR
140G, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
140G, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2459181
GUARD AS-RADIATOR
140G, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
140G, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
320 L, 320B, 320B FM LL, 320C FM, 320E LN, 320E LRR, 320E RR, 320N, 322B L, 322C FM, 323D L, 323D LN, 323D SA, 323E L, 324E, 324E L, 324E LN, 325B, 325B L, 325C, 329E, 329E L, 329E LN, 330B L, 336E, 3...
3599416
GUARD AS-RADIATOR
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
3755701
GUARD AS
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
2602276
GUARD AS-TRACK GUIDE
324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 326D L
324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 326D L
2602278
GUARD AS-TRACK GUIDE
324D, 324D L, 324D LN, 324E, 324E L, 324E LN
324D, 324D L, 324D LN, 324E, 324E L, 324E LN
2742504
GUARD AS-CYLINDER
324D, 324D L, 324E
324D, 324D L, 324E
2602276
GUARD AS-TRACK GUIDE
324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 326D L
324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 326D L
3755701
GUARD AS
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
3599416
GUARD AS-RADIATOR
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
324D, 324D FM, 324D L, 325D, 325D FM, 325D L, 329D, 329D L
1029765
GUARD AR-FULL RECOIL
323D L, 324D LN, 325D, 325D L, 330D, 330D L, 330D LN, 336D L, 345C, 345C L, 365C, 365C L, 385C, 385C L
323D L, 324D LN, 325D, 325D L, 330D, 330D L, 330D LN, 336D L, 345C, 345C L, 365C, 365C L, 385C, 385C L
2459349
GUARD AS
320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 323D L, 323D LN, 323D SA
320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 323D L, 323D LN, 323D SA
2459348
GUARD AS
320D, 320D FM, 320D FM RR, 320D L, 320D LN, 320D LRR, 320D RR, 321C, 321D LCR, 323D L, 323D LN
320D, 320D FM, 320D FM RR, 320D L, 320D LN, 320D LRR, 320D RR, 321C, 321D LCR, 323D L, 323D LN
2459303
GUARD AS
345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, W345C MH
345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, W345C MH
3075121
GUARD
320D, 320D FM, 320D L, 320D LN, 320D LRR, 320D RR, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L
320D, 320D FM, 320D L, 320D LN, 320D LRR, 320D RR, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L
3321454
GUARD AS-WINDOW
324D, 324D L, 324D LN, 329D L, 336D L, 345C, 345C L, 345D L, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L
324D, 324D L, 324D LN, 329D L, 336D L, 345C, 345C L, 345D L, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L
2653521
GUARD AS
321C
321C
2742504
GUARD AS-CYLINDER
324D, 324D L, 324E
324D, 324D L, 324E
2602278
GUARD AS-TRACK GUIDE
324D, 324D L, 324D LN, 324E, 324E L, 324E LN
324D, 324D L, 324D LN, 324E, 324E L, 324E LN