2P1204 ALTERNATOR GROUP--Prestolite--24 Volt, 19 Ampere Part of 2P7836, 5C8661 & 6N5468 Alternator Groups shown on Pages 78, 78-2 & 78A 930

ELECTRICAL AND STARTING SYSTEM

ALTERNATOR GP-CHARGING

0. 2P-1204 ALTERNATOR
1. 6N-9294 ALTERNATOR
2. 9G-8255 ALTERNATOR
3. 9G-8255 ALTERNATOR
4. 7N-9720 ALTERNATOR
5. 7N-9720 ALTERNATOR
6. 3T-6352 ALTERNATOR
7. 3T-6352 ALTERNATOR
8. 9G-4574 ALTERNATOR
9. 9G-9538 ALTERNATOR
0. INFORMATION

WHEEL LOADER 930 WHEEL LOADER 79J
930 WHEEL LOADER 79J03733-UP (MACHINE) POWERED BY 3304 ENGINE HEBP1105 930 79J (1978)

ELECTRICAL AND STARTING SYSTEM

ALTERNATOR GP-CHARGING

3T-1888 ALTERNATOR GP-CHARGING

2P-1204 ALTERNATOR GP

6N-9294 ALTERNATOR GP-CHARGING

9G-8255 ALTERNATOR GP-CHARGING

#HEBP11050280

2P-1204: ALTERNATOR GP

ALTERNATOR GP

2P1204 ALTERNATOR GROUP--Prestolite--24 Volt, 19 Ampere
Part of 2P7836, 5C8661 & 6N5468 Alternator Groups shown on Pages 78, 78-2 & 78A

c218595 HEBP1105

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	031-0243	[3]	SCREW
2.	6N-3821 C	[1]	REGULATOR ASSEM.
	3K-6234	[1]	SCREW
	4B-4863	[1]	WASHER
3.	009-8708	[2]	BOOT
4.	2L-8076	[1]	TERMINAL
5.	2L-8077	[1]	TERMINAL
6.	1P-1091 J		KIT (Reg. Mounting Plate and Gasket)
7.	1P-1145	[1]	HOLDER ASSEM.
	1P-1137	[1]	HOLDER
8.	4B-2049	[4]	NUT
	3B-4502	[4]	LOCKWASHER
9.	1P-1138	[1]	FIELD TERMINAL AND PLATE ASSEM.
10.	5S-4245	[2]	SCREW
	6B-4542	[2]	LOCKWASHER
11.	4B-4274	[1]	WASHER
12.	1P-1130 J	[1]	KIT (2 Brushes)
13.	032-4000 C	[4]	SCREW
14.	2P-1714 J	[1]	KIT (4 Gaskets)
15.	1P-1080 J	[1]	KIT (Retainer and Seals)
16.	6N-6717 CJ	[1]	KIT (Terminal Stud and Insulator)
17.	2P-1709	[1]	RECTIFIER AND STATOR ASSEM.
18.	2P-1719	[1]	PLATE AND RECTIFIER ASSEM. (Positive)
	2P-1720	[1]	PLATE AND RECTIFIER ASSEM. (Negative)
19.	6N-1226 C	[1]	ROTOR ASSEM.
20.	1B-8705	[1]	KEY
21.	3B-4502	[10]	LOCKWASHER
22.	6N-5255 C	[1]	HEAD ASSEM.
23.	6D-9953	[2]	PIN
24.	5L-6326 C	[1]	BEARING
25.	2P-1713 J	[1]	KIT (Retainer, Seal and Spacer)
26.	017-2311	[3]	SCREW
27.	9M-5520	[1]	SCREW
28.	3B-4511	[1]	LOCKWASHER
29.	1P-1131 J	[1]	KIT (Shaft Parts-Nut and Lockwasher)
30.	2L-0611	[1]	BEARING
31.	1P-1134	[1]	RACE
32.	6N-5257 CJ	[1]	KIT (Frame Screw-4 Screws)
33.	6N-5254 C	[1]	HEAD ASSEM.
34.	3B-4507	[2]	LOCKWASHER 11.11 mm(.4375 in.)I.D.
	3B-4504	[2]	LOCKWASHER 6.35 mm(.25 in.)I.D.
35.	1D-4718	[2]	NUT 11.11 mm(.4375 in.)I.D
	9M-1311	[2]	NUT 6.35 mm(.25 in.)I.D.
36.	1P-1088 J	[1]	KIT (2 Brush Springs)
37.	2P-6261 C	[2]	INSULATOR
38.	2H-6139	[4]	LOCKWASHER
	C		INDICATES CHANGE
	J		REPAIR KITS AVAILABLE

#HEBP11050281

6N-9294: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

6N9294 ALTERNATOR GROUP--24 Volt, 35 Ampere
Serial No. 79J8739-Up. Part of 6N5468 Alternator Group shown on Page 78A-1

HEBP11050281 HEBP1105

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Part No	Qty	Parts name
9G-8255 Y	[1]	ALTERNATOR GROUP--DELCO-REMY
		- or -
3T-6352 Y	[1]	ALTERNATOR GROUP--DELCO-REMY
		- or -
7N-9720 Y	[1]	ALTERNATOR GROUP
		- or -
9G-4574 Y	[1]	ALTERNATOR GROUP--NIPPON DENSO
Y		SEPARATE ILLUSTRATION

#HEBP11050282

9G-8255: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

9G8255 ALTERNATOR GROUP--24 Volt, 35 Ampere--Delco-Remy--Part 1
Serial No. 79J8739-Up
Part of 6N9294 Alternator Group listed on Page 82-1

c228795 HEBP1105

9G8255 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	5P-6920	[1]	BEARING-ROLLER
2.	7N-7806	[1]	COIL AS-FIELD
3.	7N-7804	[1]	STATOR AS
4.	7N-7795	[1]	COLLAR
5.	7N-7810	[1]	FRAME AS-DRIVE END
6.	5P-9514	[1]	BALL BEARING
7.	9L-2140	[1]	PLATE
8.	9L-6782	[1]	SHIELD-DUST
9.	7N-7800	[1]	ROTOR AS
10.	2K-4821	[1]	LOCKNUT
11.	7F-7621	[1]	WASHER
12.	9L-6783	[1]	COLLAR
13.	9L-2139	[1]	WASHER-FELT
14.	9N-1210	[1]	FAN AS
15.	7N-9020	[3]	SCREW AS
16.	9L-2137	[1]	RETAINER AS
17.	7N-7122	[1]	RECTIFIER AS
18.	9S-2396	[1]	BUSHING
19.	9S-2007	[4]	SCREW-LOCKING
20.	7N-7809	[1]	PLATE
21.	7N-7805	[1]	HOUSING
22.	7N-9024	[4]	BOLT

#HEBP11050283

9G-8255: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

9G8255 ALTERNATOR GROUP--24 Volt, 35 Ampere--Delco-Remy--Part 2
Serial No. 79J8739--Up
Part of 6N9294 Alternator Group listed on Page 82-1

c228796 HEBP1105

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	7N-7807	[1]	TERMINAL KIT (output)
			(Includes Insulator, Screw, Washers, Lockwasher, Nut and Adapter)
2.	7N-7808	[1]	TERMINAL KIT
			(Includes Stud, Bushings, Washers and Nut Assem.)
3.	9L-6770	[1]	CAP
4.	8N-0740	[5]	SCREW ASSEM.
5.	7N-9022	[2]	SCREW ASSEM.
	9N-0938	[2]	WASHER
6.	7N-9023	[2]	SCREW ASSEM.
7.	7N-7799	[1]	REGULATOR ASSEM.
8.	6N-1869	[4]	NUT ASSEM.
9.	7N-7811	[1]	CONNECTOR
10.	7N-9018	[3]	SCREW ASSEM.
11.	9N-1202	[1]	DIODE ASSEM.
12.	7N-7797	[2]	INSULATOR
13.	7N-9021	[1]	SCREW ASSEM.
	7N-7796	[1]	BUSHING
14.	7N-7802	[1]	CAPACITOR ASSEM.
	3N-4082	[1]	BRACKET
15.	7N-7798	[1]	CONNECTOR
16.	7N-7801	[1]	CONNECTOR

#HEBP11050284

7N-9720: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

7N9720 ALTERNATOR GROUP--24 Volt, 35 Ampere--Type 1
Serial No. 79J8739--Up
Part of 6N9294 Alternator Group listed on Page 82-1

c309353 HEBP1105

7N9720 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	9G-7551	[1]	BEARING
2.	9G-7548	[1]	RING
3.	9G-7558	[1]	COIL AS-FIELD
4.	9G-7560	[1]	ROTOR AS
5.	9G-7553	[1]	RING-COVER
6.	9G-7562	[1]	COVER AS
7.	9G-7567	[1]	REGULATOR AS
8.	9G-7552	[1]	BEARING
9.	9G-7557	[1]	SCREW AS
10.	9G-7568	[1]	FRAME AS-REAR
11.	9G-7563	[1]	DIODE AS
12.	9G-7561	[1]	STATOR AS
13.	9G-7566	[1]	FRAME-DRIVE END
14.	9G-7564	[1]	FAN
15.	9G-7549	[1]	SPACER
16.	2K-4821	[1]	LOCKNUT
17.	3T-5962 C	[1]	PLATE-IDENTIFICATION
18.	2H-3880 C	[2]	SCREW-DRIVE
19.	3B-4510 C	[1]	LOCKWASHER
20.	1B-8705 C	[1]	KEY-WOODRUFF

			THE FOLLOWING REPAIR
			KITS ARE AVAILABLE:
	9G-7554	[1]	KIT-TERMINAL GROUND
			(INCL NUTS AND
			LOCKWASHERS)
	9G-7555	[1]	KIT-TERMINAL OUTPUT
			(INCL NUTS, WASHERS
			AND BUSHINGS)
	9G-7556	[1]	KIT-CAPACITOR
			(INCL CAPACITOR,
			SCREW, LOCKWASHER
			AND WASHER)
	9G-7559	[1]	KIT-TERMINAL RELAY
			(INCL SPLICE,TUBE,
			NUT, TERMINAL,
			LOCKWASHER, WASHERS
			AND BUSHING)
	9G-7565	[1]	KIT-TERMINAL REGULATOR
			(INCL NUTS, LOCKWASHERS,
			WASHERS & BUSHING)
	C		CHANGE FROM PREVIOUS TYPE

#HEBP11050285

7N-9720: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

7N9720 ALTERNATOR GROUP--24 Volt, 35 Ampere--Type 2
Serial No. 79J8739--Up
Part of 6N9294 Alternator Group listed on Page 82-1

c303085 HEBP1105

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	9G-7551	[1]	BEARING
2.	9G-7548	[1]	RING
3.	9G-7558	[1]	COIL AS-FIELD
4.	9G-7560	[1]	ROTOR AS
5.	9G-7553	[1]	RING-COVER
6.	9G-7562	[1]	COVER AS
7.	9G-7567	[1]	REGULATOR AS
8.	9G-7552	[1]	BEARING
9.	9G-7557 C	[4]	SCREW AS
10.	9G-7568	[1]	FRAME AS-REAR
11.	3T-1887 C	[1]	DIODE AS
12.	9G-7561	[1]	STATOR AS
13.	9G-7566	[1]	FRAME-DRIVE END
14.	9G-7564	[1]	FAN
15.	9G-7549	[1]	SPACER
16.	2K-4821	[1]	LOCKNUT
17.	3T-5962	[1]	PLATE-IDENTIFICATION
18.	2H-3880	[2]	SCREW-DRIVE
19.	3B-4510	[1]	LOCKWASHER
20.	1B-8705	[1]	KEY-WOODRUFF






			THE FOLLOWING REPAIR
			KITS ARE AVAILABLE:
	9G-7554	[1]	KIT-TERMINAL GROUND
			(INCL NUTS AND
			LOCKWASHERS)
	9G-7555	[1]	KIT-TERMINAL OUTPUT (OUTPUT)
			(INCL NUTS, WASHERS AND
			BUSHINGS)
	9G-7556	[1]	KIT-CAPACITOR
			(INCL CAPACITOR, SCREW,
			LOCKWASHER & WASHER)
	9G-7559	[1]	KIT-TERMINAL RELAY (RELAY)
			(INCL SPLICE, TUBE,
			NUT, TERMINAL,
			LOCKWASHERS, WASHERS
			AND BUSHING)
	9G-7565	[1]	KIT-TERMINAL REGULATOR (REGULATOR)
			(INCL NUTS, LOCKWASHERS,
			WASHERS AND BUSHING)
	C		CHANGE FROM PREVIOUS TYPE

#HEBP11050286

3T-6352: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

3T6352 ALTERNATOR GROUP--Delco-Remy--24 Volt, 35 Ampere--Part 1
Serial No. 79J8739--Up
Part of 6N9294 Alternator Group listed on Page 82-1

c235181 HEBP1105

3T6352 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	5P-6920	[1]	BEARING-ROLLER
2.	7N-7806	[1]	COIL AS-FIELD
3.	7N-7804	[1]	STATOR AS
4.	7N-7795	[1]	COLLAR
5.	7N-7810	[1]	FRAME AS-DRIVE END
6.	5P-9514	[1]	BALL BEARING
7.	9L-2140	[1]	PLATE
8.	9L-6782	[1]	SHIELD-DUST
9.	7N-7800	[1]	ROTOR AS
10.	2K-4821	[1]	LOCKNUT
11.	7F-7621	[1]	WASHER
12.	9L-6783	[1]	COLLAR
13.	9L-2139	[1]	WASHER-FELT
14.	9N-1210	[1]	FAN AS
15.	7N-9202	[3]	SCREW AS
16.	9L-2137	[1]	RETAINER AS
17.	7N-7122	[1]	RECTIFIER AS
18.	9S-2396	[1]	BUSHING
19.	9S-2007	[4]	SCREW-LOCKING
20.	7N-7809	[1]	PLATE
21.	7N-7805	[1]	HOUSING
22.	7N-9024	[4]	BOLT

#HEBP11050287

3T-6352: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

3T6352 ALTERNATOR GROUP--Delco-Remy--24 Volt, 35 Ampere--Part 2
Serial No. 79J8739-Up
Part of 6N9294 Alternator Group listed on Page 82-1

c304807 HEBP1105

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	7N-7807	[1]	TERMINAL KIT (output)
			(Includes Insulator, Screw, WASHERS, LOCKWASHER, NUT & ADAPTER)
2.	7N-7808	[1]	TERMINAL KIT
			(Includes Stud, Bushings, WASHERS & NUT ASSEM.)
3.	9L-6770	[1]	CAP
4.	8N-0740	[5]	SCREW ASSEM.
5.	6N-1872 C	[2]	SCREW ASSEM.
	9N-0938	[2]	WASHER 11.17mm(.44 in.)O.D.
6.	7N-9023	[2]	SCREW ASSEM.
7.	3T-6353	[1]	REGULATOR ASSEM.
8.	6N-1869	[4]	NUT ASSEM.
9.	7N-7811	[1]	CONNECTOR
10.	7N-9018	[3]	SCREW ASSEM.
11.	9N-1202	[1]	DIODE ASSEM.
12.	7N-7797	[2]	INSULATOR
13.	7N-9021	[1]	SCREW ASSEM.
	7N-7796	[1]	BUSHING
14.	7N-7802	[1]	CAPACITOR ASSEM.
	3N-4082	[1]	BRACKET
15.	7N-7798	[1]	CONNECTOR
16.	7N-7801	[1]	CONNECTOR
17.	5L-4426 C	[1]	NUT
	3B-4504 C	[1]	LOCKWASHER
	3P-9901 C	[1]	WASHER
18.	3H-0240 C	[2]	WASHER 9.65mm(.38 in.)O.D.
	C		INDICATES CHANGE

#HEBP11050288

9G-4574: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

9G4574 ALTERNATOR GROUP--24 Volt, 35 Ampere
Serial No. 79J8739-Up. Part of 6N9294 Alternator

c335872 HEBP1105

9G4574 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	2K-4821	[1]	LOCKNUT
	5P-8247	[1]	WASHER-HARD
2.	1B-8705	[1]	KEY-WOODRUFF
3.	7T-2793	[1]	FAN AS
4.	7T-2792	[1]	FRAME AS
5.	7T-2794	[1]	STATOR AS
6.	7T-2790	[1]	ROTOR AS
7.	7T-2791	[1]	COIL AS
8.	7T-2798	[1]	REGULATOR AS
9.	7T-2797	[1]	COVER
10.	7T-2796	[1]	HOLDER AS
11.	7T-2795	[1]	FRAME AS
12.	7T-2801	[1]	CONDENSER
13.	9L-6770	[1]	CAP
14.	7T-2802	[1]	WIRE AS

			THE FOLLOWING REPAIR
			KITS ARE AVAILABLE:
	7T-2800	[1]	KIT-TERMINAL (POSITIVE)
			(INCLUDES INSULATORS,
			NUTS, LOCKWASHERS
			& WASHERS)
	7T-2804	[1]	KIT-TERMINAL (RELAY)
			(INCL. WIRE AS., CAP,
			BOLT & INSULATOR)

	7T-2805	[1]	KIT-TERMINAL (NEGATIVE)
			(INCLUDES INSULATORS,
			NUTS, WASHERS,
			AND LOCKWASHERS
	7T-2799	[1]	KIT-BEARING
	7T-2803	[1]	KIT-HARDWARE
			(INCL. SCREW AS.
			& BOLT AS.)
	7T-2816	[1]	KIT-HARDWARE
			(INCL. PLATE AS., PLATE,
			BOLT AS., WASHERS,
			SPACERS & RING)

#HEBP11050289

9G-9538: ALTERNATOR GP-CHARGING

ALTERNATOR GP-CHARGING

9G9538 ALTERNATOR GROUP--24 Volt, 50 Ampere
Part of 5S9088 Alternator. AN ATTACHMENT

c328673 HEBP1105

9G9538 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your 930 WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	9G-7551	[1]	BEARING
2.	9G-7548	[1]	RING
3.	3T-1885	[1]	COIL AS.
4.	9G-7560	[1]	ROTOR AS.
5.	9G-7553	[1]	RING
6.	9G-7562	[1]	COVER AS.
7.	9G-7567	[1]	REGULATOR AS.
8.	9G-7552	[1]	BEARING
9.	9G-7557	[4]	SCREW AS.
10.	9G-7568	[1]	FRAME AS.
11.	3T-1887	[1]	DIODE AS.
12.	3T-1886	[1]	STATOR AS.
13.	9G-7566	[1]	FRAME
14.	9G-7564	[1]	FAN
15.	9G-7549	[1]	SPACER
16.	2K-4821	[1]	LOCKNUT
		[1]	WASHER
17.	3T-5962 C	[1]	NAMEPLATE
18.	2H-3880 C	[2]	SCREW (DRIVE)
19.	5P-8247 C	[1]	WASHER
20.	1B-8705 C	[1]	KEY
21.	9L-6770 C	[1]	CAP
			THE FOLLOWING REPAIR KITS ARE AVAILABLE:
	9G-7554	[1]	KIT (GROUND TERMINAL)
			(INCL. NUTS AND LOCKWASHERS)
	9G-7555	[1]	KIT (OUTPUT TERMINAL)
			(INCL. NUTS, WASHERS AND BUSHINGS)
	9G-7556	[1]	KIT (CAPACITOR)
			(INCL. CAPACITOR, SCREW, LOCKWASHER AND WASHER)
	9G-7559	[1]	KIT (RELAY TERMINAL)
			(INCL. SPLICE, TUBE, NUT, TERMINAL, LOCKWASHER, WASHERS AND BUSHING)
	9G-7565	[1]	KIT (REGULATOR TERMINAL)
			(INCL. NUTS, LOCKWASHERS, WASHERS AND BUSHING)
	C		INDICATES CHANGE