AVSPARE.COM
parts catalog

HOSE AS 2608316 - Caterpillar


2608316 HOSE AS Caterpillar parts 315D L, 318D L, 318D2 L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 323D L, 323D LN, 323D SA, 323D2 L, 323E L
Rating:
27
Alternative (cross code) number:
CA2608316
260-8316
2608316
Caterpillar 2608316 HOSE AS
Weight: 6 pounds 2 kg.

Buy HOSE AS 2608316 Caterpillar genuine, new aftermarket tractor parts with delivery
EXCAVATOR,

Number on catalog scheme: 2
  For full view, you need register

Information:


Illustration 9 g03414066
Typical example of the P1 pin location for the sensor supply (30) Ground (56) 8 VDC supply (64) Ground (72) 5 VDC supply
Illustration 10 g03130497
Typical example of the pin locations for the 5 VDC supply on the P2 connector (1) 5 VDC supply (10) Ground
Table 2
Troubleshooting Test Steps    Values    Results    
1. Check for Connector Damage
A. Turn the keyswitch to the OFF position.
B. Check the connectors and the harness for the following faults:
Damage
Abrasion
Corrosion
Incorrect attachment
C. Refer to Troubleshooting, "Electrical Connectors - Inspect".
D. Perform a
45 N (10 lb) pull test on each of the wires in the harness that are associated with the throttle position sensors. Check the wire connectors for all the sensors on the sensor supply circuits.
E. Check the screws for the ECM connectors for the correct torque of
6 N m (53 lb in).
   
Connector fault    
Result: Found damage, abrasion, corrosion, or incorrect attachment.
Repair the connectors or the harness and/or replace the connectors or the harness.
Use the electronic service tool in order to clear all logged diagnostic codes and then verify that the repair eliminates the fault.
Result: No faults found
Proceed to Test Step 2.
   
2. Check for Active Diagnostic Codes
A. Connect the electronic service tool to the diagnostic connector.
B. Turn the keyswitch to the ON position.
C. Use the electronic service tool in order to monitor the diagnostic codes. Check and record any active diagnostic codes.
Note: Wait at least 15 seconds in order for the diagnostic codes to become active.
   
Diagnostic codes
   
Result: One or more of the diagnostic codes listed in Table 1 is active or recently logged.
Proceed to Test Step 3.
Result: None of the previous diagnostic codes are active.
The fault may be intermittent. Proceed to Test Step 7.
   
3. Disconnect the Sensors One at a Time
A. Turn the keyswitch to the OFF position.
B. For a 3509-X diagnostic code, disconnect the sensors on the 5 VDC supply circuit on the J2/P2 connector one at a time. Refer to Illustration 2. Wait for 30 seconds after each sensor is disconnected. Use the electronic service tool in order to monitor the diagnostic codes.
For a 3510-X diagnostic code, disconnect the analog throttle position sensors (if equipped) one at a time. Also, disconnect the aftertreatment ID module any other sensors that are connected to the 5 VDC supply on the P1 connector. Wait for 30 seconds after each sensor is disconnected. Use the electronic service tool in order to monitor the diagnostic codes.
For a 678-X diagnostic code, disconnect the digital throttle position sensors (if equipped) one at a time. Also, disconnect any other sensors that are connected to the 8 VDC supply on the P1 connector. Wait for 30 seconds after each sensor is disconnected. Use the electronic service tool in order to monitor the diagnostic codes.
Note: The sensor supply diagnostic will become inactive when the sensor that caused the diagnostic code is disconnected.
C. Ensure that all the sensors on the suspect sensor supply circuit are disconnected.
   
Diagnostic code inactive    
Result: The 3509 or 3510 is inactive when

Cat SIS web machinery list:

Caterpillar parts catalog
323 Excavator BR900001-UP (MACHINE) POWERED BY C7.1 Engine
320 Excavator BR600001-UP (MACHINE) POWERED BY C7.1 Engine
320 GC Excavator BR400001-UP (MACHINE) POWERED BY C4.4 Engine
323F LN Mobile Hydraulic Power Unit RGP00001-UP (MACHINE) POWERED BY C4.4 Engine
320 Excavator YBP00001-UP (MACHINE) POWERED BY C7.1 Engine
320 GC Excavator ZBT00001-UP (MACHINE) POWERED BY C4.4 Engine
320D3 Excavator ESX00001-UP (MACHINE) POWERED BY ALUW06DTI Engine
323D3 Excavator FEY00001-UP (MACHINE) POWERED BY C7.1 Engine
320 & 320 GC Excavators XBJ00001-UP (MACHINE) POWERED BY C4.4 Engine
320D2 Excavator XBA00001-UP (MACHINE) POWERED BY C7.1 Engine
323D2 L Excavator JEX00001-UP (MACHINE) POWERED BY C7.1 Engine
323F L Excavators KBY00001-UP (MACHINE) POWERED BY C7.1 Engine
320F L Excavator NHD00001-UP (MACHINE) POWERED BY C4.4 Engine
538 Forest Machine General Forestry HBS00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 GC Excavator YBJ00001-UP (MACHINE) POWERED BY C4.4 Engine
538 Forest Machine General Forestry GMY00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators YBK00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 Excavator WBY00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators TGJ00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator SGB00001-UP (MACHINE) POWERED BY C4.4 Engine
323F LN Excavator YEC00001-UP (MACHINE) POWERED BY C4.4 Engine
323F SA Excavator FA200001-10100 (MACHINE) POWERED BY C4.4 Engine
323F SA Mobile Hydraulic Power Unit P7P00001-UP (MACHINE) POWERED BY C4.4 Engine
320D2 & 320D2 L Excavators ESG00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 L Excavator XCC00001-UP (MACHINE) POWERED BY C7.1 Engine
320 GC Excavator KTN00001-UP (MACHINE) POWERED BY C4.4 Engine
323 Excavator RAZ00001-UP (MACHINE) POWERED BY C7.1 Engine
320 Excavator ZBN00001-UP (MACHINE) POWERED BY C7.1 Engine
320 GC Excavator DKJ00001-UP (MACHINE) POWERED BY C4.4 Engine
323 Excavator YBL00001-UP (MACHINE) POWERED BY C7.1 Engine
320 Excavator HEX00001-UP (MACHINE) POWERED BY C4.4 Engine
323F LN Excavator MFY00001-UP (MACHINE) POWERED BY C4.4 Engine
323 Excavator DWF00001-UP (MACHINE) POWERED BY C7.1 Engine
323F LN Excavator FA210101-UP (MACHINE) POWERED BY C4.4 Engine
323D & 323D L Excavator SDC00001-UP (MACHINE) POWERED BY 3066 Engine
323D LN & 323D S Excavators CYD00001-UP (MACHINE) POWERED BY 3066 Engine
320D & 320D L Excavators CXY00001-UP (MACHINE) POWERED BY 3066 Engine
323D L Excavator JLG00001-UP (MACHINE) POWERED BY C6.4 Engine
320D FM Forest Swing Machine CYZ00001-UP (MACHINE) POWERED BY C6.4 Engine
320D RR FM Forest Swing Machine SRT00001-UP (MACHINE) POWERED BY 3066 Engine
323D L Excavator PBM00001-UP (MACHINE) POWERED BY 3066 Engine
315D L Excavator CJN00001-UP (MACHINE) POWERED BY C4.2 Engine
320D & 320D L Excavators MCH00001-UP (MACHINE) POWERED BY C6.4 Engine
320D & 320D L Excavators FAL00001-UP (MACHINE) POWERED BY C6.4 Engine
315D L Excavator NCM00001-UP (MACHINE) POWERED BY C4.2 Engine
323D LN & 323D S Excavators RAC00001-UP (MACHINE) POWERED BY C6.4 Engine
320D & 320D L Excavators JGZ00001-UP (MACHINE) POWERED BY 3066 Engine
320D Forest Machines BZF00001-UP (MACHINE) POWERED BY C6.4 Engine
323D L Excavator BYM00001-UP (MACHINE) POWERED BY C6.4 Engine
320D & 320D L Excavators A6F00001-UP (MACHINE) POWERED BY C6.4 Engine
320D L Excavator A9F00001-UP (MACHINE) POWERED BY C6.4 Engine
320D FM Forest Swing Machine BWW00001-UP (MACHINE) POWERED BY C6.4 Engine
315D L Excavator KBD00001-UP (MACHINE) POWERED BY C4.2 Engine
320D & 320D L Excavators JFZ00001-UP (MACHINE) POWERED BY C6.4 Engine
323D L Excavator NDE00001-UP (MACHINE) POWERED BY C6.4 Engine
320D LN Excavator WBN00001-UP (MACHINE) POWERED BY C6.4 Engine
320D Excavator BZP00001-UP (MACHINE) POWERED BY C6.4 Engine
323D L Excavator LFL00001-UP (MACHINE) POWERED BY C6.4 Engine
323D L Excavator PBE00001-UP (MACHINE) POWERED BY C6.4 Engine
323D L Excavator YSD00001-UP (MACHINE) POWERED BY C6.4 Engine
323D & 323D L Excavators WGC00001-UP (MACHINE) POWERED BY C6.4 Engine
315D L Excavator BZN00001-UP (MACHINE) POWERED BY C4.2 Engine
315D L Excavator JGS00001-UP (MACHINE) POWERED BY C4.2 Engine
320D L & 320D LN Excavators GDP00001-UP (MACHINE) POWERED BY C6.4 Engine
320D & 320D L Excavators KLM00001-UP (MACHINE) POWERED BY C6.4 Engine
320D L Excavator SPN00001-UP (MACHINE) POWERED BY C6.4 Engine
323D, 323D L & 323D LN Excavators CWG00001-UP (MACHINE) POWERED BY C6.4 Engine
315D L Excavator TLE00001-UP (MACHINE) POWERED BY C4.2 Engine
323D SA Excavator NES00001-UP (MACHINE) POWERED BY C6.4 Engine
315D L Excavator JHA00001-UP (MACHINE) POWERED BY C4.2 Engine
320D GC Excavator KTF00001-UP (MACHINE) POWERED BY C6.4 Engine
320D GC Excavator PCM00001-UP (MACHINE) POWERED BY C6.4 Engine
320E L Excavators TNJ00001-UP (MACHINE) POWERED BY C6.6 Engine
320E, 320E L & 320E LN Excavators DFG00001-UP (MACHINE) POWERED BY C6.6 Engine
320D Excavator KHN00001-UP (MACHINE) POWERED BY C6.4 Engine
323E L, 323E LN & 323E SA Excavators RAP00001-UP (MACHINE) POWERED BY C6.6 Engine
323D L Excavator GTF00001-UP (MACHINE) POWERED BY C6.4 Engine
320E & 320E L Excavators AWS00001-UP (MACHINE) POWERED BY C6.6 Engine
320D & 320D L Excavators KZF00001-UP (MACHINE) POWERED BY C6.6 Engine
320D GC Excavator JZA00001-UP (MACHINE) POWERED BY C6.6 Engine
323D L Excavator NZF00001-UP (MACHINE) POWERED BY C6.6 Engine
320D Excavator JPD00001-UP (MACHINE) POWERED BY C6.4 Engine
318D L Excavator ZKJ00001-UP (MACHINE) POWERED BY C4.2 Engine
323D2 L Excavators KCE00001-UP (MACHINE) POWERED BY C7.1 Engine
323D2 L Excavator JEG00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator TZS00001-UP (MACHINE) POWERED BY 3054C Engine
318D2 L Excavator WGR00001-UP (MACHINE) POWERED BY 3054C Engine
320D2 Excavator DFM00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators KHR00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators LMA00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator XGS00001-UP (MACHINE) POWERED BY 3054C Engine
320E L EXCAVATORS REE00001-UP (MACHINE) POWERED BY C6.6 Engine
320D2 & 320D2 L Excavators DNP00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators GBA00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators YEA00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 GC Excavator JFM00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 Excavator XBB00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 FOREST MACHINE BW200001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 LOG LOADER FOREST MACHINE CY200001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator XAH00001-UP (MACHINE) POWERED BY 3054C Engine
320D2 & 320D2 L Excavators TDN00001-UP (MACHINE) POWERED BY C7.1 Engine
323F L Excavators XCF00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator HAH00001-UP (MACHINE) POWERED BY 3054C Engine
320D2 & 320D2 L Excavators KBS00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator JEB00001-UP (MACHINE) POWERED BY 3054C Engine
320D2 & 320D2 L Excavators LCA00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 Excavator MDJ00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 GC Excavator NBH00001-UP (MACHINE) POWERED BY C4.4 Engine
323D2 L Excavators XBK00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator DPJ00001-UP (MACHINE) POWERED BY 3054C Engine
320D2 & 320D2 L Excavators NBF00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 GC Excavator XAK00001-UP (MACHINE) POWERED BY 3054C Engine
323D2 L Excavator KBX00001-UP (MACHINE) POWERED BY C7.1 Engine
323D2 L Excavator TDT00001-UP (MACHINE) POWERED BY C7.1 Engine
318D2 L Excavator HBP00001-UP (MACHINE) POWERED BY C4.4 Engine
320D2 & 320D2 L Excavators RDZ00001-UP (MACHINE) POWERED BY C7.1 Engine
320F L Excavator YBM00001-UP (MACHINE) POWERED BY C4.4 Engine
320D2 & 320D2 L Excavator DNS00001-UP (MACHINE) POWERED BY C7.1 Engine
323D2 L Excavator FLC00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 & 320D2 L Excavators ZBD00001-UP (MACHINE) POWERED BY C7.1 Engine
320D2 GC Excavator ZBH00001-UP (MACHINE) POWERED BY C4.4 Engine
320D2 GC Excavator PFE00001-UP (MACHINE) POWERED BY C4.4 Engine
323 Excavator HDT00001-UP (MACHINE) POWERED BY C7.1 Engine


Parts hose Caterpillar catalog:

2056687 HOSE-AIR
320C, 320C FM, 320C L, 320D
2108107 HOSE
320C, 320C FM, 320C L, 320D
2040946 HOSE
320C, 320C FM, 320C L, 320D, 323D L, 323D LN
2040947 HOSE
320C, 320C FM, 320C L, 320D
2108011 HOSE
320C, 320C FM, 320C L, 320D, 323D L, 323D LN
5I8510 HOSE AS
320D, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 L, 321D LCR, 323D L, 323D LN, 323D SA, 323D2 L, 325C, 330B L, 330C L, 345C, 345C L, 345D, 345D L, 345D L VG, 349D, 349D L, 350
2459178 HOSE-RADIATOR
320D, 320D FM, 320D GC, 320D L, 323D L, 323D LN
2653602 HOSE-RADIATOR
320D, 320D FM, 320D GC, 320D L, 323D L, 323D LN
2653585 HOSE
320D, 320D FM, 320D GC, 320D L, 320D LN, 323D L, 323D LN, 323D SA
2653586 HOSE
320D, 320D FM, 320D GC, 320D L, 323D L, 323D LN
2653591 HOSE
320D, 320D FM, 320D GC, 320D L, 320D LN, 323D L, 323D LN, 323D SA
2653599 HOSE
320D, 320D FM, 320D GC, 320D L, 320D LN, 323D L, 323D LN, 323D SA
2076282 HOSE AS
315D L, 316E L, 318D2 L, 318E L, 320E LN, 323D L, 323D LN, 323D SA, 323D2 L, 323E L, 324D, 324D L, 324D LN, 325D, 325D L, 329D L, 330C, 330C L, 330D, 330D L, 330D LN, 336D, 336D L, 336D LN, 336D2, 336...
2825884 HOSE AS
315D L, 316E L, 318D2 L, 318E L, 319D, 319D L, 319D LN, 323D LN, 323D SA
2536694 HOSE AS
312D, 312D L, 312D2, 312D2 GC, 313D2, 314D CR, 314D LCR, 315D L, 316E L, 318D2 L, 318E L, 319D, 319D L, 319D LN, 320D, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 L, 320E, 320E LN, 323D L, 323D L...
2771089 HOSE AS
315D L, 316E L, 318D2 L, 318E L, 319D, 319D L, 319D LN, 322B L, 322C, 322C FM, 324D, 324D L, 324E, 324E L, 324E LN, 325C, 325D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN
2125326 HOSE AS
312D, 312D L, 314D CR, 314D LCR, 315D L, 316E L, 318D2 L, 318E L, 319D, 319D L, 319D LN, 325D, 325D L, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 345B II, 345B L, 345C, 345C L, 345D, 345D...
1737864 HOSE AS
315D L, 316E L, 318D2 L, 318E L, 319D, 319D L, 319D LN, 320C, 321C, 322B LN, 322C, 325C
3514998 HOSE AS
315D L, 316E L, 318E L
3689376 HOSE AS
315D L, 318D L, 318D2 L
2967057 HOSE AS
315D L, 316E L, 318E L
2786495 HOSE AS
315D L, 349E, 349E L, 349E L HVG, 349E L VG, 349F L
2125149 HOSE AS
315D L, 316E L, 318E L, 319D, 319D L, 319D LN, 320E LRR, 320E RR, 322C, 322C FM, 325C FM, 330C L, 330C MH, 336E L, 336E LN, 336F L, 345C, 345C L, 345D, 345D L, 345D L VG, 349D, 349D L, 374F L
2661210 HOSE AS
315D L, 318D L, 318D2 L, 318E L
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.