ELECTRICAL AND STARTING SYSTEM
WIRING GPELECTRICAL AND STARTING SYSTEM
WIRING GP
#KEBP62350370
479-9317: WIRING GP-SCREED
479-9317 WIRING GP-SCREED
S/N P651-122; ML61-117
(3-M)
PART OF 390-4740 SCREED AR
AN ATTACHMENT
S/N P651-122; ML61-117
(3-M)
PART OF 390-4740 SCREED AR
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 3E-5239 | [1] | RELAY AS (24-VOLT)(HORN) | |
| 2. | 3S-2093 | [24] | STRAP-CABLE | |
| 3. | 7K-1181 | [30] | STRAP-CABLE | |
| 4. | 7R-7951 | [1] | PLATE | |
| 5. | 8T-9655 | [14] | MOUNT-ISOLATION | |
| 6. | 121-5327 | [2] | GROMMET | |
| 7. | 143-9644 | [2] | PLATE-RETAINER | |
| 8. | 163-1201 | [1] | HORN AS (24-VOLT, LOW TONE) | |
| 9. | 169-5414 | [2] | CLIP | |
| 10. | 177-2215 | [3] | STRAP-DUAL CLAMP | |
| 11. | 200-6345 | [2] | SADDLE-MOUNTING (DUAL SWIVEL) | |
| 12. | 299-5744 | [1] | MODULE GP-RELAY DRIVER | |
| 7X-6315 | [1] | STRAP AS-GROUND | ||
| 5P-6006 D | TUBE-HEAT SHRINK (9.52-MM DIA)(0.1-M) | |||
| 2L-8078 | [1] | TERMINAL-RING (14-GA TO 16-GA, 5/16-IN SCREW) | ||
| 2L-8075 | [1] | TERMINAL-RING (14-GA TO 16-GA, NO. 8 SCREW) | ||
| 134-4126 | [1] | WASHER (4.52X8.28X0.76-MM THK) | ||
| 184-2472 | [1] | SCREW-PAN HEAD (8-32X0.375-IN) | ||
| 13. | 327-6125 | [1] | LAMP GP-SIGNAL (24-VOLT, RH) | |
| 14. | 327-8515 | [1] | LAMP GP-SIGNAL (24-VOLT, LH) | |
| (EACH LAMP GP-SIGNAL INCLUDES) | ||||
| 230-4012 | [1] | RECEPTACLE AS-CONNECTOR (2-PIN) | ||
| 15. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (EXTENDER, RH) | |
| 15A. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (MAIN, RH) | |
| 15B. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (MAIN, LH) | |
| 15C. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (EXTENDER, LH) | |
| (EACH SENSOR GP-TEMPERATURE INCLUDES) | ||||
| 9X-3401 | [2] | PIN-CONNECTOR (16-GA TO 18-GA) | ||
| 102-8802 | [1] | KIT-RECEPTACLE (2-PIN) | ||
| (INCLUDES RECEPTACLE AS & WEDGE) | ||||
| 16. | 455-9580 | [1] | CONTROL GP-UNPROGRAMMED (ELECTRONIC) | |
| 17. | 399-9027 | [1] | HARNESS AS-SCREED (TRACTOR TO SCREED) | |
| 9X-0141 | [2] | PLUG AS-CONNECTOR (40-PIN) | ||
| (EACH INCLUDES) | ||||
| 3E-8557 M | [1] | BOLT (M5X0.8X39.37-MM) | ||
| 3E-4367 | [1] | RING-RETAINING | ||
| 9X-3490 | [2] | SEAL-CONNECTOR (40-PIN) | ||
| 8T-8737 | [8] | PLUG-SEAL | ||
| 194-5226 | [72] | WIRE AS (16-GA) | ||
| -OR- | ||||
| 194-5227 | [72] | WIRE AS (14-GA) | ||
| 108-1304 E | TUBE-HEAT SHRINK (33-MM DIA)(27-CM) | |||
| 18. | 399-9033 | [1] | BRACKET | |
| 19. | 399-9048 | [1] | PLATE | |
| 20. | 431-0680 | [2] | STRAP | |
| 21. | 442-7954 | [2] | NUT-RING | |
| 22. | 475-0302 Y | [2] | HARNESS GP-WIRING (END GATE) | |
| 23. | 479-9318 Y | [1] | HARNESS AS-CHASSIS (LEFT) | |
| 24. | 479-9319 Y | [1] | HARNESS AS-SCREED (RIGHT) | |
| 25. | 479-9320 Y | [1] | HARNESS AS-SCREED (EXTENDER, LH) | |
| 26. | 505-5577 CY | [1] | HARNESS AS-SCREED (EXTENDER, RH) | |
| 27. | 096-6166 | [8] | WASHER-HARD (4.5X9X1-MM THK) | |
| 28. | 099-3649 M | [4] | BOLT (M8X1.25X40-MM) | |
| 29. | 130-5300 | [3] | CLIP | |
| 30. | 178-1781 | [1] | CLIP | |
| 31. | 204-2281 | [7] | STRAP-CABLE | |
| 32. | 206-1511 | [4] | CLAMP-HALF | |
| 33. | 277-1873 | [1] | CLIP (LADDER) | |
| 34. | 327-0325 | [26] | STRAP-CABLE | |
| 35. | 344-5674 M | [3] | NUT (M8X1.25-THD) | |
| 36. | 344-5675 M | [1] | NUT (M10X1.5-THD) | |
| 37. | 345-3753 | [1] | MOUNTING-CABLE TIE | |
| 38. | 381-2621 | [1] | MOUNTING-CABLE TIE | |
| 39. | 4B-4863 | [8] | WASHER (4.7X11X1.2-MM THK) | |
| 40. | 5C-8312 M | [6] | NUT (M4X0.7-THD) | |
| 41. | 5P-4116 | [10] | WASHER-HARD (8.8X20.5X2-MM THK) | |
| 42. | 6I-1418 | [7] | SPACER (8.2X12.7X28.7-MM THK) | |
| 43. | 6V-7978 | [4] | SCREW-MACHINE (10-32X0.375-IN) | |
| 44. | 6V-9491 M | [12] | SCREW-MACHINE (M4X0.7X20-MM) | |
| 45. | 7P-1695 | [2] | WASHER (10.5X19X3-MM THK) | |
| 46. | 7R-7941 | [2] | CLAMP | |
| 47. | 8P-6364 | [6] | PLUG | |
| 48. | 8T-3844 M | [2] | BOLT (M6X1X70-MM) | |
| 49. | 8T-4121 | [13] | WASHER-HARD (11X21X2.5-MM THK) | |
| 50. | 8T-4133 M | [2] | NUT (M10X1.5-THD) | |
| 51. | 8T-4136 M | [3] | BOLT (M10X1.5X25-MM) | |
| 52. | 8T-4137 M | [10] | BOLT (M10X1.5X20-MM) | |
| 53. | 8T-4138 M | [8] | BOLT (M6X1X20-MM) | |
| 54. | 8T-4171 M | [1] | BOLT (M6X1X12-MM) | |
| 55. | 8T-4205 | [1] | WASHER-HARD (7.2X14.5X2-MM THK) | |
| 56. | 8T-6912 M | [3] | BOLT (M8X1.25X50-MM) | |
| 58. | 9X-2480 M | [4] | BOLT (M6X1X45-MM) | |
| 59. | 9X-6257 | [8] | SCREW-MACHINE (6-32X0.625-IN) | |
| 60. | 9X-8256 | [8] | WASHER (6.6X12X2-MM THK) | |
| 61. | 474-7565 | [2] | CAP AS-CONNECTOR | |
| 62. | 7X-7877 E | STRIP-EDGE (42-CM) | ||
| C | CHANGE FROM PREVIOUS TYPE | |||
| D | ORDER BY THE METER | |||
| E | ORDER BY THE CENTIMETER | |||
| M | METRIC PART | |||
| R | REMANUFACTURED PART MAY BE AVAILABLE | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350371
479-9317: WIRING GP-SCREED
479-9317 WIRING GP-SCREED
S/N P65123-UP; ML6118-UP
(3-M)
PART OF 390-4740 SCREED AR
AN ATTACHMENT
S/N P65123-UP; ML6118-UP
(3-M)
PART OF 390-4740 SCREED AR
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 3E-5239 | [1] | RELAY AS (24-VOLT)(HORN) | |
| 2. | 3S-2093 | [24] | STRAP-CABLE | |
| 3. | 7K-1181 | [30] | STRAP-CABLE | |
| 4. | 7R-7951 | [1] | PLATE | |
| 5. | 8T-9655 | [14] | MOUNT-ISOLATION | |
| 6. | 121-5327 | [2] | GROMMET | |
| 7. | 143-9644 | [2] | PLATE-RETAINER | |
| 8. | 163-1201 | [1] | HORN AS (24-VOLT, LOW TONE) | |
| 9. | 169-5414 | [2] | CLIP | |
| 10. | 177-2215 | [3] | STRAP-DUAL CLAMP | |
| 11. | 200-6345 | [2] | SADDLE-MOUNTING (DUAL SWIVEL) | |
| 12. | 299-5744 | [1] | MODULE GP-RELAY DRIVER | |
| 7X-6315 | [1] | STRAP AS-GROUND | ||
| 5P-6006 D | TUBE-HEAT SHRINK (9.52-MM DIA)(0.1-M) | |||
| 2L-8078 | [1] | TERMINAL-RING (14-GA TO 16-GA, 5/16-IN SCREW) | ||
| 2L-8075 | [1] | TERMINAL-RING (14-GA TO 16-GA, NO. 8 SCREW) | ||
| 134-4126 | [1] | WASHER (4.52X8.28X0.76-MM THK) | ||
| 184-2472 | [1] | SCREW-PAN HEAD (8-32X0.375-IN) | ||
| 299-6190 | [1] | CONTROL AS-ELECTRONIC (RELAY DRIVER MODULE) | ||
| 184-2471 | [15] | SCREW-PAN HEAD | ||
| 13. | 327-6125 | [1] | LAMP GP-SIGNAL (24-VOLT, RH) | |
| 14. | 327-8515 | [1] | LAMP GP-SIGNAL (24-VOLT, LH) | |
| (EACH LAMP GP-SIGNAL INCLUDES) | ||||
| 230-4012 | [1] | RECEPTACLE AS-CONNECTOR (2-PIN) | ||
| 15. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (EXTENDER, RH) | |
| 15A. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (MAIN, RH) | |
| 15B. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (MAIN, LH) | |
| 15C. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (EXTENDER, LH) | |
| (EACH SENSOR GP-TEMPERATURE INCLUDES) | ||||
| 9X-3401 | [2] | PIN-CONNECTOR (16-GA TO 18-GA) | ||
| 102-8802 | [1] | KIT-RECEPTACLE (2-PIN) | ||
| (INCLUDES RECEPTACLE AS & WEDGE) | ||||
| 16. | 455-9580 | [1] | CONTROL GP-UNPROGRAMMED (ELECTRONIC) | |
| 17. | 399-9027 | [1] | HARNESS AS-SCREED (TRACTOR TO SCREED) | |
| 196-8876 E | BRAID (BLACK, ONE GOLD STRAND)(120-CM) | |||
| 9X-0141 | [2] | PLUG AS-CONNECTOR (40-PIN) | ||
| (EACH INCLUDES) | ||||
| 3E-4367 | [1] | RING-RETAINING | ||
| 3E-8557 M | [1] | BOLT (M5X0.8X39.37-MM) | ||
| 9X-3490 | [2] | SEAL-CONNECTOR (40-PIN) | ||
| 8T-8737 | [8] | PLUG-SEAL | ||
| 194-5226 | [72] | WIRE AS (16-GA) | ||
| -OR- | ||||
| 194-5227 | [72] | WIRE AS (14-GA) | ||
| 108-1304 E | TUBE-HEAT SHRINK (33-MM DIA)(30-CM) | |||
| 18. | 399-9033 | [1] | BRACKET | |
| 19. | 399-9048 | [1] | PLATE | |
| 20. | 431-0680 | [2] | STRAP | |
| 21. | 442-7954 | [2] | NUT-RING | |
| 22. | 475-0302 Y | [2] | HARNESS GP-WIRING (END GATE) | |
| 23. | 479-9318 Y | [1] | HARNESS AS-CHASSIS (LEFT) | |
| 24. | 479-9319 Y | [1] | HARNESS AS-SCREED (RIGHT) | |
| 25. | 551-6523 CY | [1] | HARNESS AS-SCREED (EXTENDER, LH) | |
| 26. | 551-6524 CY | [1] | HARNESS AS-SCREED (EXTENDER, RH) | |
| 27. | 096-6166 | [8] | WASHER-HARD (4.5X9X1-MM THK) | |
| 28. | 099-3649 M | [4] | BOLT (M8X1.25X40-MM) | |
| 29. | 130-5300 | [3] | CLIP | |
| 30. | 178-1781 | [1] | CLIP | |
| 31. | 204-2281 | [7] | STRAP-CABLE | |
| 32. | 206-1511 | [4] | CLAMP-HALF | |
| 33. | 277-1873 | [1] | CLIP (LADDER) | |
| 34. | 327-0325 | [26] | STRAP-CABLE | |
| 35. | 344-5674 M | [3] | NUT (M8X1.25-THD) | |
| 36. | 344-5675 M | [1] | NUT (M10X1.5-THD) | |
| 37. | 345-3753 | [1] | MOUNTING-CABLE TIE | |
| 38. | 381-2621 | [1] | MOUNTING-CABLE TIE | |
| 39. | 4B-4863 | [8] | WASHER (4.7X11X1.2-MM THK) | |
| 40. | 5C-8312 M | [6] | NUT (M4X0.7-THD) | |
| 41. | 5P-4116 | [10] | WASHER-HARD (8.8X20.5X2-MM THK) | |
| 42. | 6I-1418 | [7] | SPACER (8.2X12.7X28.7-MM THK) | |
| 43. | 6V-7978 | [4] | SCREW-MACHINE (10-32X0.375-IN) | |
| 44. | 123-0707 M | [12] | SCREW-HEX SOCKET (M4X0.7X20-MM) | |
| 45. | 7P-1695 | [2] | WASHER (10.5X19X3-MM THK) | |
| 46. | 7R-7941 | [2] | CLAMP | |
| 47. | 8P-6364 | [6] | PLUG | |
| 48. | 8T-3844 M | [2] | BOLT (M6X1X70-MM) | |
| 49. | 8T-4121 | [13] | WASHER-HARD (11X21X2.5-MM THK) | |
| 50. | 8T-4133 M | [2] | NUT (M10X1.5-THD) | |
| 51. | 8T-4136 M | [3] | BOLT (M10X1.5X25-MM) | |
| 52. | 8T-4137 M | [10] | BOLT (M10X1.5X20-MM) | |
| 53. | 8T-4138 M | [8] | BOLT (M6X1X20-MM) | |
| 54. | 8T-4171 M | [1] | BOLT (M6X1X12-MM) | |
| 55. | 8T-4205 | [1] | WASHER-HARD (7.2X14.5X2-MM THK) | |
| 56. | 8T-6912 M | [3] | BOLT (M8X1.25X50-MM) | |
| 58. | 9X-2480 M | [4] | BOLT (M6X1X45-MM) | |
| 59. | 9X-6257 | [8] | SCREW-MACHINE (6-32X0.625-IN) | |
| 60. | 9X-8256 | [8] | WASHER (6.6X12X2-MM THK) | |
| 61. | 474-7565 | [2] | CAP AS-CONNECTOR | |
| 62. | 7X-7877 E | STRIP-EDGE (42-CM) | ||
| 63. | 7X-4780 | [1] | GROMMET | |
| C | CHANGE FROM PREVIOUS TYPE | |||
| D | ORDER BY THE METER | |||
| E | ORDER BY THE CENTIMETER | |||
| M | METRIC PART | |||
| R | REMANUFACTURED PART MAY BE AVAILABLE | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350372
486-4623: WIRING GP-SCREED
486-4623 WIRING GP-SCREED
S/N P651-UP; LR61-UP; ML61-UP
PART OF 487-5617 EXTENSION AR-SCREED, 486-4622 EXTENSION GP-SCREED
AN ATTACHMENT
S/N P651-UP; LR61-UP; ML61-UP
PART OF 487-5617 EXTENSION AR-SCREED, 486-4622 EXTENSION GP-SCREED
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS#KEBP62350373
496-9649: WIRING GP-SCREED
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 7K-1181 | [78] | STRAP-CABLE | |
| 2. | 441-0314 Y | [2] | LAMP GP-FLOOD (24-VOLT, 50-WATT, LED) | |
| 3. | 479-8444 | [6] | LAMP GP-FLOOD (FLOOD, 850 LUMENS) | |
| (EACH INCLUDES) | ||||
| 3T-0852 M | [2] | LOCKNUT (M8X1.25-THD) | ||
| 5P-4116 | [1] | WASHER-HARD (8.8X20.5X2-MM THK) | ||
| 8T-6912 M | [1] | BOLT (M8X1.25X50-MM) | ||
| 4. | 496-9643 Y | [1] | HARNESS AS-SCREED (MAIN) | |
| 5. | 496-9644 Y | [2] | HARNESS AS-SCREED (TRACTOR TO SCREED) | |
| 6. | 496-9645 | [2] | BAR AS | |
| 7. | 496-9650 Y | [1] | HARNESS AS-SCREED (RH) | |
| 8. | 496-9651 Y | [1] | HARNESS AS-SCREED (LH) | |
| 9. | 496-9673 | [4] | BRACKET | |
| 10. | 130-5300 | [1] | CLIP | |
| 11. | 177-2215 | [26] | STRAP-DUAL CLAMP | |
| 12. | 327-0325 | [2] | STRAP-CABLE | |
| 13. | 4P-7428 | [2] | CLIP (LADDER) | |
| 14. | 4P-7581 | [6] | CLIP (LADDER) | |
| 15. | 8T-4223 | [2] | WASHER-HARD (13.5X25.5X3-MM THK) | |
| 16. | 8T-4956 M | [2] | BOLT (M12X1.75X35-MM) | |
| 17. | 7X-7943 | [1] | KNOB-CLAMP | |
| 18. | 3S-2093 | [20] | STRAP-CABLE | |
| 19. | 344-5675 M | [4] | NUT (M10X1.5-THD) | |
| 20. | 4H-2558 | [6] | GROMMET | |
| 21. | 559-8049 | [1] | PLATE AS | |
| 22. | 7Y-5262 | [2] | U-BOLT | |
| 23. | 8T-4121 | [4] | WASHER-HARD (11X21X2.5-MM THK) | |
| 24. | 496-9662 Y | [2] | HARNESS AS-SCREED (END GATE) | |
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350374
391-7155: WIRING GP-SCREED HEATER
391-7155 WIRING GP-SCREED HEATER
S/N P651-UP; LR61-UP; ML61-UP
PART OF 416-9952 EXTENSION GP-SCREED
AN ATTACHMENT
S/N P651-UP; LR61-UP; ML61-UP
PART OF 416-9952 EXTENSION GP-SCREED
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 1S-2342 | [1] | STRAP AS-GROUND | |
| 2. | 3S-2093 | [2] | STRAP-CABLE | |
| 3. | 7K-1181 | [6] | STRAP-CABLE | |
| 4. | 132-8485 | [2] | NUT-RING | |
| 5. | 399-3838 | [1] | HEATER AS-SCREED | |
| 418-6704 | [1] | PLUG AS-CONNECTOR (3-PIN) | ||
| 6. | 399-9056 Y | [1] | HARNESS AS-WIRING (POWER) | |
| 7. | 416-0511 Y | [1] | BOX GP-JUNCTION (EXTENSION) | |
| 8. | 454-3492 Y | [1] | HARNESS AS-SCREED | |
| 9. | 061-8844 | [1] | GROMMET | |
| 10. | 124-7346 | [2] | LOCKWASHER | |
| 11. | 160-8755 M | [1] | BOLT (M6X1.0X10-MM) | |
| 12. | 204-2281 | [2] | STRAP-CABLE | |
| 13. | 204-8000 | [3] | MOUNTING-CABLE TIE | |
| 14. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (SCREED) | |
| 9X-3401 | [2] | PIN-CONNECTOR (16-GA TO 18-GA) | ||
| 102-8802 | [1] | KIT-RECEPTACLE (2-PIN) | ||
| (INCLUDES RECEPTACLE AS & WEDGE) | ||||
| 15. | 381-2621 | [1] | MOUNTING-CABLE TIE | |
| 16. | 7P-1695 | [2] | WASHER (10.5X19X3-MM THK) | |
| 17. | 7X-7729 | [6] | WASHER (11X25X3-MM THK) | |
| 18. | 8C-8560 | [4] | SCREW-LOCK (4-40X0.5-IN) | |
| 19. | 8T-4133 M | [2] | NUT (M10X1.5-THD) | |
| 20. | 8T-4136 M | [6] | BOLT (M10X1.5X25-MM) | |
| 21. | 9X-8256 | [1] | WASHER (6.6X12X2-MM THK) | |
| 22. | 9B-1117 | [4] | LOCKWASHER | |
| 23. | 5P-8937 B | COMPOUND-JOINT (THERMAL) | ||
| 24. | 5P-6025 D | LOCKWIRE (0.1-M EACH) | ||
| 24A. | 5P-6025 D | LOCKWIRE (0.2-M EACH) | ||
| B | USE AS REQUIRED | |||
| D | ORDER BY THE METER | |||
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350375
428-4945: WIRING GP-SCREED HEATER
428-4945 WIRING GP-SCREED HEATER
S/N P651-UP; LR61-UP; ML61-UP
PART OF 428-4850, 522-1493 SCREED AR
AN ATTACHMENT
S/N P651-UP; LR61-UP; ML61-UP
PART OF 428-4850, 522-1493 SCREED AR
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 7K-1181 | [49] | STRAP-CABLE | |
| 2. | 7V-5628 | [2] | PLATE (TOP) | |
| 3. | 102-8705 | [2] | PLATE (TOP) | |
| 4. | 417-1001 | [4] | PLATE | |
| 5. | 467-0068 | [1] | WIRE AS-GROUND | |
| 6. | 467-8194 | [1] | WIRE AS-GROUND | |
| 7. | 528-7731 | [1] | WIRE AS-GROUND | |
| 8. | 107-4749 | [4] | PLATE (TOP) | |
| 9. | 124-7346 | [10] | LOCKWASHER | |
| 10. | 177-2215 | [13] | STRAP-DUAL CLAMP | |
| 11. | 1G-8781 | [8] | CLAMP (HALF) | |
| 12. | 200-6345 | [8] | SADDLE-MOUNTING (DUAL SWIVEL) | |
| 13. | 204-2281 | [7] | STRAP-CABLE | |
| 14. | 207-3643 | [4] | CLAMP-HALF | |
| 15. | 277-1873 | [2] | CLIP (LADDER) | |
| 16. | 327-0325 | [2] | STRAP-CABLE | |
| 17. | 348-2003 | [4] | WIRE AS-GROUND | |
| 18. | 364-4569 | [1] | STRAP | |
| 19. | 381-2621 | [3] | MOUNTING-CABLE TIE | |
| 20. | 491-2411 Y | [1] | WIRING GP-SCREED HEATER (RH) | |
| 21. | 491-2412 Y | [1] | WIRING GP-SCREED HEATER (LH) | |
| 22. | 491-2941 Y | [1] | WIRING GP-SCREED HEATER (LH) | |
| 23. | 491-2942 Y | [1] | WIRING GP-SCREED HEATER (RH) | |
| 24. | 536-2017 | [4] | HEATER AS-SCREED (675-VOLT, 1000-WATT) | |
| (EACH INCLUDES) | ||||
| 418-6712 | [1] | PLUG AS-CONNECTOR | ||
| 25. | 559-5533 | [2] | HEATER AS-SCREED (675-VOLT, 6900-WATT) | |
| 26. | 559-5534 | [2] | HEATER AS-SCREED (675-VOLT, 6900-WATT) | |
| 27. | 7P-1695 | [14] | WASHER (10.5X19X3-MM THK) | |
| 28. | 7R-7908 | [4] | CLAMP | |
| 29. | 7X-0818 M | [2] | BOLT (M8X1.25X45-MM) | |
| 30. | 7X-2538 M | [8] | BOLT (M8X1.25X100-MM) | |
| 31. | 8C-8451 M | [12] | BOLT (M6X1X40-MM) | |
| 32. | 8T-4121 | [3] | WASHER-HARD (11X21X2.5-MM THK) | |
| 33. | 8T-4133 M | [10] | NUT (M10X1.5-THD) | |
| 34. | 8T-4136 M | [1] | BOLT (M10X1.5X25-MM) | |
| 35. | 8T-4138 M | [8] | BOLT (M6X1X20-MM) | |
| 36. | 8T-4186 M | [2] | BOLT (M10X1.5X40-MM) | |
| 37. | 8T-4205 | [8] | WASHER-HARD (7.2X14.5X2-MM THK) | |
| 38. | 8T-4224 | [8] | WASHER-HARD (8.8X16X2-MM THK) | |
| 40. | 206-2724 E | GUARD-HOSE (110-CM EACH) | ||
| 5P-1275 F | LOCKWIRE | |||
| E | ORDER BY THE CENTIMETER | |||
| F | NOT SHOWN | |||
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350376
437-7126: WIRING GP-SCREED HEATER
437-7126 WIRING GP-SCREED HEATER
S/N P651-UP; LR61-UP; ML61-UP
PART OF 428-4845 SCREED AR
AN ATTACHMENT
S/N P651-UP; LR61-UP; ML61-UP
PART OF 428-4845 SCREED AR
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 7K-1181 | [39] | STRAP-CABLE | |
| 2. | 7V-5628 | [2] | PLATE (TOP) | |
| 3. | 102-8705 | [2] | PLATE (TOP) | |
| 4. | 200-6345 | [4] | SADDLE-MOUNTING (DUAL SWIVEL) | |
| 5. | 438-1011 Y | [1] | HARNESS AS-WIRING (EXTENDER, LH) | |
| 6. | 438-1012 Y | [1] | HARNESS AS-WIRING (EXTENDER, RH) | |
| 7. | 438-1013 Y | [1] | HARNESS AS-WIRING (MAIN, LH) | |
| 8. | 438-1014 Y | [1] | HARNESS AS-WIRING (MAIN, RH) | |
| 9. | 559-5531 | [2] | HEATER AS-SCREED (675-VOLT, 6900-WATT) | |
| 10. | 559-5532 | [2] | HEATER AS-SCREED (675-VOLT, 6900-WATT) | |
| 11. | 467-0068 | [1] | WIRE AS-GROUND | |
| 12. | 467-8194 | [1] | WIRE AS-GROUND | |
| 13. | 124-7346 | [10] | LOCKWASHER | |
| 14. | 177-2215 | [3] | STRAP-DUAL CLAMP | |
| 15. | 204-2281 | [3] | STRAP-CABLE | |
| 16. | 207-3643 | [4] | CLAMP-HALF | |
| 17. | 327-0325 | [2] | STRAP-CABLE | |
| 18. | 348-2003 | [4] | WIRE AS-GROUND | |
| 19. | 381-2621 | [3] | MOUNTING-CABLE TIE | |
| 20. | 7P-1695 | [12] | WASHER (10.5X19X3-MM THK) | |
| 21. | 7R-7908 | [4] | CLAMP | |
| 22. | 7X-0818 M | [2] | BOLT (M8X1.25X45-MM) | |
| 23. | 7X-2538 M | [8] | BOLT (M8X1.25X100-MM) | |
| 24. | 8C-8451 M | [4] | BOLT (M6X1X40-MM) | |
| 25. | 8T-4121 | [3] | WASHER-HARD (11X21X2.5-MM THK) | |
| 26. | 8T-4133 M | [10] | NUT (M10X1.5-THD) | |
| 27. | 8T-4136 M | [1] | BOLT (M10X1.5X25-MM) | |
| 28. | 8T-4186 M | [2] | BOLT (M10X1.5X40-MM) | |
| 29. | 8T-4224 | [8] | WASHER-HARD (8.8X16X2-MM THK) | |
| 30. | 206-2724 E | GUARD-HOSE (110-CM EACH) | ||
| 5P-1275 BFJ | LOCKWIRE | |||
| B | USE AS REQUIRED | |||
| E | ORDER BY THE CENTIMETER | |||
| F | NOT SHOWN | |||
| J | ORDER BY THE DECIMETER | |||
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350377
438-1040: WIRING GP-SCREED HEATER
438-1040 WIRING GP-SCREED HEATER
S/N P651-UP; ML61-UP
PART OF 416-9953 EXTENSION GP-SCREED
AN ATTACHMENT
S/N P651-UP; ML61-UP
PART OF 416-9953 EXTENSION GP-SCREED
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 1S-2342 | [1] | STRAP AS-GROUND | |
| 2. | 3S-2093 | [6] | STRAP-CABLE | |
| 3. | 7K-1181 | [9] | STRAP-CABLE | |
| 4. | 132-8485 | [2] | NUT-RING | |
| 5. | 399-3838 | [1] | HEATER AS-SCREED | |
| 418-6704 | [1] | PLUG AS-CONNECTOR (3-PIN) | ||
| 6. | 399-7098 | [1] | HEATER AS-SCREED | |
| 418-6712 | [1] | PLUG AS-CONNECTOR | ||
| 7. | 399-9056 Y | [1] | HARNESS AS-WIRING (POWER) | |
| 8. | 416-0511 Y | [1] | BOX GP-JUNCTION (EXTENSION) | |
| 9. | 417-1001 | [1] | PLATE | |
| 10. | Y | [1] | HARNESS AS-WIRING (EXTENSION) | |
| 11. | 061-8844 | [1] | GROMMET | |
| 12. | 096-6166 | [2] | WASHER-HARD (4.5X9X1-MM THK) | |
| 13. | 107-4749 | [1] | PLATE | |
| 14. | 124-7346 | [2] | LOCKWASHER | |
| 16. | 1G-8781 | [2] | CLAMP (HALF) | |
| 18. | 204-8000 | [1] | MOUNTING-CABLE TIE | |
| 19. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (SCREED HEAT) | |
| 9X-3401 | [2] | PIN-CONNECTOR (16-GA TO 18-GA) | ||
| 102-8802 | [1] | KIT-RECEPTACLE (2-PIN) | ||
| (INCLUDES RECEPTACLE AS & WEDGE) | ||||
| 20. | 352-3969 | [1] | CLIP (LADDER) | |
| 21. | 381-2621 | [1] | MOUNTING-CABLE TIE | |
| 22. | 5C-8312 M | [2] | NUT (M4X0.7-THD) | |
| 23. | 6V-9491 M | [2] | SCREW-MACHINE (M4X0.7X20-MM) | |
| 24. | 7P-1695 | [2] | WASHER (10.5X19X3-MM THK) | |
| 25. | 7X-2533 M | [2] | BOLT (M6X1X35-MM) | |
| 26. | 7X-7729 | [4] | WASHER (11X25X3-MM THK) | |
| 27. | 8C-8560 | [4] | SCREW-LOCK (4-40X0.5-IN) | |
| 28. | 8T-4133 M | [2] | NUT (M10X1.5-THD) | |
| 29. | 8T-4136 M | [4] | BOLT (M10X1.5X25-MM) | |
| 30. | 8T-4138 M | [2] | BOLT (M6X1X20-MM) | |
| 31. | 8T-4205 | [2] | WASHER-HARD (7.2X14.5X2-MM THK) | |
| 32. | 8T-4224 | [1] | WASHER-HARD (8.8X16X2-MM THK) | |
| 33. | 9B-1117 | [4] | LOCKWASHER | |
| 35. | 5P-6025 D | LOCKWIRE (0.2-M EACH) | ||
| 35A. | 5P-6025 D | LOCKWIRE (0.1-M EACH) | ||
| D | ORDER BY THE METER | |||
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350378
438-1043: WIRING GP-SCREED HEATER
438-1043 WIRING GP-SCREED HEATER
S/N P651-UP; ML61-UP
PART OF 416-9950 EXTENSION GP-SCREED
AN ATTACHMENT
S/N P651-UP; ML61-UP
PART OF 416-9950 EXTENSION GP-SCREED
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 1S-2342 | [1] | STRAP AS-GROUND | |
| 2. | 3S-2093 | [6] | STRAP-CABLE | |
| 3. | 7K-1181 | [15] | STRAP-CABLE | |
| 4. | 132-8485 | [2] | NUT-RING | |
| 5. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (SCREED HEAT) | |
| 9X-3401 | [2] | PIN-CONNECTOR (16-GA TO 18-GA) | ||
| 102-8802 | [1] | KIT-RECEPTACLE (2-PIN) | ||
| (INCLUDES RECEPTACLE AS & WEDGE) | ||||
| 6. | 399-3839 | [1] | HEATER AS-SCREED (675-VOLT, 3425-WATT) | |
| 418-6704 | [1] | PLUG AS-CONNECTOR (3-PIN) | ||
| 7. | 399-6960 | [1] | HEATER AS-SCREED (675-VOLT, 664-WATT) | |
| 418-6712 | [1] | PLUG AS-CONNECTOR | ||
| 8. | 399-9034 Y | [1] | HARNESS AS-WIRING | |
| 9. | 416-0511 Y | [1] | BOX GP-JUNCTION (EXTENSION) | |
| 10. | 417-1001 | [1] | PLATE | |
| 11. | 438-1037 Y | [1] | HARNESS AS-WIRING (EXTENSION) | |
| 12. | 061-8844 | [1] | GROMMET | |
| 13. | 096-6166 | [2] | WASHER-HARD (4.5X9X1-MM THK) | |
| 14. | 107-4749 | [1] | PLATE | |
| 15. | 124-7346 | [2] | LOCKWASHER | |
| 17. | 1G-8781 | [2] | CLAMP (HALF) | |
| 19. | 204-8000 | [3] | MOUNTING-CABLE TIE | |
| 20. | 352-3969 | [1] | CLIP (LADDER) | |
| 21. | 381-2621 | [3] | MOUNTING-CABLE TIE | |
| 22. | 4P-7428 | [1] | CLIP (LADDER) | |
| 23. | 5C-8312 M | [2] | NUT (M4X0.7-THD) | |
| 24. | 6V-9491 M | [2] | SCREW-MACHINE (M4X0.7X20-MM) | |
| 25. | 7P-1695 | [2] | WASHER (10.5X19X3-MM THK) | |
| 26. | 7X-2533 M | [2] | BOLT (M6X1X35-MM) | |
| 27. | 7X-7729 | [2] | WASHER (11X25X3-MM THK) | |
| 28. | 8C-8560 | [4] | SCREW-LOCK (4-40X0.5-IN) | |
| 29. | 8T-4121 | [4] | WASHER-HARD (11X21X2.5-MM THK) | |
| 30. | 8T-4133 M | [2] | NUT (M10X1.5-THD) | |
| 31. | 8T-4136 M | [4] | BOLT (M10X1.5X25-MM) | |
| 32. | 8T-4138 M | [2] | BOLT (M6X1X20-MM) | |
| 33. | 8T-4196 M | [2] | BOLT (M10X1.5X35-MM) | |
| 34. | 8T-4205 | [2] | WASHER-HARD (7.2X14.5X2-MM THK) | |
| 35. | 8T-4224 | [1] | WASHER-HARD (8.8X16X2-MM THK) | |
| 36. | 9B-1117 | [4] | LOCKWASHER | |
| 38. | 5P-6025 D | LOCKWIRE (0.2-M EACH) | ||
| 38A. | 5P-6025 D | LOCKWIRE (0.1-M EACH) | ||
| 39. | 160-8755 M | [1] | BOLT (M6X1.0X10-MM) | |
| D | ORDER BY THE METER | |||
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
#KEBP62350379
438-1052: WIRING GP-SCREED HEATER
438-1052 WIRING GP-SCREED HEATER
S/N P651-UP; LR61-UP; ML61-UP
PART OF 439-8580 EXTENSION GP-SCREED
AN ATTACHMENT
S/N P651-UP; LR61-UP; ML61-UP
PART OF 439-8580 EXTENSION GP-SCREED
AN ATTACHMENT
For full view, you need register
Parts for your AP600F ASPHALT PAVER:
CATERPILLAR SIS| Pos. | Part No | Qty | Parts name | Comments |
|---|---|---|---|---|
| 1. | 1S-2342 | [1] | STRAP AS-GROUND | |
| 2. | 3S-2093 | [4] | STRAP-CABLE | |
| 3. | 7K-1181 | [12] | STRAP-CABLE | |
| 4. | 132-8485 | [2] | NUT-RING | |
| 5. | 336-2011 | [1] | SENSOR GP-TEMPERATURE (SCREED HEAT) | |
| 102-8802 | [1] | KIT-RECEPTACLE (2-PIN) | ||
| (INCLUDES RECEPTACLE AS & WEDGE) | ||||
| 9X-3401 | [2] | PIN-CONNECTOR (16-GA TO 18-GA) | ||
| 6. | 399-6960 | [1] | HEATER AS-SCREED (675-VOLT, 664-WATT) | |
| 418-6712 | [1] | PLUG AS-CONNECTOR | ||
| 7. | 417-1001 | [1] | PLATE | |
| 8. | 438-1037 Y | [1] | HARNESS AS-WIRING (EXTENSION) | |
| 9. | 438-1050 Y | [1] | BOX GP-JUNCTION (EXTENSION) | |
| 10. | 450-5557 | [1] | HEATER AS (675-VOLT, 3350-WATT) | |
| 418-6712 | [1] | PLUG AS-CONNECTOR | ||
| 11. | 061-8844 | [1] | GROMMET | |
| 12. | 096-6166 | [2] | WASHER-HARD (4.5X9X1-MM THK) | |
| 13. | 107-4749 | [1] | PLATE | |
| 14. | 124-7346 | [2] | LOCKWASHER | |
| 15. | 1G-8781 | [2] | CLAMP (HALF) | |
| 16. | 204-2281 | [1] | STRAP-CABLE | |
| 17. | 204-8000 | [1] | MOUNTING-CABLE TIE | |
| 18. | 381-2621 | [2] | MOUNTING-CABLE TIE | |
| 19. | 399-9056 Y | [1] | HARNESS AS-WIRING (POWER) | |
| 20. | 5C-8312 M | [2] | NUT (M4X0.7-THD) | |
| 21. | 6V-9491 M | [2] | SCREW-MACHINE (M4X0.7X20-MM) | |
| 22. | 7P-1695 | [2] | WASHER (10.5X19X3-MM THK) | |
| 23. | 7X-2533 M | [2] | BOLT (M6X1X35-MM) | |
| 24. | 7X-2538 M | [2] | BOLT (M8X1.25X100-MM) | |
| 25. | 8C-8560 | [4] | SCREW-LOCK (4-40X0.5-IN) | |
| 26. | 8T-4121 | [3] | WASHER-HARD (11X21X2.5-MM THK) | |
| 27. | 8T-4133 M | [2] | NUT (M10X1.5-THD) | |
| 28. | 8T-4136 M | [3] | BOLT (M10X1.5X25-MM) | |
| 29. | 8T-4138 M | [2] | BOLT (M6X1X20-MM) | |
| 30. | 8T-4205 | [2] | WASHER-HARD (7.2X14.5X2-MM THK) | |
| 31. | 8T-4224 | [2] | WASHER-HARD (8.8X16X2-MM THK) | |
| 32. | 9B-1117 | [4] | LOCKWASHER | |
| 33. | 5P-6025 D | LOCKWIRE (0.1-M EACH) | ||
| 33A. | 5P-6025 D | LOCKWIRE (0.2-M) | ||
| D | ORDER BY THE METER | |||
| M | METRIC PART | |||
| Y | SEPARATE ILLUSTRATION | |||
Information:
ELECTRICAL AND STARTING SYSTEM
WIRING GP
Special Instruction
Reuse And Salvage Guidelines
Guideline for Visual Inspection and Repair of Foam Wiring Harness {0649, 1408, 1408, 1408, 1408}
Guideline for Visual Inspection and Repair of Foam Wiring Harness {0649, 1408, 1408, 1408, 1408}
Guideline for Visual Inspection and Repair of Foam Wiring Harness {0649, 1408, 1408, 1408, 1408}
