AVSPARE.COM
parts catalog
  1. Home
  2. Caterpillar catalog

142-4457 EXCITER GP -POWER S/N 4GN1-618 PART OF 144-1827 GENERATOR GP 3516B INDUSTRIAL ENGINE


GENERATORS
GENERATOR GP

INDUSTRIAL ENGINE 3516B INDUSTRIAL ENGINE PYL
 3516B Generator Set PYL00001-UP M0070666 3516B PYL   (2016)

GENERATORS

GENERATOR GP
COUPLING GP-GENERATOR DRIVE
384-1295 COUPLING GP-GENERATOR DRIVE
EXCITER GP
142-4453 EXCITER GP
EXCITER GP
142-4457 EXCITER GP
EXCITER GP
215-2402 EXCITER GP
144-1828 GENERATOR AR
296-0412 GENERATOR AR
 

#M00706660600
 

142-4457: EXCITER GP

142-4457 EXCITER GP -POWER
S/N 4GN1-618
PART OF 144-1827 GENERATOR GP
i00658543 M0070666
1424457 EXCITER GP Parts scheme
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 6I-4911 [1] ROTOR-EXCITER  
2. 124-1426 [1] STATOR-EXCITER  
3. 1F-5842 [4] BOLT (5/16-18X3.25-IN)  
4. 9M-1974 [4] WASHER-HARD (8.8X16X2-MM THK)  
 

#M00706660601
 

215-2402: EXCITER GP

215-2402 EXCITER GP -POWER
S/N 4GN1-UP
PART OF 144-1827, 296-0411 GENERATOR GP
i01692957 M0070666
2152402 EXCITER GP Parts scheme
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 206-6224 [1] ROTOR-EXCITER  
2. 215-2404 [1] STATOR-EXCITER  
3. 8H-8769 [4] BOLT (5/16-18X4.25-IN)  
4. 9M-1974 [4] WASHER-HARD (8.8X16X2-MM THK)  
 

#M00706660602
 

144-1828: GENERATOR AR

144-1828 GENERATOR AR
S/N 4GN1-UP
60-HERTZ. 480-VOLT
i01115069 M0070666
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
  144-1827 Y [1] GENERATOR GP  
   
  131-4254 [1] KIT-PARTS (GENERATOR)  
    S/N 4GN1-618
    (INCLUDES DRIVERS, JUMPERS, SEPARATORS, STOPS & TERMINALS)
  171-6719 [1] KIT-PARTS (GENERATOR)  
    S/N 4GN619-UP
    (INCLUDES END STOP, DIVIDERS, TERMINAL BLOCKS, JUMPERS, TOOL, FUSES & PLUGS)
   
  118-8452 [1] FILM-INFORMATION (GENERATOR)  
    INSTALL FILM ON THE RH SIDE OF THE GENERATOR BARREL, CENTERED FROM FRONT TO BACK,
    APPROX. 100MM DOWN FROM THE CENTER LINE AT THE TOP OF THE GENERATOR.
    INSTALL CLEAR LAMINATE OVER FILM.
  3N-8764 [1] FILM-CONNECTION (SPACE HEATER)  
    FILM IS PROVIDED BY SUPPLIER.
    INSTALL INSIDE OF GENERATOR HOUSING ON PANEL NEXT TO SPACE HEATER TERMINAL STRIP.
  7W-5893 [4] FILM-INFORMATION (GENERATOR LIFTING)  
    INSTALL ONE DIRECTLY ABOVE EACH LIFTING HOLE ON GENERATOR BARREL.
  228-4798 [1] FILM-IDENTIFICATION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  303-3433 [1] FILM-IDENTIFICATION (CATERPILLAR)  
    INSTALL FILM ON THE REAR PANEL OF THE GENERATOR TERMINAL BOX, CENTERED APPROX. 30MM FROM THE TOP OF THE REAR PANEL.
  303-3440 [2] FILM-IDENTIFICATION (CAT)  
    INSTALL FILM ON THE REAR PANEL OF THE GENERATOR TERMINAL BOX, CENTERED APPROX. 30MM FROM THE TOP OF THE REAR PANEL.
    IF THERE IS AN AIR CLEANER INSTALLED,
    MOVE FILM BELOW AIR CLEANER CENTERED ALONG THE TOP EDGE OF THE BOTTOM HALF MOON SHAPED COVER.
  225-3224 [3] FILM-WARNING (AUTOMATIC ENGINE START)  
    INSTALL ONE FILM ON THE RH & LH SIDES OF THE GENERATOR TERMINAL BOX, CENTERED ABOVE THE CRUSH WARNING FILM
    AND ONE FILM ON THE REAR OF THE TERMINAL BOX, CENTERED BELOW THE 229-5047 FILM.
  225-3227 [2] FILM-WARNING (HOT SURFACE)  
    INSTALL ONE FILM ON EACH SIDE OF THE GENERATOR BARREL, DIRECTLY ON THE GENERATOR BARREL, NOT ON THE BARREL COVER.
    IF THERE IS NO BARREL COVER, CENTER FILMS ON EACH SIDE OF THE BARREL FROM FRONT TO REAR,
    AND ON THE RH SIDE, CENTER FILM BELOW THE 118-8452 GLPS GENERATOR INFO FILM.
  229-5047 [3] FILM-WARNING (SHOCK HAZARD, READ OMM)  
    INSTALL ONE FILM ON THE RH & LH SIDES OF THE GENERATOR TERMINAL BOX, CENTERED ABOVE THE AUTO START WARNING
    AND ONE FILM ON REAR OF THE TERMINAL BOX, CENTERED BELOW THE CATERPILLAR TRADEMARK DECAL.
  106-8061 [1] PLATE-GENERATOR (GREASE BEARING)  
    INSTALL ON GENERATOR FRONT PANEL ASSEMBLY ON RH SIDE OF PACKAGE, NEXT TO GENERATOR INFORMATION PLATE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)  
    INSTALL ON RH SIDE OF GENERATOR BARREL AT FRONT USING 2K-3219 DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  R   REMANUFACTURED PART MAY BE AVAILABLE
  Y   SEPARATE ILLUSTRATION
 

#M00706660603
 

296-0412: GENERATOR AR

296-0412 GENERATOR AR
S/N 4GN1-UP
60-HERTZ. 480-VOLT
i03202103 M0070666
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
  296-0411 Y [1] GENERATOR GP  
   
  118-8452 [1] FILM-INFORMATION (GENERATOR)  
    INSTALL FILM ON THE RH SIDE OF THE GENERATOR BARREL, CENTERED FROM FRONT TO BACK,
    APPROX. 100MM DOWN FROM THE CENTER LINE AT THE TOP OF THE GENERATOR.
    INSTALL CLEAR LAMINATE OVER FILM.
  7W-5893 [4] FILM-INFORMATION (GENERATOR LIFTING)  
    INSTALL ONE DIRECTLY ABOVE EACH LIFTING HOLE ON GENERATOR BARREL.
  228-4798 [1] FILM-IDENTIFICATION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  303-3433 [1] FILM-IDENTIFICATION (CATERPILLAR)  
    INSTALL FILM ON THE REAR PANEL OF THE GENERATOR TERMINAL BOX, CENTERED APPROX. 30MM FROM THE TOP OF THE REAR PANEL.
  303-3440 [2] FILM-IDENTIFICATION (CAT)  
    INSTALL ONE FILM ON THE RH & LH SIDE OF THE GENERATOR TERMINAL BOX, AT THE TOP LH CORNER OF THE TERMINAL BOX,
    ALIGN EACH FILM WITH THE EDGES OF THE TERMINAL BOX COVER.
  225-3224 [3] FILM-WARNING (AUTOMATIC ENGINE START)  
    INSTALL ONE FILM ON THE RH & LH SIDES OF THE GENERATOR TERMINAL BOX, CENTERED ABOVE THE CRUSH WARNING FILM,
    AND ONE FILM ON THE REAR OF THE TERMINAL BOX, CENTERED BELOW THE 229-5047 FILM,
    IF THE GENERATOR IS EQUIPPED WITH LOUVERS, MOVE FILM TO THE RH SIDE OF THE CATERPILLAR TRADEMARK DECAL.
  225-3227 [2] FILM-WARNING (HOT SURFACE)  
    INSTALL ONE FILM ON EACH SIDE OF THE GENERATOR BARREL, DIRECTLY ON THE GENERATOR BARREL, NOT ON THE BARREL COVER.
    IF THERE IS NO BARREL COVER, CENTER FILMS ON EACH SIDE OF THE BARREL FROM FRONT TO REAR,
    AND ON THE RH SIDE, CENTER FILM BELOW THE 118-8452 GLPS GENERATOR INFO FILM.
  229-5047 [3] FILM-WARNING (SHOCK HAZARD, READ OMM)  
    INSTALL ONE FILM ON THE RH & LH SIDES OF THE GENERATOR TERMINAL BOX, CENTERED ABOVE THE AUTO START WARNING,
    AND ONE FILM ON THE REAR OF THE TERMINAL BOX, CENTERED BELOW THE CATERPILLAR TRADEMARK DECAL
    IF THE GENERATOR IS EQUIPPED WITH LOUVERS, MOVE FILM TO THE LH SIDE OF THE CATERPILLAR TRADEMARK DECAL.
  Y   SEPARATE ILLUSTRATION
 

#M00706660604
 

363-1218: GENERATOR AR

363-1218 GENERATOR AR
S/N 4GN1-UP
60-HERTZ. 480-VOLT
i04758651 M0070666
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
  363-1217 Y [1] GENERATOR GP  
   
  171-6719 [1] KIT-PARTS (GENERATOR)  
    (INCLUDES END STOP, DIVIDERS, TERMINAL BLOCKS, JUMPERS, TOOL, FUSES & PLUGS))
   
  118-8452 [1] FILM-INFORMATION (GENERATOR)  
    INSTALL FILM ON THE RH SIDE OF THE GENERATOR BARREL, CENTERED FROM FRONT TO BACK,
    APPROX. 100MM DOWN FROM THE CENTER LINE AT THE TOP OF THE GENERATOR.
    INSTALL CLEAR LAMINATE OVER FILM.
  7W-5893 [4] FILM-INFORMATION (GENERATOR LIFTING)  
    INSTALL ONE DIRECTLY ABOVE EACH LIFTING HOLE ON GENERATOR BARREL.
  228-4798 [1] FILM-IDENTIFICATION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  303-3433 [1] FILM-IDENTIFICATION (CATERPILLAR)  
    INSTALL FILM ON THE REAR PANEL OF THE GENERATOR TERMINAL BOX, CENTERED APPROX. 30MM FROM THE TOP OF THE REAR PANEL.
  303-3440 [2] FILM-IDENTIFICATION (CAT)  
    INSTALL ONE FILM ON THE RH & LH SIDE OF THE GENERATOR TERMINAL BOX, AT THE TOP LH CORNER OF THE TERMINAL BOX,
    ALIGN EACH FILM WITH THE EDGES OF THE TERMINAL BOX COVER.
  225-3224 [3] FILM-WARNING (AUTOMATIC ENGINE START)  
    INSTALL ONE FILM ON THE RH & LH SIDES OF THE GENERATOR TERMINAL BOX, CENTERED ABOVE THE CRUSH WARNING FILM,
    AND ONE FILM ON THE REAR OF THE TERMINAL BOX, CENTERED BELOW THE 229-5047 FILM,
    IF THE GENERATOR IS EQUIPPED WITH LOUVERS, MOVE FILM TO THE RH SIDE OF THE CATERPILLAR TRADEMARK DECAL.
  225-3227 [2] FILM-WARNING (HOT SURFACE)  
    INSTALL ONE FILM ON EACH SIDE OF THE GENERATOR BARREL, DIRECTLY ON THE GENERATOR BARREL, NOT ON THE BARREL COVER.
    IF THERE IS NO BARREL COVER, CENTER FILMS ON EACH SIDE OF THE BARREL FROM FRONT TO REAR,
    AND ON THE RH SIDE, CENTER FILM BELOW THE 118-8452 GLPS GENERATOR INFO FILM.
  229-5047 [3] FILM-WARNING (SHOCK HAZARD, READ OMM)  
    INSTALL ONE FILM ON THE RH & LH SIDES OF THE GENERATOR TERMINAL BOX, CENTERED ABOVE THE AUTO START WARNING,
    AND ONE FILM ON THE REAR OF THE TERMINAL BOX, CENTERED BELOW THE CATERPILLAR TRADEMARK DECAL
    IF THE GENERATOR IS EQUIPPED WITH LOUVERS, MOVE FILM TO THE LH SIDE OF THE CATERPILLAR TRADEMARK DECAL.
  Y   SEPARATE ILLUSTRATION
 

#M00706660605
 

144-1827: GENERATOR GP

144-1827 GENERATOR GP
S/N 4GN1-618
60-HERTZ. 480-VOLT. 827-FRAME, 6-POLE, 6-LEAD, 2-BEARING
PART OF 144-1828 GENERATOR AR
i00663814 M0070666
1441827 GENERATOR GP Parts scheme
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 154-1901 Y [1] CONNECTION GP-TERMINAL STRIP (LOW VOLTAGE)  
2. 121-9640 Y [1] CONNECTION GP-ELECTRICAL (RESISTIVE TEMPERATURE DEVICE)  
3. 124-7659 [1] SLEEVE-SHAFT (SHAFT)  
4. 154-3477 Y [1] TRANSFORMER GP-POTENTIAL (MEDIUM VOLTAGE)  
5. 141-4987 Y [1] COVER GP-GENERATOR  
6. 142-4452 Y [1] RECTIFIER GP-REVOLVING  
7. 142-4453 Y [1] EXCITER GP (PERMANENT MAGNET)  
8. 152-5179 Y [1] BRACKET GP-MOUNTING (OPPOSITE DRIVE END)  
9. 154-3413 Y [1] ADAPTER GP-GENERATOR COUPLING  
10. 142-4457 Y [1] EXCITER GP (POWER)  
11. 144-9056 Y [1] TRANSFORMER GP-CURRENT  
12. 145-6001 Y [1] SCREEN GP-AIR (AIR EXIT)  
13. 145-6002 Y [1] SCREEN GP-AIR (AIR EXIT)  
14. 145-7468 Y [1] ROTOR GP-GENERATOR  
15. 145-7664 Y [1] STATOR GP-MAIN  
  Y   SEPARATE ILLUSTRATION
 

#M00706660606
 

144-1827: GENERATOR GP

144-1827 GENERATOR GP
S/N 4GN619-UP
60-HERTZ. 480-VOLT. 827-FRAME, 6-POLE, 6-LEAD, 2-BEARING
PART OF 144-1828 GENERATOR AR
i02844602 M0070666
1441827 GENERATOR GP Parts scheme
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 154-1901 Y [1] CONNECTION GP-TERMINAL STRIP (LOW VOLTAGE)  
2. 206-5967 [1] SLEEVE-SHAFT (SHAFT)  
3. 141-4987 Y [1] COVER GP-GENERATOR  
4. 215-2402 Y [1] EXCITER GP (POWER)  
5. 142-4453 Y [1] EXCITER GP (PERMANENT MAGNET)  
6. 298-3817 CY [1] RECTIFIER GP-REVOLVING  
7. 154-3413 Y [1] ADAPTER GP-GENERATOR COUPLING  
8. 145-7664 Y [1] STATOR GP-MAIN  
9. 145-6001 Y [1] SCREEN GP-AIR (AIR EXIT)  
10. 145-6002 Y [1] SCREEN GP-AIR (AIR EXIT)  
11. 152-5179 Y [1] BRACKET GP-MOUNTING (OPPOSITE DRIVE END)  
12. 208-0393 Y [1] ROTOR GP-GENERATOR  
   
  134-0040 F [1] HUB-FLEXIBLE COUPLING (1-M)  
  C   CHANGE FROM PREVIOUS TYPE
  F   NOT SHOWN
  Y   SEPARATE ILLUSTRATION
 

#M00706660607
 

296-0411: GENERATOR GP

296-0411 GENERATOR GP
S/N 4GN1-UP
60-HERTZ. 480-VOLT. 827-FRAME, 6-POLE, 6-LEAD, 2-BEARING
PART OF 296-0412 GENERATOR AR
i05498730 M0070666
2960411 GENERATOR GP Parts scheme
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 141-4987 Y [1] COVER GP-GENERATOR  
2. 142-4453 Y [1] EXCITER GP (PERMANENT MAGNET)  
3. 145-6001 Y [1] SCREEN GP-AIR (AIR EXIT)(GENERATOR)  
4. 145-6002 Y [1] SCREEN GP-AIR (AIR EXIT)(ADAPTER)  
5. 152-5179 Y [1] BRACKET GP-MOUNTING (OPPOSITE DRIVE END)  
6. 154-1901 Y [1] CONNECTION GP-TERMINAL STRIP (LOW VOLTAGE)  
7. 154-3413 Y [1] ADAPTER GP-GENERATOR COUPLING  
8. 206-5967 [1] SLEEVE-SHAFT (SHAFT)  
9. 215-2402 Y [1] EXCITER GP (POWER)  
10. 298-3817 Y [1] RECTIFIER GP-REVOLVING  
11. 145-7664 Y [1] STATOR GP-MAIN  
12. 208-0393 CY [1] ROTOR GP-GENERATOR  
  235-8130 CF [1] HUB-FLEXIBLE COUPLING  
  C   CHANGE FROM PREVIOUS TYPE
  F   NOT SHOWN
  Y   SEPARATE ILLUSTRATION
 

#M00706660608
 

363-1217: GENERATOR GP

363-1217 GENERATOR GP
S/N 4GN1-UP
60-HERTZ. 480-VOLT. 827-FRAME, 6-LEAD
PART OF 363-1218 GENERATOR AR
i04758663 M0070666
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
    (NO SERVICED PARTS)
 

#M00706660609
 

125-2114: HEAT SINK AS

125-2114 HEAT SINK AS
S/N 4GN1-UP
PART OF 142-4452 RECTIFIER GP-REVOLVING
i00520700 M0070666
1252114 HEAT SINK AS Parts scheme
  For full view, you need register

Parts for your 3516B INDUSTRIAL ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 2R-8159 [4] BOLT-SOCKET HEAD (10-32X1.5-IN)  
2. 4B-2043 [1] NUT (8-32-THD)  
3. 4B-2049 [4] NUT (10-32-THD)  
4. 4P-6009 [1] VARISTOR  
5. 7E-0127 [1] RESISTOR AS  
6. 7S-1197 [1] SCREW-MACHINE (8-32X0.5-IN)  
7. 9B-7233 [1] LOCKWASHER  
8. 110-4422 [1] RECTIFIER (POSITIVE)  
9. 110-4424 [1] RECTIFIER (NEGATIVE)  
10. 117-8556 [4] WASHER (5.6X7.8X0.5-MM THK)  
11. 5P-0537 [2] WASHER-HARD (7.2X14.5X2-MM THK)  
12. 9F-7022 [2] BOLT (1/4-20X1.5-IN)  
13. 9S-8750 [2] NUT-FULL (1/4-20-THD)  
 

Information:

General Service Information
Safety
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Identification
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Abbreviations
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Symbols
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Components
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Energize To Run Engine System
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Schematics And Wiring Diagrams
SR4 GENERATOR MOUNTED CONTROL PANEL FOR SPARK IGNITED (SI) E
Operation
FLOOR-STANDING SWITCHGEAR
Automatic Start-Stop
FLOOR-STANDING SWITCHGEAR
Alternating Current Components Troubleshooting
FLOOR-STANDING SWITCHGEAR
Automatic Start-Stop Troubleshooting
FLOOR-STANDING SWITCHGEAR
Engine News
New Part Kits Available For SR4B Generators{4469}
1996/06/12
Special Instruction, REHS0345, "Generator Service Literature Index" Is Available {4450}
1998/11/01
New Maintenance Information For Generators{4450}
1998/12/01
Use 152-7143 Cable Assembly For Flash-Programming Generator Status Control Module{4450}
1999/02/01
Special Instruction, REHS0345-01, "Generator Service Literature Index" Is Available{4450}
1999/04/01
New Control Panel Films Show That SR4B Generators Are Not To Be Wired In The Delta Configuration{7557,7566}
1999/04/01
Improved Rectifiers Increases Service Life {4473}
2003/06/01
Proper Application and Operation of Generator Set Will Increase Varistor Life and Will Minimize Generator Set Repair Costs and Down Time {4466}
2003/10/01
Improved Rectifier Assembly Is Now Used {4465}
2005/10/10
Updated Cat EPD Alternator Failure Report Template Is Now Available for Cat Generator Sets {1404}
2011/05/25
Operation and Maintenance Manual
Bearing (Spherical Roller) - Lubricate
SR500 Generators
Insulation - Test
SR500 Generators
Stator Winding Temperature - Measure/Record
SR500 Generators
Bearing Temperature - Measure/Record
SR500 Generators
Rotating Rectifier - Test
SR500 Generators
Varistor - Test
SR500 Generators
Winding - Test
SR500 Generators
Bearing (Ball) - Lubricate - Generator
SR500 Generators
Rotating Rectifier - Test
SR500 Generators
Special Instruction
Cooling Air Filter Installation For 680 And 800 Frame Generators{7263}
Cooling Air Filter Installation For 680 And 800 Frame Generators{7263}
Generator Service Literature Index{4450}
Generator Service Literature Index{4450}
Grounding Design Guide for Electric Power Generation Products {4450, 4459}
Grounding Design Guide for Electric Power Generation Products {4450, 4459}
Generator Bearing Service {4457}
Generator Bearing Service {4457}
Instructions for Installing AssetIQ<SUP>TM</SUP> for Commercial Generator Set Systems on Caterpillar and non-Caterpillar Products {4450, 7490}
Instructions for Installing AssetIQTM for Commercial Generator Set Systems on Caterpillar and non-Caterpillar Products {4450, 7490}
Technical Information Bulletin
Generator Lead Connections Can Rub Against The Terminal Box Or Each Other
Generator Lead Connections Can Rub Against The Terminal Box Or Each Other
Paralleling Generators To Utility Substations
Paralleling Generators To Utility Substations
Reported Failures Of 110-4422 Rectifiers And 110-4424 Rectifiers On 3500-Series Generator Sets
Reported Failures Of 110-4422 Rectifiers And 110-4424 Rectifiers On 3500-Series Generator Sets
Application of Thermally Conductive 4C-6715 Rectifier Silicone Kit when Installing 9Y-0916 Rectifier Assembly
Application of Thermally Conductive 4C-6715 Rectifier Silicone Kit when Installing 9Y-0916 Rectifier Assembly
Specifications
General Information
SR4 and SR4B Electric Power Generation Rewind Data
Generator Identification
SR4 and SR4B Electric Power Generation Rewind Data
Component Views
SR4 and SR4B Electric Power Generation Rewind Data
Connection Diagrams for Exciter
SR4 and SR4B Electric Power Generation Rewind Data
Connection Diagrams for Main Stator and Main Rotor
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-0001</B> Generator through <B>5N-0025</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>102-2415</B> Generator through <B>108-3052</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>109-1595</B> Generator through <B>109-3774</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-0027</B> Generator through <B>5N-0050</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-0051</B> Generator through <B>5N-0075</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-0076</B> Generator through <B>5N-0090</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-0431</B> Generator through <B>5N-7207</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>111-8240</B> Generator through <B>112-1481</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>115-5101</B> Generator through <B>121-6860</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>121-6882</B> Generator through <B>123-3185</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>129-1502</B> Generator through <B>129-5034</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-7208</B> Generator through <B>5N-7232</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-7233</B> Generator through <B>5N-7309</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>130-0234</B> Generator through <B>130-7595</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-8891</B> Generator through <B>5N-8911</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>5N-9081</B> Generator through <B>5N-9432</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>4P-2236</B> Generator through <B>4P-9907</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>4W-0183</B> Generator through <B>4W-9669</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>7C-1601</B> Generator through <B>7C-9126</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>7E-0097</B> Generator through <B>7E-9695</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>7W-1877</B> Generator through <B>7W-8825</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>9Y-0157</B> Generator through <B>9Y-0389</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>9Y-0390</B> Generator through <B>9Y-0533</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for <B>9Y-1408</B> Generator through <B>9Y-9422</B> Generator
SR4 and SR4B Electric Power Generation Rewind Data
Terminology
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 144-0469 Generator through 144-0583 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 166-2651 Generator through 166-2689 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 166-2691 Generator through 166-7187 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 144-1811 Generator through 144-1951 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 147-9437 Generator through 147-9497 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 153-3081 Generator through 153-3098 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 167-1351 Generator through 167-1354 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 126-8022 Generator through 128-7424 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 136-6580 Generator through 136-6609 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 141-5534 Generator through 142-9900 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 144-1666 Generator through 144-1766 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 136-6610 Generator through 136-6641 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 144-1964 Generator through 144-2088 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 149-2447 Generator through 150-9152 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 158-6410 Generator through 163-8546 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 164-0975 Generator through 164-4946 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 173-7078 Generator through 194-6563 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 203-5749 Generator through 324-5120 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 6I-0053 Generator through 6I-4860 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Winding Data for 109-3776 Generator through 109-7874 Generator
SR4 and SR4B Electric Power Generation Rewind Data
Systems Operation
Generator Operation
SR4B Generators
General Information
SR4B Generators
Component Descriptions
SR4B Generators
Glossary
SR4B Generators
Main Revolving Field Connections (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Options (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Main Revolving Field Connections (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Options (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
General Information (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
General Information (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Generator Wiring Diagrams (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Main Stator and Voltage Sensing Lead Connections (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Main Stator and Voltage Sensing Lead Connections (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Oil Field Generator Connections (SR4)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Testing and Adjusting
General Information
SR4B Generators
Troubleshooting
SR4B Generators
Generator Set - Test
SR4B Generators
Varistor - Test
SR4B Generators
Rotating Rectifier - Test
SR4B Generators
Winding - Test
SR4B Generators
Resistor - Test
SR4B Generators
Exciter Field - Flash
SR4B Generators
Generator - Dry
SR4B Generators
Insulation - Test
SR4B Generators
Disassembly and Assembly
Coupling - Install
SR4B Generators
Coupling - Remove
SR4B Generators
Bearing - Remove and Install
SR4B Generators
Rotor - Remove and Install
SR4B Generators
Generator - Align
SR4B Generators
Generator - Install
SR4B Generators
Generator - Remove
SR4B Generators
Exciter - Remove and Install
SR4B Generators
Service Magazine
Use 139-2788 Ferrule (AWG 24-12) And 139-2789 Ferrule (AWG 10-6) Crimp Tools For Repairing 3500 SR4B Generator Wiring Harness {1403}
1998/03/02
Use 142-5055 Insulation Tester Group To Measure And Check Insulation Resistance{4450,0785}
1998/03/23
Special Instruction, REHS0345, &quot;Generator Service Literature Index&quot; Is Available{4450}
1998/10/26
Special Instruction, REHS0345-01, &quot;Generator Service Literature Index&quot; Is Available {4450}
1999/04/12
New 155-5175 AC Current Probe For Generator Sets Now Available{1400,4450,0734,7002}
1999/05/24
A List Of Contacts For Caterpillar Product Support Is Available {1000, 4450, 7000}
2002/03/25

Caterpillar Parts SIS Catalog 3516B :

EXCITER GP
142-4453 EXCITER GP
COUPLING GP-GENERATOR DRIVE
384-1295 COUPLING GP-GENERATOR DRIVE
361-2453 CONVERSION GP-GENERATOR
122-3487 CONVERSION GP-GENERATOR
CONNECTION GP-TERMINAL STRIP
154-1901 CONNECTION GP-TERMINAL STRIP
122-0328 CONNECTION GP-TERMINAL STRIP
CONNECTION GP-TERMINAL STRIP
121-9480 CONNECTION GP-TERMINAL STRIP
CONNECTION GP-TERMINAL STRIP
118-9430 CONNECTION GP-TERMINAL STRIP
EXCITER GP
215-2402 EXCITER GP
144-1828 GENERATOR AR
296-0412 GENERATOR AR
363-1218 GENERATOR AR
GENERATOR GP
144-1827 GENERATOR GP
GENERATOR GP
144-1827 GENERATOR GP
GENERATOR GP
296-0411 GENERATOR GP
363-1217 GENERATOR GP

Truck sale:

Caterpillar 3516B
 
Caterpillar 3516B
- Stationary Generator Sets
RING POWER CORP.
 
500,000 
Caterpillar 3516B, Stationary Generator Sets, Construction
- Stationary Generator Sets
FINNING CHILE S.A.
 
350,000 
Caterpillar 3516B, Stationary Generator Sets, Construction


Caterpillar 3516B
 
Caterpillar 3516B
- Industrial engines
RING POWER CORP.
Caterpillar 3516B
 
Caterpillar 3516B
- Stationary Generator Sets
RING POWER CORP.
Back to top
Contacts Request list Affiliate disclosure
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.