2291471 MANIFOLD-HOUSING Caterpillar parts
C15
Rating:
Alternative (cross code) number:
CA2291471
229-1471
2291471
CA2291471
229-1471
2291471
TRUCK ENGINE,
Compatible equipment models: 2291471:
Information:
Table 1
Qty New Part Number Former Part Number(1)
1 525-7103 Fuel Level Sender As 341-1842 Fuel Level Sender As
5 099-2374 Bolts
1 359-8335 Rubber Gasket
1 155-2261 Plug Lock Wedge
(1) The former part number listed is for reference only and may differPreparing the Machine
Perform the following procedure for preparing the machine before replacing the fuel level sender:
Move the machine to a hard and level surface.
Engage the parking brake and ground the implements. Chock the wheels (in case of wheeled excavator).
Turn the engine start switch to the OFF position.
Lock out and tag out main power supply.Note: Refer to Operation and Maintenance Manual of the machine being serviced to perform proper shutdown and prepare for maintenance procedures.Installation Procedure
Perform the following procedure to replace the fuel level sender:
Illustration 1 g06235602
View of fuel level sender location
(1) Fuel Level Sender
Locate the fuel tank and fuel level sensor. Refer to Illustration 1.
Drain fuel from the tank and ensure that the level is below the fuel sensor mounting location.
Disconnect the old fuel level sensor harness connector from the machine harness.
Remove five 099-2374 Bolts and five 8T-0328 Hard Washers.
Remove the sensor from fuel tank along with the gasket.
Utilizing a scraper and a rag, remove sealant residue from the tank. Wash and dry the flange surface.Note: Make sure that the surface of the tank is clean and dry.
Install a new 525-7103 Fuel Level Sender As and a 359-8335 Rubber Gasket into the fuel tank using five 099-2374 Bolts.
Illustration 2 g06233698
Torque pattern
(2) Bolt
(3) Washer
Tighten the 5 bolts in star pattern (1-2-3-4-5) using torque of 1.4 0.10 N m (1.0 0.07 lb ft). Verify the value after initial torque to avoid gasket compression. Refer to Illustration 2.
Illustration 3 g06233677
Plug seal and plug wedge
(4) Machine Side DT - Plug Seal
(5) Machine Side DT - Plug Wedge
On the machine harness, if the DT plugs seal is swollen from absorbing moisture, replace the plug seal with a 155-2261 Plug Lock Wedge. Refer to Illustration 3.
Connect the sensor connector to the machine harness connector.
Restore the machine power. Start the machine and confirm that there are no fuel leaks.
In the operator station (cab) display, verify that the fuel level indication is correct.
Use Cat® Electronic Technician (Cat ET) to check for any diagnostic codes related to sensor installation.
Restore the machine to normal operating condition.
Caterpillar parts catalog:
Parts manifold Caterpillar catalog:
2244324
MANIFOLD GP-EXHAUST
789D, C15, TH35-C15T
789D, C15, TH35-C15T
1979619
MANIFOLD GP-FUEL
365C, 365C L, 365C L MH, 621B, 621G, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 637E, 637G, 651B, 657E, 657G, 824C, C-15, C-16, C-18, C15, C16, C18, CX31-C15I, CX35-P800, TH35-C15I
365C, 365C L, 365C L MH, 621B, 621G, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 637E, 637G, 651B, 657E, 657G, 824C, C-15, C-16, C-18, C15, C16, C18, CX31-C15I, CX35-P800, TH35-C15I
2244322
MANIFOLD GP-EXHAUST
C15, TH35-C15T
C15, TH35-C15T
1680300
MANIFOLD
24M, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 621B, 621G, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 637E, 637G, 651B, 657E, 657G, 824C, 834G, 834H, 836...
24M, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 621B, 621G, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 637E, 637G, 651B, 657E, 657G, 824C, 834G, 834H, 836...
1333359
MANIFOLD-EXHAUST
24M, 3406B, 3406C, 3406E, 365C, 365C L, 365C L MH, 374D L, 374F L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 390F L, 583T, 587T, 621B, 621G, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 63...
24M, 3406B, 3406C, 3406E, 365C, 365C L, 365C L MH, 374D L, 374F L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 390F L, 583T, 587T, 621B, 621G, 623G, 627F, 627G, 631D, 631E, 631G, 633E II, 637D, 63...
9N5679
MANIFOLD-BRAKESAVER
3406, 3406B, 3406C, 3406E, 3408, C-15, C-16, C15
3406, 3406B, 3406C, 3406E, 3408, C-15, C-16, C15
1460194
MANIFOLD-HOUSING
3406C, 3406E, C-15, C-16, C15, C16
3406C, 3406E, C-15, C-16, C15, C16
2396304
MANIFOLD-HOUSING
24M, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 824C, 824H, 825H, 826H, 834H, 836H, 980G, 980H, 986H, 988H, AD45B, AD55, C15, C18, PM-200, PM-201
24M, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 824C, 824H, 825H, 826H, 834H, 836H, 980G, 980H, 986H, 988H, AD45B, AD55, C15, C18, PM-200, PM-201
2316127
MANIFOLD-EXHAUST
C13, C15, TH35-C15T
C13, C15, TH35-C15T
2313462
MANIFOLD-EXHAUST
C13, C15, TH35-C15T
C13, C15, TH35-C15T
2223889
MANIFOLD
C-10, C-12
C-10, C-12
2239798
MANIFOLD-INLET
C-10, C-12
C-10, C-12
2250127
MANIFOLD-INLET
C-10, C-12
C-10, C-12
2223890
MANIFOLD
C-15
C-15
2554638
MANIFOLD-OIL
C11, C13
C11, C13
2313462
MANIFOLD-EXHAUST
C13, C15, TH35-C15T
C13, C15, TH35-C15T
2316127
MANIFOLD-EXHAUST
C13, C15, TH35-C15T
C13, C15, TH35-C15T
2396304
MANIFOLD-HOUSING
24M, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 824C, 824H, 825H, 826H, 834H, 836H, 980G, 980H, 986H, 988H, AD45B, AD55, C15, C18, PM-200, PM-201
24M, 365C, 365C L, 365C L MH, 374D L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 824C, 824H, 825H, 826H, 834H, 836H, 980G, 980H, 986H, 988H, AD45B, AD55, C15, C18, PM-200, PM-201