6C9089 NUT-CAP Caterpillar parts
307, 307B, 311B, 312, 312B L, 312C, 312D, 315, 315B L, 315C, 315D L, 317, 317B LN, 318B, 318C, 319C, 319D, 320 L, 320B, 320C, 322B LN, 322C, 323D L, 323D LN, 324D, 324D LN, 325 L, 325B L, 325C, 325D, ...
Rating:
Alternative (cross code) number:
CA6C9089
6C-9089
6C9089
CA6C9089
6C-9089
6C9089
Weight: 0.01 pounds 0 kg.
BACKHOE LOADER, WHEELED EXCAVATOR,
Compatible equipment models: 6C9089:
EXCAVATOR
307
311B
312
312B L
312C
312D
315
315B L
315C
315D L
317
317B LN
318B
318C
319C
319D
320 L
320B
320C
322B LN
322C
323D L
323D LN
324D
324D LN
325 L
325B L
325C
325D
325D L
329D L
330
330 L
330B L
330C
330C L
330D L
330D LN
330D MH
336D L
345B II
345B L
345C
345C L
345D L
350
350 L
365B
365B II
365C
365C L
365C L MH
374D L
375
375 L
385B
385C
385C FS
385C L
385C L MH
390D
390D L
M325D L MH
M325D MH
MINI HYD EXCAVATOR
307B
Number on catalog scheme:
63
For full view, you need register
Information:
The diagnostic circuit of the implement ECM identifies a system voltage that is below 18 DCV.The possible causes of this diagnostic code are listed:
The system voltage remains low for an extended time after the engine is started.
There is a connection with high impedance between the battery and the ECM.
There is a connection with high impedance between the ECM and system ground.
One set of batteries is disconnected with the key in the ON position. Also, the engine must not be running.System Response:The machine response is listed:
Implement functions will not work.
The pilot supply on/off solenoid for the implements will de-energize.Note: Ensure that CID 0168 FMI 01 is active and that the diagnostic code is active. Test Step 1. CHECK THE BATTERY VOLTAGE.
Start the engine.
Run the engine at high idle for several minutes.
Measure the battery voltage at the battery posts. Expected Result: The voltage should be greater than 18.0 DCV.Results:
OK - The voltage is greater than 18.0 DCV. The battery voltage is correct. Proceed to test step 2.
NOT OK - The voltage is less than 18.0 DCV. The charging system is not operating correctly. Repair: Check the charging system. Refer to Special Instruction, REHS0354, "Charging System Troubleshooting".STOPTest Step 2. CHECK THE SYSTEM VOLTAGE AT THE ECM.
Run the engine at high idle.
Locate the connector for the implement ECM .
Use 7X-1710 Multimeter Probe Group.
Measure the system voltage between J1-31 (wire 121-RD(Red)) and J1-13 (wire A272-BK(Black)). Measure the voltage between J1-39 (wire 121-RD(Red)) and J1-23 (wire A272-BK(Black)). Measure the system voltage between J1-47 (wire 121-RD(Red)) and J1-57 (wire A272-BK(Black)). Expected Result: The voltage should be less than 18.0 DCV.Results:
OK - Voltage is less than 18.0 DCV. The harness has failed.Repair: Repair the harness or replace the harness.STOP
NOT OK - Voltage is greater than 18.0 DCV. The system voltage is correct. Repair: Ensure that CID 0168 FMI 01 is active. Disconnect the harness connector from the ECM and inspect contacts J1-31, J1-39, J1-47, J1-13, J1-23 and J1-57 for corrosion or debris. Reconnect the harness connector to the ECM. If the diagnostic code is active, replace the ECM. See Testing and Adjusting, "Electronic Control Module (ECM) − Replace".STOP
The system voltage remains low for an extended time after the engine is started.
There is a connection with high impedance between the battery and the ECM.
There is a connection with high impedance between the ECM and system ground.
One set of batteries is disconnected with the key in the ON position. Also, the engine must not be running.System Response:The machine response is listed:
Implement functions will not work.
The pilot supply on/off solenoid for the implements will de-energize.Note: Ensure that CID 0168 FMI 01 is active and that the diagnostic code is active. Test Step 1. CHECK THE BATTERY VOLTAGE.
Start the engine.
Run the engine at high idle for several minutes.
Measure the battery voltage at the battery posts. Expected Result: The voltage should be greater than 18.0 DCV.Results:
OK - The voltage is greater than 18.0 DCV. The battery voltage is correct. Proceed to test step 2.
NOT OK - The voltage is less than 18.0 DCV. The charging system is not operating correctly. Repair: Check the charging system. Refer to Special Instruction, REHS0354, "Charging System Troubleshooting".STOPTest Step 2. CHECK THE SYSTEM VOLTAGE AT THE ECM.
Run the engine at high idle.
Locate the connector for the implement ECM .
Use 7X-1710 Multimeter Probe Group.
Measure the system voltage between J1-31 (wire 121-RD(Red)) and J1-13 (wire A272-BK(Black)). Measure the voltage between J1-39 (wire 121-RD(Red)) and J1-23 (wire A272-BK(Black)). Measure the system voltage between J1-47 (wire 121-RD(Red)) and J1-57 (wire A272-BK(Black)). Expected Result: The voltage should be less than 18.0 DCV.Results:
OK - Voltage is less than 18.0 DCV. The harness has failed.Repair: Repair the harness or replace the harness.STOP
NOT OK - Voltage is greater than 18.0 DCV. The system voltage is correct. Repair: Ensure that CID 0168 FMI 01 is active. Disconnect the harness connector from the ECM and inspect contacts J1-31, J1-39, J1-47, J1-13, J1-23 and J1-57 for corrosion or debris. Reconnect the harness connector to the ECM. If the diagnostic code is active, replace the ECM. See Testing and Adjusting, "Electronic Control Module (ECM) − Replace".STOP
Cat SIS web machinery list:
Parts nut Caterpillar catalog:
120G, 12G, 130G, 140G, 143H, 14G, 16, 160G, 160H, 1673C, 16G, 205B, 214B, 215, 215B, 224B, 235, 245, 3114, 3116, 320 L, 3204, 3208, 322 FM L, 325, 325 L, 325 LN, 330, 330 L, 3304, 3304B, 3306, 3306B, ...
216, 228, 236, 236B, 242B, 246C, 247, 247B, 248, 256C, 262C, 262C2, 267, 267B, 268B, 272C, 277C, 277C2, 279C, 279C2, 287, 287C, 287C2, 289C, 289C2, 297C, 299C, 3114, 3116, 3208, 3304, 3304B, 3306, 330...
120, 120B, 120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 12E, 12F, 12G, 12H, 12H ES, 12H NA, 12K, 12M 2, 130G, 135H, 135H NA, 140, 140B, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 143H, 14E, 14G,...
1090, 1190, 1190T, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 1290T, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 135H, 135H NA, 1390, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 143H, 14H, ...
1090, 1190, 1190T, 120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 1290T, 12E, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 1390, 140G, 140H, 140H ES, 14...
120H, 120K, 120K 2, 12H, 12K, 135H, 140H, 140K, 140K 2, 143H, 14H, 160H, 160K, 163H, 16H, 205, 205B, 206, 206B, 211B, 212, 212B, 213B, 214B, 224B, 24H, 301.5, 301.6C, 302.5, 302.5C, 307, 307B, 307C, 3...
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 12G, 12H, 12H ES, 12H NA, 12K, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 14G, 14H, 14H NA, 160H, 160H ES, 160H NA, 160K, 163H, ...
10-20B, 115, 120M, 120M 2, 12M, 12M 2, 12M 3, 12M 3 AWD, 1390, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H NA, 24H, 2590, 30/30, 302.5, 302.5C, 312, 315, 317, 320C, ...
313D2 LGP, 315B FM L, 315C, 315D L, 316E L, 317B LN, 318B, 318C, 318D L, 318D2 L, 319C, 320 L, 320B, 320B L, 320C, 320C L, 320N, 321C, OEMS
8C6437
NUT
205, 205B, 206, 206B, 211B, 212, 212B, 213B, 214B, 224B, 422E, 422F, 428E, 428F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 627H, 627K, 627K LRC, C-9, C9, C9.3, M312, M315, M318, M320, TH31-E61
205, 205B, 206, 206B, 211B, 212, 212B, 213B, 214B, 224B, 422E, 422F, 428E, 428F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 627H, 627K, 627K LRC, C-9, C9, C9.3, M312, M315, M318, M320, TH31-E61
1693261
NUT
416F, 420F, 422E, 422F, 428E, 428F, 430F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 450F, 725, 730, 735, 735B, 740, 740B, 770, 770G, 770G OEM, 772, 772G, 772G OEM, 773F, 773G, 773G LRC, 773G OEM, 775F...
416F, 420F, 422E, 422F, 428E, 428F, 430F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 450F, 725, 730, 735, 735B, 740, 740B, 770, 770G, 770G OEM, 772, 772G, 772G OEM, 773F, 773G, 773G LRC, 773G OEM, 775F...
120M, 120M 2, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 2384C, 2470C, 2484C, 24M, 2570C, 2670C, 2864C, 450E, ...
450E, 450F
2887210
NUT
450E, 450F
450E, 450F
2097457
NUT
450E, 450F, CP-533E, CP-54B, CP-56, CP-573E, CP-64, CP-663E, CP-68B, CP-74B, CP-76, CS-533E, CS-54, CS-54B, CS-56, CS-563D, CS-563E, CS-56B, CS-583E, CS-64, CS-64B, CS-663E, CS-66B, CS-683E, CS-68B, C...
450E, 450F, CP-533E, CP-54B, CP-56, CP-573E, CP-64, CP-663E, CP-68B, CP-74B, CP-76, CS-533E, CS-54, CS-54B, CS-56, CS-563D, CS-563E, CS-56B, CS-583E, CS-64, CS-64B, CS-663E, CS-66B, CS-683E, CS-68B, C...
3081892
NUT
216B, 216B3, 226B, 226B3, 232B, 242B, 247B, 247B3, 257B, 3011C, 3013C, 3024C, AP-255E, BB-621C, C0.5, C0.7, C1.1, C1.5, C1.6, C2.2, CB-14, CB-22, CB-334E, CB-34, CB22B, CB24B, CB32B, CB34B, CB34B XW, ...
216B, 216B3, 226B, 226B3, 232B, 242B, 247B, 247B3, 257B, 3011C, 3013C, 3024C, AP-255E, BB-621C, C0.5, C0.7, C1.1, C1.5, C1.6, C2.2, CB-14, CB-22, CB-334E, CB-34, CB22B, CB24B, CB32B, CB34B, CB34B XW, ...
3081889
NUT
216B, 216B3, 226B, 226B3, 232B, 242B, 247B, 247B3, 257B, 3011C, 3013C, 3024C, AP-255E, BB-621C, C0.5, C0.7, C1.1, C1.5, C1.6, C2.2, CB-14, CB-22, CB-334E, CB-34, CB22B, CB24B, CB32B, CB34B, CB34B XW, ...
216B, 216B3, 226B, 226B3, 232B, 242B, 247B, 247B3, 257B, 3011C, 3013C, 3024C, AP-255E, BB-621C, C0.5, C0.7, C1.1, C1.5, C1.6, C2.2, CB-14, CB-22, CB-334E, CB-34, CB22B, CB24B, CB32B, CB34B, CB34B XW, ...
216B, 226B, 232B, 242B, 247B, 257B, 312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320D, 320D L, 320D LN, 320D LRR, 320D RR, 320E L, 320E LN, 320E LRR, 323E L, 324E L, 324E LN, 329E L, 329E LN, 336E...
120M, 120M 2, 12M, 140M, 140M 2, 14M, 160M, 160M 2, 16M, 216B, 226B, 232B, 242B, 247B, 24M, 257B, 312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320D, 320D L, 320D LN, 320D LRR, 320D RR, 320E L, 320...
236D, 242D, 246D, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 301.6C, 302.5C, 416F, 420F, 422E, 422F, 428E, 428F, 430F, 432E, 432F, 434E, 434F, 442E, 444E, 444F, 910K, 914K
2039007
NUT
120M, 120M 2, 12M, 12M 2, 12M 3, 12M 3 AWD, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 216B3, 226B3, 236B3, 236D, 2384C, 242B3, 242D, 246D, 247B3, 2484C, 24M, 252B3,...
120M, 120M 2, 12M, 12M 2, 12M 3, 12M 3 AWD, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 216B3, 226B3, 236B3, 236D, 2384C, 242B3, 242D, 246D, 247B3, 2484C, 24M, 252B3,...