0968055 PIN-SPRING Caterpillar parts
304.5, 305.5, 306, 311, 416, 416B, 426B, 428, 428B, 438B, AS3143, AS4173, CWAC-40, E140, M312, M315, M318, M320, TH103, TH355B, TH460B, TH560B, TH580B, TH63, TH83, THP10 II
Rating:
Alternative (cross code) number:
CA0968055
096-8055
0968055
CA0968055
096-8055
0968055
Weight: 0.04 pounds 0 kg.
Information:
LENGTH
20
mm
OUTSIDE PIN DIAMETER
4
mm
ACCESS PLATFORM, WHEELED EXCAVATOR,
Compatible equipment models: 0968055:
Number on catalog scheme:
7
For full view, you need register
Information:
Illustration 1 g02106593
Schematic of the Temperature Sensor (Transmission Oil).
Illustration 2 g02786398This diagnostic code is associated with the Temperature Sensor (Transmission Oil). The FMI 03 means that the power train ECM has determined that the voltage of the circuit for the sensor is above normal.This diagnostic code may be recorded for the following reasons: transmission oil temperature may be too high. An open circuit has caused the power train ECM to determine that the temperature is too high, which is incorrect. The machine may not shift smoothly when the machine is cold.The possible causes of this diagnostic code are listed below:
The signal circuit for the sensor is open.
The signal circuit for the sensor is shorted to the +battery circuit.
The sensor has failed.
The power circuit or the ground circuit has failed.
The ECM has failed. ECM failure is unlikely.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear the diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 0177 FMI 03 is active before performing this procedure.Note: Use the 146-4080 Digital Multimeter for the measurements in this procedure.Test Step 1. CHECK FOR POWER AT THE SENSOR.
Do not disconnect the harness connector from the sensor.
Turn the key start switch and the disconnect switch to the ON position.
At the back of the harness connector for the sensor, insert a 7X-1710 Multimeter Probe along the voltage supply wire (contact 1).
Measure the voltage from contact 1 to frame ground. Expected Result:The voltage is 5 VDC.Results:
OK - The voltage is 5 VDC. Proceed to Test Step 2.
NOT OK - The voltage is not 5 VDC. The +battery circuit in the machine harness has failed.Repair: Replace the machine harness or repair the machine harness.STOPTest Step 2. CHECK FOR PROPER GROUND AT THE SENSOR.
The machine harness remains connected to the sensor.
Turn the key start switch and the disconnect switch to the OFF position.
Remove the 7X-1710 Multimeter Probe from the voltage supply wire (contact 1).
At the back of the harness connector for the sensor, insert a 7X-1710 Multimeter Probe along the ground wire (contact 2).
Measure the resistance from contact 2 to frame ground. Expected Result:The resistance is less than 5 ohms.Results:
OK
Cat SIS web machinery list:
Parts pin Caterpillar catalog:
216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3, 242D, 246C, 246D, 247, 247B, 247B3, 248, 252B, 252B3, 256C, 257B, 257B3, 257D, 259B3, 259D, 262C, 262C2, 262D, 267, 267B,...
414E, 416B, 416C, 416D, 416E, 420D, 420E, 422E, 424B, 424B HD, 424D, 426B, 426C, 428B, 428C, 428D, 430D, 430E, 436C, 438C
414E, 416, 416B, 416C, 416D, 416E, 420D, 422E, 424B, 424B HD, 424D, 426B, 426C, 428B, 428C, 428D, 430D, 436C, 438C, 446
414E, 416B, 416C, 416D, 416E, 416F, 420D, 420E, 420F, 422E, 422F, 424D, 426B, 426C, 428B, 428C, 428D, 428E, 428F, 430D, 430E, 430F, 432D, 432E, 432F, 434E, 434F, 436C, 438C, 438D, 442D, 442E, 444E, 44...
10 FT, 10B, 117, 118, 119, 128, 129, 140, 16, 172, 184, 235, 245, 245B, 24M, 2670C, 30, 303E CR, 305.5E, 308E, 308E CR, 3160, 35, 414E, 416C, 416E, 420D, 420E, 420F, 422E, 426C, 428C, 428E, 428F, 430E...
428, 428B
416C, 416F, 420D, 420E, 420F, 424D, 426C, 428C, 430D, 430E, 430F, 432D, 432E, 434E, 436C, 438C, 442D, 442E, 444E, 910K, 914G, 914K, 924G, 924GZ, 924H, 924HZ, 924K, 928HZ, 930G, 930K, IT14G, IT14G2, IT...
426B, 426C, 436B, 436C, 438B, 438C, 438D, 442D, M312, M313C, M315, M315C, M316C, M318, M318C
311, 311B, 311C, 311D LRR, 312B, 312C, 312C L, 312D, 312D L, 313D, 314C, 314D CR, 314D LCR, 315D L, 318C, 318D L, 319C, 319D, 319D L, 319D LN, 320 L, 320B, 320C, 320C FM, 320C L, 320D, 320D FM, 320D F...
303, 311, 311B, 311C, 311D LRR, 312, 312B, 312C, 312C L, 312D, 312D L, 313D, 314C, 314D CR, 314D LCR, 315D L, 318C, 318D L, 319C, 319D, 319D L, 319D LN, 320, 320 L, 320B, 320B FM LL, 320C, 320C FM, 32...
8T6904
PIN-CLEVIS
216, 228, 236, 246C, 247, 248, 256C, 262C, 262C2, 267, 272C, 277C, 277C2, 279C, 279C2, 287, 287C, 287C2, 289C, 289C2, 297C, 299C, 301.5, 416B, 416C, 416D, 420D, 424D, 426B, 426C, 428, 428B, 428C, 428D...
216, 228, 236, 246C, 247, 248, 256C, 262C, 262C2, 267, 272C, 277C, 277C2, 279C, 279C2, 287, 287C, 287C2, 289C, 289C2, 297C, 299C, 301.5, 416B, 416C, 416D, 420D, 424D, 426B, 426C, 428, 428B, 428C, 428D...
9R8094
PIN
216, 236, 416B, 416C, 426B, 426C, 428B, 428C, 436C, 438C, 446B
216, 236, 416B, 416C, 426B, 426C, 428B, 428C, 436C, 438C, 446B
216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3, 242D, 246C, 246D, 247, 247B, 247B3, 248, 252B, 252B3, 256C, 257B, 257B3, 257D, 259B3, 259D, 262C, 262C2, 262D, 267, 267B,...
216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3, 242D, 246C, 246D, 247, 247B, 247B3, 248, 252B, 252B3, 256C, 257B, 257B3, 257D, 259B3, 259D, 262C, 262C2, 262D, 267, 267B,...
216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3, 242D, 246C, 246D, 247, 247B, 247B3, 248, 252B, 252B3, 256C, 257B, 257B3, 257D, 259B3, 259D, 262C, 262C2, 262D, 267, 267B,...
120, 120B, 127, 12E, 140, 140B, 325B L, 325C, 330B L, 330C, 416, 416B, 416C, 416D, 420D, 424D, 426, 426B, 426C, 428, 428B, 428C, 428D, 430D, 432D, 436C, 438C, 438D, 442D, 446, 446B, 446D, 508, 517, 51...
416, 416B, 416C, 416D, 420D, 424D, 426, 426B, 426C, 428, 428B, 428C, 428D, 430D, 432D, 436C, 438C, 438D, 442D, CS-531C, CS-531D, CS-563C, CS-563D, CS-573C, CS-573D, CS-583, CS-583C, CS-583D, CS-663E, ...
416, 416B, 426, 426B, 428, 428B, 436B
416, 416B, 426, 426B, 428, 428B, 436B, 446B, 446D, M312, M313C, M313D, M315, M315C, M315D, M316C, M316D, M318, M318C, M318D
416, 416B, 426, 426B, 428, 428B, 436B, 446, 446B, 446D, AP-600D, AP-655D, AP555E, AS4251C, M312, M313C, M315, M315C, M316C, M318, M318C, M318C MH, M320, M322C
35, 414E, 416, 416B, 416C, 416D, 416E, 420D, 420E, 422E, 424D, 426, 426B, 426C, 428, 428B, 428C, 428D, 428E, 430D, 430E, 436B, 436C, 438B, 438C, 446, 446B, 446D, 45, 450E, 450F, 55, 621H, 623H, 627H, ...