1069421 PLUG-ORIFICE Caterpillar parts
416B, 416C, 426B, 426C, 428B, 428C, 436C, 438C, 725, 730, 928H, IT28G
Rating:
Alternative (cross code) number:
CA1069421
106-9421
1069421
CA1069421
106-9421
1069421
Weight: 0.01 pounds 0 kg.
ARTICULATED TRUCK, WHEEL LOADER,
Compatible equipment models: 1069421:
Number on catalog scheme:
27
For full view, you need register
Information:
Illustration 1 g01134038
Schematic of the Boom Drift Reduction SolenoidThis diagnostic code is associated with the Boom Drift Reduction Solenoid. The FMI 06 means that the ECM has determined that there is a short to ground in the circuit. The possible causes of this diagnostic code are listed:
The energize circuit of the solenoid is shorted to ground.
The solenoid has failed.
The ECM has failed. This is unlikely. Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 1119 FMI 06 is active before performing this procedure.Note: Use the 146-4080 Digital Multimeter for the measurements in this procedure.Test Step 1. CHECK THE SOLENOID.
Turn the disconnect switch and the key start switch to the ON position. Do not start the engine.
Observe the status of the diagnostic code.
Disconnect the solenoid with the active diagnostic code from the machine harness. Expected Result:CID 1119 FMI 06 changes to CID 1119 FMI 05 when the solenoid is disconnected.Results:
YES - CID 1119 FMI 06 changes to CID 1119 FMI 05 when the solenoid is disconnected. The circuit is correct.Repair: The solenoid has failed. Repeat this test "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid. Stop.
NO - CID 1119 FMI 06 remains active. Proceed to Test Step 2.Test Step 2. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT TO GROUND.
Turn the key start switch and the disconnect switch to the OFF position.
The solenoid remains disconnected from the machine harness.
Disconnect the machine harness connector(s) from the ECM.
At the machine harness connector, measure the resistance from the signal contact J2-54 (wire P946-BR) to all contacts that are used in the machine harness connectors for the ECM. Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness. The short is between J2-54 (wire P946-BR) and the circuit with the low resistance measurement.Repair: Repair the machine harness or replace the machine harness. Stop.Test Step 3. CHECK IF THE DIAGNOSTIC CODE REMAINS.
Inspect the harness connectors and clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Check the status of the CID 1119 FMI 06. Expected Result:The CID 1119 FMI 06 is active. Results:
YES - The CID 1119 FMI 06 is active. The diagnostic code has not been corrected. The ECM may have failed.Repair: It is unlikely that the ECM has failed. Exit this procedure and perform this procedure again. If the cause of the diagnostic code is not found, replace the ECM. See Testing and Adjusting, "Electronic Control Module (ECM) - Replace". Stop.
NO - The CID 1119 FMI 06 is not active. The diagnostic code does not exist at this time.
Cat SIS web machinery list:
Parts plug Caterpillar catalog:
120H, 120H ES, 120H NA, 135H, 135H NA, 14M, 16M, 3126B, 3126E, 325C, 329D L, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L, 349E L HVG, 349E L VG, 349F L, 365C, 365C L, 36...
120H, 120K, 120K 2, 120M, 120M 2, 12H, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 140H, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H, 14M, 160H, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H...
120M, 120M 2, 12M, 12M 2, 12M 3, 12M 3 AWD, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 2470C, 2570C, 2670C, 2864C, 508, 515, 517, 518, 518C, 525, 525B, 528, 528B, 53...
120M, 120M 2, 12M, 2384C, 2470C, 2484C, 2570C, 2670C, 3054C, 3054E, 312D2, 312D2 GC, 312D2 L, 312E, 312E L, 313D2, 313D2 LGP, 314E CR, 314E LCR, 316E L, 318D2 L, 318E L, 320D GC, 320D L, 320D2, 320D2 ...
1090, 1190, 1190T, 120K, 120K 2, 120M, 120M 2, 1290T, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 1390, 140G, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 2...
12M 2, 140M, 160M, 216B, 216B3, 226B, 226B3, 232B, 236B, 236B3, 242B, 242B3, 247B, 247B3, 252B, 252B3, 257B, 257B3, 259B3, 267B, 268B, 301.6C, 3116, 312C, 312C L, 315B L, 315C, 317B LN, 318B, 320 L, 3...
120, 120G, 12E, 12F, 12G, 140, 140G, 14E, 14G, 153, 16, 163, 16G, 235, 235C, 245, 245B, 245D, 311C, 311D LRR, 312C, 312C L, 312D, 312D L, 313D, 314C, 314D CR, 314D LCR, 315C, 315D L, 318C, 318D L, 319...
225, 24H, 30/30, 330C, 330D L, 330D MH, 3406, 3406B, 3406C, 3406E, 3408E, 3412E, 345B II, 345B II MH, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L, 349E L HVG, 349E L VG,...
117, 118, 119, 120G, 127, 128, 129, 12E, 12G, 130G, 140G, 14G, 14H, 14H NA, 16, 160G, 16G, 16H, 16H NA, 215, 215B, 215C, 225, 227, 229, 229D, 231D, 235, 235B, 235C, 245, 25, 30, 3192, 330 L, 330B, 340...
527, 621F, 621G, 623E, 623F, 623G, 627F, 627G, 631E, 631G, 633E II, 637E, 637G, 725, 725C, 730, 735, 784B, 784C, 785, 785B, 785C, 785D, 789, 789B, 789C, 789D, 793, 793B, 793C, 795F AC, 795F XQ, 797, 7...
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 14H, 14H NA, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 16H, 16H NA, 215, 2...
311C, 311D LRR, 311F LRR, 312C, 312C L, 312D, 312D L, 312D2, 312D2 GC, 312D2 L, 312E, 312E L, 313D, 313D2, 313D2 LGP, 314C, 314D CR, 314D LCR, 314E CR, 314E LCR, 315C, 315D L, 316E L, 318B, 318C, 318D...
1090, 1190, 1190T, 120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 1290T, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 1390, 140G, 140H, 140H ES, 140H NA...
1069485
PLUG-ORIFICE
416B, 416C, 426B, 426C, 428B, 428C, 436C, 438C
416B, 416C, 426B, 426C, 428B, 428C, 436C, 438C
416B, 426, 426B, 428, RT50
416B, 426, 426B, 428, RT50
416B, 426, 426B, 428, PP120, RT50, SAT223, SAT22DB, SAT318, SAT318T, SAT322, SAT420, SAT630
4T4531
PLUG
30/30, 416B, 416C, 416D, 420D, 424D, 426B, 426C, 428, 428B, 428C, 428D, 430D, 432D, 436C, 438C, 438D, 442D, 446, 446B, 446D, 508, 515, 517, 525, 525B, 525C, 527, 535B, 535C, 545, 545C, D4H, D4H XL, D4...
30/30, 416B, 416C, 416D, 420D, 424D, 426B, 426C, 428, 428B, 428C, 428D, 430D, 432D, 436C, 438C, 438D, 442D, 446, 446B, 446D, 508, 515, 517, 525, 525B, 525C, 527, 535B, 535C, 545, 545C, D4H, D4H XL, D4...
120H, 120M, 12H, 12M, 135H, 140H, 140M, 143H, 14H, 14M, 160H, 160M, 163H, 16H, 35, 416B, 416C, 426B, 426C, 428B, 428C, 436C, 438B, 438C, 45, 5110B, 55, 621G, 623G, 627G, 631E, 631G, 637E, 637G, 651E, ...
120H, 120M, 12H, 12M, 135H, 140H, 140M, 143H, 14H, 14M, 160H, 160M, 163H, 16H, 35, 416B, 416C, 426B, 426C, 428B, 428C, 436C, 438B, 438C, 45, 5110B, 55, 621G, 623G, 627G, 631E, 631G, 637E, 637G, 651E, ...
6E3277
PLUG-ORIFICE
416B, 426B, 438B
416B, 426B, 438B
120H, 120M, 12H, 12M, 135H, 140H, 140M, 140M 2, 143H, 14H, 14M, 160H, 160M, 160M 2, 163H, 16H, 2470C, 2570C, 2670C, 35, 416B, 416C, 416D, 420D, 420F, 424D, 426B, 426C, 428B, 428C, 428D, 430D, 430F, 43...
143H, 163H, 163H NA, 3406, 3406B, 350, 365B, 365B II, 365B L, 365C, 365C L, 365C L MH, 374D L, 375, 375 L, 385B, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L, 416B, 416C, 416D, 420D, 424D, 426B, 426...
120G, 120M 2, 12G, 12M 2, 12M 3 AWD, 130G, 140G, 140M 2, 140M 3 AWD, 160G, 160M 2, 160M 3 AWD, 16G, 16H NA, 183B, 193, 216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3, 24...