2345283 PLUG AS-CONNECTOR Caterpillar parts
AD30, AD55, R1600, R1600G, R1700G, R2900G
Rating:
Alternative (cross code) number:
CA2345283
234-5283
2345283
CA2345283
234-5283
2345283
Weight: 0.20 pounds 0 kg.
LOAD HAUL DUMP, UNDERGROUND ART TRUCK,
Compatible equipment models: 2345283:
Information:
Illustration 1 g01228667
VPAT blade angle right solenoid connections
Illustration 2 g01228557
VPAT angle pilot manifold located on the right hand fender in front of the hydraulic oil tank (1) Angle right solenoid valve (2) Angle left solenoid valveThis diagnostic code is associated with the VPAT blade angle right solenoid. The FMI 06 means that the ECM has determined that the current for the solenoid circuit is above normal.The possible causes of this diagnostic code are listed:
The energize circuit of the solenoid is shorted to ground.
The solenoid has failed.
The ECM has failed. This is unlikely.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 1934 FMI 06 is active before performing this procedure.System Response:When this code is active, the angle function that the solenoid controls will not operate.Test Step 1. CHECK THE SOLENOID
Turn the disconnect switch and the key start switch to the ON position. DO NOT start the engine.
Observe the status of the diagnostic code.
Disconnect the solenoid with the active diagnostic code from the machine harness.Expected Result:The CID 1934 FMI 06 code changes to CID 1934 FMI 05 code when the solenoid is disconnected. Results:
YES - The 1934 FMI 06 code changes to CID 1934 FMI 05 code when the solenoid is disconnected. The circuit is correct. Repair: The solenoid has failed. Repeat this test "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid.STOP
NO - The CID 1934 FMI 06 code remains active. Disconnecting the solenoid did not affect the status of the active diagnostic code. Proceed to Test Step 2.Test Step 2. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT TO GROUND
Turn the key start switch and the disconnect switch to the OFF position.
The solenoid remains disconnected from the machine harness.
Disconnect the machine harness connectors from the ECM.
At the machine harness connector, measure the resistance from the signal contact J1-59 (wire F789-YL) to frame ground. Measure the resistance from the signal contact J1-59 (wire F789-YL) to all of the J1 and J2 contacts that are used in the machine harness connectors for the ECM.Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness. The short is between wire F789-YL and the circuit with the low resistance measurement.Repair: Refer to the complete machine Electrical System Schematic. Examine all of the connectors in the circuits for points in the machine harness where the circuits could be shorted. For information on testing for short circuits and finding short circuits, refer to Testing and Adjusting, "Wiring Harness (Short Circuit) - Test". Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK THE STATUS OF THE DIAGNOSTIC CODE
Inspect the harness connectors and clean the contacts of
Caterpillar parts catalog:
Parts plug Caterpillar catalog:
7H3171
PLUG-PIPE
1090, 1140, 1160, 1190, 1190T, 120B, 120G, 120M, 120M 2, 1290T, 12E, 12G, 12H, 12H ES, 12H NA, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 1390, 140B, 140G, 140H, 140H ES, 140H NA, 140M, 140M 2, 140M 3, 140M ...
1090, 1140, 1160, 1190, 1190T, 120B, 120G, 120M, 120M 2, 1290T, 12E, 12G, 12H, 12H ES, 12H NA, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 1390, 140B, 140G, 140H, 140H ES, 140H NA, 140M, 140M 2, 140M 3, 140M ...
3D4603
PLUG-PIPE
118, 119, 127, 128, 12E, 16, 1674, 1676, 1693, 235, 304, 304.5, 305, 305.5, 305.5E, 306, 306E, 307, 307B, 307C, 307D, 307E, 308C, 308D, 308E, 308E2 CR, 311C, 311D LRR, 311F LRR, 312C, 312C L, 312D, 31...
118, 119, 127, 128, 12E, 16, 1674, 1676, 1693, 235, 304, 304.5, 305, 305.5, 305.5E, 306, 306E, 307, 307B, 307C, 307D, 307E, 308C, 308D, 308E, 308E2 CR, 311C, 311D LRR, 311F LRR, 312C, 312C L, 312D, 31...
5P7684
PLUG
225, 24H, 30/30, 330C, 330D L, 330D MH, 3406, 3406B, 3406C, 3406E, 3408E, 3412E, 345B II, 345B II MH, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L, 349E L HVG, 349E L VG,...
225, 24H, 30/30, 330C, 330D L, 330D MH, 3406, 3406B, 3406C, 3406E, 3408E, 3412E, 345B II, 345B II MH, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L, 349E L HVG, 349E L VG,...
9S8927
PLUG
10 FT, 215, 225, 245, 245B, 3126B, 8 FT, 950, C7, R1300G, R1600, R1600G
10 FT, 215, 225, 245, 245B, 3126B, 8 FT, 950, C7, R1300G, R1600, R1600G
9S4205
PLUG
3508C, 3512B, 3512C, 3516B, 3516C, 517, 518C, 527, 528, 528B, 530B, 561C, 561M, 578, 583R, 589, 621, 621B, 621E, 621F, 621G, 623E, 623F, 623G, 627B, 627E, 627F, 627G, 627H, 627K, 627K LRC, 631C, 631E,...
3508C, 3512B, 3512C, 3516B, 3516C, 517, 518C, 527, 528, 528B, 530B, 561C, 561M, 578, 583R, 589, 621, 621B, 621E, 621F, 621G, 623E, 623F, 623G, 627B, 627E, 627F, 627G, 627H, 627K, 627K LRC, 631C, 631E,...
3P7009
PLUG-CUP
120G, 12G, 130G, 140G, 14G, 14H, 14H NA, 160G, 16G, 16H, 16H NA, 30/30, 375, 5080, 611, 615, 615C, 814B, 814F, 814F II, 815B, 815F, 815F II, 816F, 816F II, 936, 936F, 950B, 950B/950E, 950F, 966C, 966D...
120G, 12G, 130G, 140G, 14G, 14H, 14H NA, 160G, 16G, 16H, 16H NA, 30/30, 375, 5080, 611, 615, 615C, 814B, 814F, 814F II, 815B, 815F, 815F II, 816F, 816F II, 936, 936F, 950B, 950B/950E, 950F, 966C, 966D...
2385507
PLUG AS
30/30, 611, 613C, 613C II, 613G, 615C, 814F, 815F, 824G, 825G, 826G, 950F II, 960F, 966F II, 970F, 980G, 980G II, AD30, D250E, D250E II, D300E, D300E II, DEUCE, R1300, R1300G, R1600, R1600G, R1600H, R...
30/30, 611, 613C, 613C II, 613G, 615C, 814F, 815F, 824G, 825G, 826G, 950F II, 960F, 966F II, 970F, 980G, 980G II, AD30, D250E, D250E II, D300E, D300E II, DEUCE, R1300, R1300G, R1600, R1600G, R1600H, R...
9G7132
PLUG-ORIFICE
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 621E, 621F, 621G, 623E, 623F, 62...
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 621E, 621F, 621G, 623E, 623F, 62...
8M3837
PLUG
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 14H, 14H NA, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 16H, 16H NA, 215, 2...
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 14H, 14H NA, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 16H, 16H NA, 215, 2...
0961628
PLUG
2384C, 2484C, 303, 303.5C, 303.5D, 303.5E, 303C CR, 303E CR, 304, 304C CR, 304D CR, 304E, 305, 305.5, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 306, 306E, 307, 307B, 307C, 307D, 307E, 308C, 308D, 308E, ...
2384C, 2484C, 303, 303.5C, 303.5D, 303.5E, 303C CR, 303E CR, 304, 304C CR, 304D CR, 304E, 305, 305.5, 305.5D, 305.5E, 305C CR, 305D CR, 305E, 306, 306E, 307, 307B, 307C, 307D, 307E, 308C, 308D, 308E, ...
2385508
PLUG AS-ORIFICE
24H, 517, 527, 561M, 578, 583R, 587R, 589, 844, 844H, 844K, 854G, 854K, 988F, 988F II, 990, 990 II, 990H, 990K, 992C, 992D, 992G, 992K, 993K, 994, 994D, 994F, 994H, D10R, D11R, D11T, D4H XL, D4HTSK II...
24H, 517, 527, 561M, 578, 583R, 587R, 589, 844, 844H, 844K, 854G, 854K, 988F, 988F II, 990, 990 II, 990H, 990K, 992C, 992D, 992G, 992K, 993K, 994, 994D, 994F, 994H, D10R, D11R, D11T, D4H XL, D4HTSK II...
9G7516
PLUG
578, 589, 797, 797B, 797F, 994, 994D, 994F, 994H, D10, D10N, D10R, D10T, D10T2, D11N, D11R, D11T, D8L, D8N, D8R, D8R II, D8T, D9L, D9N, D9R, D9T, R1300, R1300G, R1300G II, R1600, R1600G, R1600H, R1700...
578, 589, 797, 797B, 797F, 994, 994D, 994F, 994H, D10, D10N, D10R, D10T, D10T2, D11N, D11R, D11T, D8L, D8N, D8R, D8R II, D8T, D9L, D9N, D9R, D9T, R1300, R1300G, R1300G II, R1600, R1600G, R1600H, R1700...
2228762
PLUG AS-CONNECTOR
AD55, R1600, R1600G, R1700G, R2900G
AD55, R1600, R1600G, R1700G, R2900G
2381357
PLUG
R1600G, R1700G
R1600G, R1700G
2225531
PLUG AS
R1600, R1600G, R1700 II
R1600, R1600G, R1700 II
2878921
PLUG AS-CONNECTOR
R1600G, R1600H
R1600G, R1600H
3788431
PLUG
770G, 770G OEM, 772G, 772G OEM
770G, 770G OEM, 772G, 772G OEM
3186528
PLUG
770G, 772G, CP-44, CP-56, CP-64, CP-76, CS-44, CS-54, CS-56, CS-64, CS-74
770G, 772G, CP-44, CP-56, CP-64, CP-76, CS-44, CS-54, CS-56, CS-64, CS-74
3772189
PLUG-ORIFICE
793F CMD
793F CMD
3717219
PLUG
793F CMD
793F CMD
3586551
PLUG AS-CONNECTOR
793F CMD
793F CMD
3587031
PLUG-ORIFICE
735B, 740B
735B, 740B
3670794
PLUG
324D FM, 324D FM LL, 325D FM, 330D FM, 568 FM LL, 725C, 730C, 735B, 740B
324D FM, 324D FM LL, 325D FM, 330D FM, 568 FM LL, 725C, 730C, 735B, 740B
3511370
PLUG AS-CODE
R1600G
R1600G