PUMP 8W6425 - Caterpillar

To record programmed specifications, use the following blanks.Customer Passwords (Optional)
First Password ____________________
Second Password ____________________Programmable Power Rating (hp at rpm) ____________________Rating Selection (L-N) ____________________Air/Fuel Ratio
Level 1: Minimal Smoke ____________________
Level 2: Optimum Performance ____________________
Level 3: Maximum Acceleration ____________________PTO Engine Governor
PTO Engine Speed Ramp Rate ____________________ rpm/secEngine Parameters( If applicable)
Top Engine Limit (TEL) at 100 percent load____________________
Torque Limit ____________________
High Idle____________________
Low Idle ____________________
Intermediate Speed ____________________Engine Monitoring ModeEquipment IDMaintenance Indicator
Manual Hours
Auto Hours
Manual Fuel
Auto FuelAuxiliary Pressure
High Warning Set Point ____________________Auxiliary Temperature
High Warning Set Point ____________________Programmable Monitoring System (PMS)
The Programmable Monitoring System determines the level of action that is taken by the ECM in response to a condition that can damage the engine. These conditions are identified by the ECM from the signals that are produced from the following sensors
Inlet Air Temperature Sensor
Engine Coolant Temperature Sensor
Engine Oil Pressure Sensor
Engine Speed/Timing Sensors
Fuel Pressure Sensor
Coolant Level Sensor
Table 1
Programmable Monitoring System Parameters
Parameter Default Value Action Time Delay in Seconds Set Points "Disable"
Min Max Default Min Max Default
"High Engine Air Inlet Temperature" ON Warning YES
ON Derate YES
"High Engine Coolant Temperature" ON Warning YES
ON Derate YES
OFF Shutdown YES
"Low Engine Oil Pressure" ON Warning (1) (1) (1) YES
ON Derate (1) (1) (1) YES
OFF Shutdown (1) (1) (1) YES
"Engine Overspeed"(2) ON Warning YES
ON Shutdown YES
"High Fuel Filter Pressure Restriction" ON Warning (1) (1) (1) YES
OFF Derate (1) (1) (1) YES
OFF Shutdown (1) (1) (1) YES
"High Fuel Pressure" ON Warning (1) (1) (1) YES
"Low Coolant Level" ON