3454153 RAIL GP-FUEL Caterpillar parts
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 416F, 420F, 428F, 430F, 432F, 434F, 444F, 450F, C4.4, C4.4XQ100, C4.4XQ80, CB-44B, CB-54B, CP-54B, CP-68B, CP-74B, CS-54B, CS-56B, CS-64B, CS-66B, CS-7...
Rating:
Alternative (cross code) number:
CA3454153
345-4153
3454153
CA3454153
345-4153
3454153
Weight: 4 pounds 1 kg.
BACKHOE LOADER, VIBRATORY COMPACTOR,
Number on catalog scheme:
3
For full view, you need register
Information:
Illustration 1 g01457705
Schematic for 5 Volt DC Power Supply of the VIMS ECMThe 5 volt power supply provides power for the pump pressure sensor of the engine fan.The CID 0262 FMI 04 diagnostic code is recorded when the voltage of the sensor supply circuit is below normal.The following conditions could cause this diagnostic code:
A sensor has failed.
The sensor supply circuit is shorted to a ground source.
The ECM has failed. This is unlikely.Test Step 1. CHECK THE SENSOR
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the pump pressure sensor of the engine fan from the machine harness.
After disconnecting the sensor, check the status of the CID 262 FMI 04 code.Expected Result:The CID 262 FMI 04 diagnostic code is no longer active.Results:
OK - The diagnostic code is not active. The harness circuit is correct. The sensor that was just disconnected has failed.Repair: Replace the sensor.STOP
NOT OK - The diagnostic code is still active. The machine harness may be shorted to ground. Proceed to Test Step 2.Test Step 2. CHECK FOR A SHORT TO GROUND
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness connectors J1 and J2 from the ECM.
At the harness connector for the ECM, measure the resistance between frame ground and contact J2-63 (wire 997-OR). Measure the resistance between contact J2-63 and all of the other contacts that are used in the J1 and J2 connectors for the ECM. Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The harness circuit resistance is correct. Proceed to Test Step 3.
NOT OK - The resistance is less than 5000 ohms. The machine harness has failed.Repair: The 997-OR wire is shorted to ground in the machine harness. Refer to the complete Electrical System Schematic for your machine. Check all harness connectors that are in the power supply circuit. Ensure that the connectors are clean and secure. Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK THE STATUS OF THE DIAGNOSTIC CODE
Inspect the harness connectors and clean the contacts of the harness connectors. Check the wires for damage to the insulation that is caused by excessive heat, battery acid, or chafing.
Perform a 45 N (10 lb) pull test on each of the wires that are associated with the sensor circuit.
Reconnect all harness connectors. Make sure that the connectors are fully seated. Make sure that the clips for each connector are completely fastened.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Determine if the CID 0262 FMI 04 diagnostic code is active.Expected Result:The CID 0262 FMI 04 diagnostic code is active.Results:
YES - The CID 0262 FMI 04 diagnostic code is active. The problem has not been corrected. Repair: Check the circuit again. The Caterpillar Electronic Technician (ET) (service tool) may be used in order to perform a "Wiggle Test" on the machine wiring harness. The "Wiggle Test" can detect intermittent shorts or intermittent opens in the
Cat SIS web machinery list:
Parts rail Caterpillar catalog:
3902615
RAIL GP-FUEL
3.4B IOPU, 311F LRR, C3.4B, CB-44B, CB-54B, CD-54B, CW-14
3.4B IOPU, 311F LRR, C3.4B, CB-44B, CB-54B, CD-54B, CW-14
3531909
RAIL AS
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
3531916
RAIL
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
3531917
RAIL
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
3531942
RAIL
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
3531943
RAIL
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
308D, 308E CR, 308E SR, 314D CR, 314D LCR, 314E CR, 314E LCR, 321D LCR
3573898
RAIL AS
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 324E L, ...
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 324E L, ...
3573899
RAIL AS
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 324E L, ...
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 324E L, ...
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 349E L HVG...
3504607
RAIL AS
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 349E L HVG...
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 349E, 349E L, 349E L HVG...
3595488
RAIL
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
3566450
RAIL
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
3116631
RAIL AS-FUEL
420E, 430E, C4.4, CB-54B, CS-54B, CW-34, D3K XL, D4K XL, D5K LGP, M313D, M315D, M315D 2
420E, 430E, C4.4, CB-54B, CS-54B, CW-34, D3K XL, D4K XL, D5K LGP, M313D, M315D, M315D 2
3586632
RAIL GP-FUEL
420E, 430E, 450E, 914G, AP555E, BG500E, C4.4, CB-54, CB-54B, CB-64, CP-44, CS-44, CS-54, CS-54B, CW-34, D3K XL, D4K XL, D5K LGP, IT14G, IT14G2, M313D, M315D, M317D 2
420E, 430E, 450E, 914G, AP555E, BG500E, C4.4, CB-54, CB-54B, CB-64, CP-44, CS-44, CS-54, CS-54B, CW-34, D3K XL, D4K XL, D5K LGP, IT14G, IT14G2, M313D, M315D, M317D 2
3182394
RAIL AS-FUEL
420E, 430E, 450E, 914G, AP555E, BG500E, C4.4, CB-54, CB-64, CP-44, CS-44, CS-54, CS-54B, D3K XL, D4K XL, D5K LGP, IT14G, M313D, M315D
420E, 430E, 450E, 914G, AP555E, BG500E, C4.4, CB-54, CB-64, CP-44, CS-44, CS-54, CS-54B, D3K XL, D4K XL, D5K LGP, IT14G, M313D, M315D
2584179
RAIL-MOUNTING
246C, 256C, 262C, 262C2, 272C, 277C, 277C2, 279C, 279C2, 287C, 287C2, 289C, 289C2, 297C, 299C
246C, 256C, 262C, 262C2, 272C, 277C, 277C2, 279C, 279C2, 287C, 287C2, 289C, 289C2, 297C, 299C
2064404
RAIL
TH220B, TH330B
TH220B, TH330B
2162268
RAIL
TH220B, TH330B, TH340B, TH350B, TH355B
TH220B, TH330B, TH340B, TH350B, TH355B
1274641
RAIL
3508, 3508B, 3512, 3512B, 3516, 3516B
3508, 3508B, 3512, 3512B, 3516, 3516B
1918396
RAIL
3512, 3512B, 3516
3512, 3512B, 3516
0975921
RAIL-MOUNTING
3208, 320C FM, 325B L, 325C, 325C L, 325D MH, 3304, 3306B, 330B L, 330C L, 330C MH, 330D MH, 3406C, 3408, 3412, 3412C, 3456, 345B, 345B II, 345B II MH, 345C, 345C MH, 3508, 3508B, 3508C, 3512, 3512B, ...
3208, 320C FM, 325B L, 325C, 325C L, 325D MH, 3304, 3306B, 330B L, 330C L, 330C MH, 330D MH, 3406C, 3408, 3412, 3412C, 3456, 345B, 345B II, 345B II MH, 345C, 345C MH, 3508, 3508B, 3508C, 3512, 3512B, ...
236D, 242D, 246D, 257D, 259D, 262D, 277D, 279D, 287D, 289D, 308E2 CR