RETAINER 2919312 - Caterpillar

Illustration 1 g01342887
Typical example
Engine Lifting (1)
Illustration 2 g01061192The safety message for lifting the engine is located on the front valve covers.
Improper lift rigging can allow unit to tumble causing injury and damage.
Before lifting the engine, read this Operation and Maintenance Manual, "Product Lifting" topic (Operation Section).If improper equipment is used to lift the engine, injury and damage can occur. Use cables that are properly rated for the weight. Use a spreader bar and attach the cables according to the information on the safety messages.Electrical Shock (2)
Illustration 3 g00305892The safety message for electrical shock is located on the front and rear valve covers. A safety message for electrical shock is also located on the Electronic Control Module (ECM).
Electrical shock hazard. The electronic unit injector system uses 90-120 volts.
The ECM sends a high voltage signal to the fuel injectors. To help prevent personal injury, disconnect the fuel injector connector. Do not come in contact with the harness connector for the fuel injector while the engine is operating.Flash Fire (3)
Illustration 4 g01061123The safety message for flash fire is located on the rear crankcase covers.
Flash fire may result in personal injury, if crankcase covers are removed within fifteen minutes after emergency shut down. Do not restart engine until cause for shutdown has been corrected.
Type 2 (If Equipped)
The safety messages that may be attached on the engine are illustrated and described below.
Illustration 5 g01342921
Typical example
Illustration 6 g01342927
Typical example
Universal Warning (1)
Illustration 7 g01105289This safety message is located on the first cylinder and the last cylinder on each side of 8, 12, and 16 cylinder engines.
Do not operate or work on this equipment unless you have read and understand the instructions and warnings in the Operation and Maintenance Manuals. Failure to follow the instructions or heed the warnings could result in serious injury or death.
Hot Surface (2)
Illustration 8 g01085603On 8 cylinder engines, the safety message is located on the valve covers of cylinder 5 and cylinder 6. On 12 cylinder engines, the safety message is located on the valve covers of cylinder 9 and cylinder 10. On 16 cylinder engines, the safety message is located on the valve covers of cylinder 13 and cylinder 14 .
Hot parts or hot components can cause burns or personal injury. Do not allow hot parts or components to contact your skin. Use protective clothing or protective equipment to protect your skin.