2459221 SEAL Caterpillar parts
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
Rating:
Alternative (cross code) number:
CA2459221
245-9221
2459221
CA2459221
245-9221
2459221
Weight: 0.15 pounds 0 kg.
EXCAVATOR, MOBILE HYD POWER UNIT,
Compatible equipment models: 2459221:
Number on catalog scheme:
16
For full view, you need register
Information:
Table 1
Diagnostic Codes
Code Description Conditions Notes
3509-3 Sensor supply voltage 1: High Battery voltage is normal.
Key switch is ON
Starter switch signal is not activated (P1/J1 Terminal 12)
3509-3: Sensor voltage is 5.625 V or higher.
3509-4: Sensor voltage is 4.375 V or lower
Engine derated.
Rail pressure limited to 80 MPa (12000 psi)
Warning Level 2.
Other Symptoms: Faulty starting, increased engine noise.
3509-4 Sensor supply voltage 1: Low
3510-3 Sensor supply voltage 2: High 3510-3: Sensor voltage is 5.625 V or higher.
3510-4: Sensor voltage is 4.375 V or lower.
Engine derated.
Rail pressure limited to 80 MPa (12000 psi)
EGR stops
Warning Level 2
Other Symptoms: Faulty starting, increased engine noise
3510-4 Sensor supply voltage 2: Low Note: A -3 code is detecting an open circuit or +B short circuit of the sensor or the wiring harness.Note: A -4 code is detecting a ground short circuit of the sensor or the wiring harness.Note: Diagnostic codes for a short circuit or and open circuitSensor Supply 2 supplies 5 v to the Ambient Air Pressure Sensor (Boost Pressure). Sensor Supply 1 supplies 5 v to the Common Rail Pressure Sensor, Crankshaft Position Sensor.
Illustration 1 g06132222
Turn the keyswitch to ON.
Measure the voltage between ECM terminals. Do not remove the ECM connectors.For code 3509, measure voltage between P1/J1 Terminal 40 (ground) / 60 (ground) and P2/J2 Terminal 68 (5V).For code 3510 measure between P1/J1 Terminal 40 (ground) / 60 (ground) and lP2/J2 Terminal 48 (5V).The voltage should be approximately 5 V. If it is approximately 5V, then go to Step 3.If it is not approximately 5 V, contact your dealer Technical Communicator (TC) before replacing the engine ECM.
Measure the voltage at the sensor connector between 5V and ground.If good, then replace the sensor.If not good, then the fault is in the wiring harness or connectors. Refer to Special Instruction, REHS7774 for jumper harnesses available for the engine connector. Refer to Special Instruction, REHS7297 for engine ECM connector repair options. If the problem remains, check the ECM.
Cat SIS web machinery list:
Parts seal Caterpillar catalog:
1390, 2590, 320D, 320D FM, 320D2, 320D2 L, 324D, 324D L, 324D LN, 325C, 325D, 325D L, 329D L, 329D LN, 329E, 521B, 522B, 541, 541 2, 551, 552, 552 2
320D, 320D L, 320D2, 320D2 L, 320E, 320E L, 320E LN, 325D, 325D L, 328D LCR, 329D, 329D L, 329E, 329E L, 329E LN
324D, 325C, 325D L, 328D LCR, 330C, 330C FM, 330C L, 330D, 330D FM, 330D L, 330D LN, 336D, 336D L, 340D L, 345C, 345C L, 345C MH, 385C L, W345C MH
324D, 329D LN, 330D, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E L, 336E LN, 336F L, 340D L, 340D2 L, 345B II, 345C, 345C L, 345D, 345D L, 345D L VG, 349D, 349D L, 349E...
324D, 329D LN, 330D, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E L, 336E LN, 336F L, 340D L, 340D2 L, 345B II, 345C, 345C L, 345D, 345D L, 345D L VG, 349D, 349D L, 349E...
324D, 325C, 325D L, 328D LCR, 330C, 330C FM, 330C L, 330D, 330D FM, 330D L, 330D LN, 336D, 336D L, 340D L, 385C L
324D, 329D LN, 330D, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E L, 336E LN, 336F L, 340D L, 340D2 L, 345C, 345C L, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L,...
325B, 325C, 325C L, 325D, 325D L, 328D LCR, 329D, 329D L
325B, 325C, 325C L, 325D, 325D L, 328D LCR, 329D, 329D L
328D LCR, 330C L, 330D, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L, 340D L, 340D2 L, 345C MH, 345D L, 349D L, 349E, 349E ...
325C, 325C L, 325D, 325D L, 328D LCR, 329D, 329D L
328D LCR, 345B II, 345B L, 345C, 345C L, 345D L, 349E L, 349E L VG, 349F L, 350, 365B, 365B II, 365B L, E650
2459215
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2459214
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2459213
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2653560
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2302882
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2302881
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, M325D L MH, M325D MH
2778433
SEAL-WASHER
1090, 1190, 1190T, 1290T, 1390, 2290, 2390, 2391, 2491, 2590, 320D, 320D FM, 322C FM, 324D FM, 324D FM LL, 325C FM, 325D FM, 330C FM, 330D FM, 511, 521, 522, 532, 541, 551, 552, TK711, TK721, TK722, T...
1090, 1190, 1190T, 1290T, 1390, 2290, 2390, 2391, 2491, 2590, 320D, 320D FM, 322C FM, 324D FM, 324D FM LL, 325C FM, 325D FM, 330C FM, 330D FM, 511, 521, 522, 532, 541, 551, 552, TK711, TK721, TK722, T...
1090, 1190, 1190T, 1290T, 1390, 2290, 2390, 2391, 2491, 2590, 320D, 320D FM, 324D FM, 511, 521, 521B, 522, 522B, 532, 541, 541 2, 551, 552, 552 2, OEMS, TK1051, TK711, TK721, TK722, TK732, TK741, TK75...
320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 322C, 323D L, 323D LN...
2697103
SEAL AS
1190, 1190T, 1390, 2390, 2391, 324D FM, 325D FM, 325D FM LL, 521, 522, 541, TK721, TK722, TK741
1190, 1190T, 1390, 2390, 2391, 324D FM, 325D FM, 325D FM LL, 521, 522, 541, TK721, TK722, TK741
320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 321C, 321D LCR, 323D L, 323D LN, 323D SA, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH...
2459222
SEAL
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH
324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325D, 325D FM, 325D FM LL, 325D L, 325D MH, 328D LCR, 329D, 329D L, 329D LN, M325D L MH, M325D MH