6N5468 ALTERNATOR GROUP--24 Volt, 19 Ampere Serial No. 82J4379-Up 2P1204 Alternator parts are shown on Page 83 Note: 2P2696 VEE Belt Set, includes 2 belts, is used D4D

6N5468 ALTERNATOR GROUP--24 Volt, 19 Ampere
Serial No. 82J4379-Up
2P1204 Alternator parts are shown on Page 83
Note: 2P2696 VEE Belt Set, includes 2 belts, is used

c167177 SEBP1043

6N5468 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	2P-1204 Y	[1]	ALTERNATOR ASSEM.
			(Separate Illustration)
2.	7S-6723	[1]	BRACKET
3.	1D-4574	[1]	BOLT 15.24 cm(6 in.)long
4.	9S-4146	[1]	WIRE ASSEM.
			(Includes)
	5P-5622 D		WIRE .16 m(6.5 in.)
	2L-8069	[1]	TERMINAL (large)
	2L-8066	[1]	TERMINAL (small)
5.	2D-2285 C	[1]	BOLT
6.	7F-1866 C	[1]	BOLT
7.	9S-1240	[1]	NUT ASSEM.
			(Includes)
	1F-0748	[1]	NUT
8.	8M-4791	[1]	WASHER
9.	0S-1585	[2]	BOLT
10.	8M-4791	[2]	WASHER
11.	8S-4183	[1]	STRAP
12.	2S-6735	[1]	SPACER
13.	9S-6129	[1]	PULLEY
	C		INDICATES CHANGE
	Y		SEPARATE ILLUSTRATION
	D		ORDER BY THE METER

#SEBP10430161

2P-1204: ALTERNATOR GP

ALTERNATOR GP

2P1204 ALTERNATOR GROUP--24 Volt, 19 Ampere
Part of 2P7836 and 6N5468 Alternator Groups shown on Page 82

c207038 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	031-0243	[3]	SCREW
2.	6N-3821 CS	[1]	REGULATOR ASSEM.
	3K-6234	[1]	SCREW
	4B-4863	[1]	WASHER
3.	009-8708	[2]	BOOT
4.	2L-8076	[1]	TERMINAL
5.	2L-8077	[1]	TERMINAL
6.	1P-1091 T		KIT-(Reg. Mounting Plate and Gasket)
7.	1P-1145	[1]	HOLDER ASSEM.
	1P-1137	[2]	HOLDER
8.	4B-2049	[4]	NUT
	3B-4502	[4]	LOCKWASHER
9.	1P-1138	[1]	FIELD TERMINAL AND PLATE ASSEM.
10.	5S-4245	[2]	SCREW
	6B-4542	[2]	LOCKWASHER
11.	4B-4274	[1]	WASHER
12.	1P-1130 T	[1]	KIT (2 Brushes)
13.	032-4000	[4]	SCREW
14.	2P-1714 T	[1]	KIT (4 Gaskets)
15.	1P-1080 T	[1]	KIT (Retainer and Seals)
16.	6N-6717 CT	[1]	KIT (insulator)
			(Terminal Stud)
17.	2P-1709	[1]	RECTIFIER AND STATOR ASSEM.
18.	2P-1719	[1]	PLATE AND RECTIFIER ASSEM.
			(Positive)
	2P-1720	[1]	PLATE AND RECTIFIER ASSEM.
			(Negative)
19.	6N-1226 C	[1]	ROTOR ASSEM.
20.	1B-8705	[1]	KEY
21.	3B-4502	[10]	LOCKWASHER
22.	6N-5255 C	[1]	HEAD ASSEM.
23.	6D-9953	[2]	PIN
24.	1B-5387 C	[1]	BEARING
25.	2P-1713 T	[1]	KIT (Retainer and Seal)
			(Retainer, Seal, Spacer, Washer)
26.	017-2311	[3]	SCREW
27.	9M-5520	[1]	SCREW
28.	3B-4511	[1]	LOCKWASHER
29.	1P-1131 T	[1]	KIT (Shaft Parts-Nut and Lockwasher)
30.	2L-0611	[1]	BEARING
31.	1P-1134	[1]	RACE
32.	6N-5257 CT	[1]	KIT (frame screw-12 bolts)
33.	6N-5254 C	[1]	HEAD ASSEM.
34.	3B-4507	[2]	LOCKWASHER 11mm(.437 in.)I.D.
	3B-4504	[2]	LOCKWASHER 6.35mm(.25in.)I.D.
35.	1D-4718	[2]	NUT 11mm(.437 in.) I.D.
	9M-1311	[2]	NUT 6.35mm(.25 in.)I.D.
36.	2H-6139	[4]	LOCKWASHER
37.	1P-1088 T	[1]	KIT (2 Brush Springs)
38.	2P-6261 C	[2]	INSULATOR
	C		INDICATES CHANGE
	S		2P1698 ALTERNATOR ASSEM. CONSI
	T		REPAIR KITS ARE AVAILABLE MARK

#SEBP10430162

5S-9088: ALTERNATOR GP-CHARGING

5S9088 ALTERNATOR ASSEMBLY--24 Volt, 50 Ampere--Part 1 of 2--Type 1
Part of 9S6693 Alternator Group shown on Page 81

c202886 SEBP1043

5S9088 ALTERNATOR GP-CHARGING Parts scheme

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	9S-2260	[1]	PLATE
2.	9S-2544	[4]	SCREW
3.	8H-0878	[6]	LOCKWASHER
4.	9S-2438	[2]	SCREW
5.	7H-2079	[7]	LOCKWASHER
6.	9S-2255	[1]	COVER
7.	9S-2262	[1]	GASKET
8.	9S-2246	[1]	LEAD ASSEM.
9.	9S-9830	[1]	SCREW
10.	8F-1326	[3]	WASHER
11.	9B-7233	[3]	LOCKWASHER (Shake Proof)
12.	9S-9829	[1]	SCREW ASSEM.
13.	4B-2043	[4]	NUT
14.	9S-2259	[1]	REGULATOR
15.	9S-2250	[1]	GROMMET
16.	9S-2011	[1]	SCREW
17.	1L-4789	[1]	LOCKWASHER
18.	9S-2389	[1]	STUD ASSEM.
19.	9S-2398	[1]	HOUSING ASSEM.
20.	9S-2393	[3]	DIODE
21.	9S-2397	[1]	COVER
22.	9F-2247	[1]	PLUG
23.	9S-2395	[1]	BEARING
24.	9S-2394	[1]	SEAL
25.	9S-2396	[1]	BUSHING
26.	9S-2007	[3]	SCREW
27.	9S-2301	[1]	INSULATION
28.	9S-2292	[1]	HEAT SINK ASSEM.
29.	9S-2300	[4]	INSULATOR
30.	9S-9830 C	[4]	SCREW
	9S-2247	[4]	WASHER (Spring)
	4B-4863	[4]	WASHER (Plain)
31.	9S-2542	[1]	SCREW
32.	9S-2437	[5]	SCREW
	9S-2013 H	[1]	KIT (Terminal Relay)
			(Consists of Bushing, "O" Ring & Hardware)
	9S-2012 H	[1]	KIT (Terminal Output)
			(Consists of Gaskets, Terminal & Hardware)
	9S-2290 H	[1]	KIT (Heat Sink)
			(Diode Junction Hardware)
	9S-2291 H	[1]	KIT (Heat Sink)
			(Positive Diode Hardware)
	C		INDICATES CHANGE
	H		NOT PART OF 5S9088 ALTERNATOR

#SEBP10430163

5S-9088: ALTERNATOR GP-CHARGING

5S9088 ALTERNATOR ASSEMBLY--24 Volt, 50 Ampere--Part 2 of 2--Type 1
Part of 9S6693 Alternator Group shown on Page 81

c113560 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	9S-2242	[1]	RACE
2.	9S-2248	[1]	FIELD COIL AND SUPPORT ASSEM.
3.	9S-2004	[1]	STATOR ASSEM.
4.	9S-2006	[1]	INSULATOR
5.	9S-2005	[1]	GROMMET
6.	9S-2014	[3]	CLIP
7.	9S-2302	[1]	ROTOR ASSEM.
8.	9S-2390	[1]	RETAINER ASSEM.
9.	9S-2391	[1]	SEAL
10.	9S-2256	[1]	GASKET
11.	9S-2261	[1]	COLLAR
12.	2F-5721	[1]	BEARING
13.	2P-5616	[1]	FRAME
14.	3B-4502	[4]	LOCKWASHER
15.	9S-2009	[4]	BOLT
16.	9S-2391	[1]	SEAL
17.	9S-2254	[1]	COLLAR
18.	9S-2252	[1]	SLINGER
19.	9S-2008	[4]	SCREW
20.	9S-2258	[1]	FAN AND BAFFLE ASSEM.
21.	7F-7621	[1]	WASHER
22.	2K-4821	[1]	LOCKNUT

#SEBP10430164

5S-9088: ALTERNATOR GP-CHARGING

5S9088 ALTERNATOR ASSEMBLY--24 Volt, 50 Ampere--Part 1 of 2--Type 2
Part of 9S6693 Alternator Group listed on Page 81. AN ATTACHMENT

c162528 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	9S-2260	[1]	PLATE
2.	9S-2544	[4]	SCREW
3.	8H-0878	[6]	LOCKWASHER
4.	9S-2438	[2]	SCREW
5.	7H-2079	[7]	LOCKWASHER
6.	9S-2255	[1]	COVER
7.	9S-2262	[1]	GASKET
8.	9S-2246	[1]	LEAD ASSEM.
9.	9S-9830	[1]	SCREW
10.	8F-1326	[3]	WASHER
11.	9B-7233	[3]	LOCKWASHER (shake proof)
12.	9S-9829	[1]	SCREW ASSEM.
13.	4B-2043	[4]	NUT
14.	7N-0129 C	[1]	REGULATOR ASSEM.
15.	9S-2250	[1]	GROMMET
16.	9S-2542	[1]	SCREW
17.	9S-2437	[5]	SCREW
18.	9S-2389	[1]	STUD ASSEM.
19.	7N-0174 C	[1]	HOUSING ASSEM.
			(Includes)
20.	9N-0943	[1]	PLUG
21.	5P-3418	[1]	BEARING
22.	9S-2396	[1]	BUSHING
23.	9S-2292	[1]	HEAT SINK ASSEM.
24.	9S-2300	[4]	INSULATOR
25.	9S-9830	[4]	SCREW
	9S-2247	[4]	WASHER (spring)
	4B-4863	[4]	WASHER (plain)
26.	9S-2007	[3]	SCREW
27.	9S-2301	[1]	INSULATION
	9S-2013 A	[1]	KIT (terminal relay)
			(Consists of Bushing, "O" Ring and Hardware)
	9S-2012 A	[1]	KIT (terminal output)
			(Consists of Gaskets, Terminal and Hardware)
	9S-2290 A	[1]	KIT (heat sink)
			(Diode Junction Hardware)
	9S-2291 A	[1]	KIT (heat sink)
			(Positive Diode Hardware)
	A		NOT PART OF THIS GROUP
	C		INDICATES CHANGE

#SEBP10430165

5S-9088: ALTERNATOR GP-CHARGING

5S9088 ALTERNATOR ASSEMBLY--24 Volt, 50 Ampere--Part 2 of 2--Type 2
Part of 9S6693 Alternator Group listed on Page 81. AN ATTACHMENT

c162529 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	5P-3419 C	[1]	RACE
2.	9S-2248	[1]	FIELD COIL AND SUPPORT ASSEM.
3.	9S-2004	[1]	STATOR ASSEM.
4.	9S-2006	[1]	INSULATOR
5.	9S-2005	[1]	GROMMET
6.	9S-2014	[3]	CLIP
7.	9S-2302	[1]	ROTOR ASSEM.
8.	9S-2390	[1]	RETAINER ASSEM.
9.	9S-2391	[1]	SEAL
10.	9S-2256	[1]	GASKET
11.	9S-2261	[1]	COLLAR
12.	2F-5721	[1]	BEARING
13.	2P-5616	[1]	FRAME
14.	3B-4502	[4]	LOCKWASHER
15.	9S-2009	[4]	BOLT
16.	9S-2391	[1]	SEAL
17.	9S-2254	[1]	COLLAR
18.	9S-2252	[1]	SLINGER
19.	9S-2008	[4]	SCREW
20.	9S-2258	[1]	FAN AND BAFFLE ASSEM.
21.	7F-7621	[1]	WASHER
22.	2K-4821	[1]	LOCKNUT
	C		INDICATES CHANGE

#SEBP10430166

8K-6883: BATTERY AND WIRING GROUP

8K6883 BATTERY AND WIRING GROUP--24 Volt--As Viewed from Rear R.H. Side of Machine--Part 1 of 3
Serial No. 82J4151 to 82J4788 inclusive
7H7290 Switch parts are shown on Page 90. See Page 89 for Wiring Diagram

c154485 SEBP1043

8K6883 BATTERY AND WIRING GROUP Parts scheme

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	1V-1739	[1]	HARNESS ASSEM.
			(Includes)
	5P-0695 J		CONDUIT 140.9 cm(55.50 in.)
	5P-0497 H		WIRE (14 gauge)
	5P-0616 H		WIRE (10 gauge)
2.	7K-9186	[2]	FERRULE
3.	6B-2667	[1]	TERMINAL
4.	5K-0786	[1]	TERMINAL
5.	4K-6495	[1]	TERMINAL
6.	6K-5125	[1]	TERMINAL
7.	4K-6494	[1]	TERMINAL
8.	7D-1314	[1]	TERMINAL
9.	7F-9224	[1]	TERMINAL
10.	2D-8781	[1]	TERMINAL
11.	2V-7413 C	[2]	FRAME ASSEM.
12.	4D-3946	[1]	CABLE ASSEM.
			(Includes)
	5P-0747 CJ		CABLE 127 cm(50 in.)
13.	2M-0913	[1]	TERMINAL (disconnect)
14.	5M-9205	[1]	TERMINAL ASSEM. (-)
			(Includes)
15.	1M-6119	[1]	BOLT
16.	1M-6120	[1]	NUT
17.	8M-5263	[1]	CABLE ASSEM.
			(Includes)
	5P-0747 CJ		CABLE 193 cm(76 in.)
18.	3D-2098	[2]	TERMINAL ASSEM.
			(Each Includes)
19.	1M-6119	[1]	BOLT
	1M-6120	[1]	NUT
20.	9M-8406	[2]	CLIP
21.	7K-1301 C	[2]	MAT
22.	4K-5715	[8]	BOLT
	1B-4330	[8]	NUT
	4B-4276	[16]	WASHER
	3B-4604	[8]	COTTER PIN
	3B-4504	[8]	LOCKWASHER
23.	6K-9961	[2]	CABLE ASSEM.
			(Each Includes)
	5P-0747 CJ		CABLE 27.94 cm(11 in.)
24.	5M-9205	[1]	TERMINAL ASSEM. (-)
			(Includes)
25.	1M-6120	[1]	BOLT
	1M-6119	[1]	NUT
26.	5M-9204	[1]	TERMINAL ASSEM. (+)
			(Includes)
27.	1M-6120	[1]	BOLT
	1M-6119	[1]	NUT
28.	7H-7290 Y	[1]	SWITCH ASSEM. (disconnect)
			(Separate Illustration)
	8H-8648	[1]	PLATE (instruction)
29.	5S-7219	[4]	BATTERY
			(Includes)
30.	5S-8405	[3]	PLUG
	C		INDICATES CHANGE
	Y		SEPARATE ILLUSTRATION
	J		ORDER BY THE CENTIMETRE
	H		ORDER BY THE DECIMETRE

#SEBP10430167

8K-6883: BATTERY AND WIRING GROUP

8K6883 BATTERY AND WIRING GROUP--24 Volt--As Viewed from Rear R.H. Side of Machine--Part 2 of 3
Serial No. 82J4151 to 82J4788 inclusive
See Page 89 for Wiring Diagram

c159298 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	4D-6466	[4]	CLIP
2.	4D-6988	[2]	CLIP
3.	6B-2366	[1]	CONNECTOR
4.	3S-2093	[2]	TIE
5.	5F-5990	[2]	CLIP
6.	2D-9535	[1]	GROMMET 20.64 mm(.813 in.)O.D.
			-OR-
	6K-8180 C	[1]	GROMMET 34.92 mm(1.37 in.)O.D.
7.	5K-4694	[1]	CABLE ASSEM.
			(Includes)
	5P-0747 CJ		CABLE 309.88 cm(122 in.)
8.	2M-0912	[1]	TERMINAL (starting motor)
9.	2M-0913	[1]	TERMINAL (disconnect switch)
10.	7K-2045	[1]	CABLE ASSEM.
			(Includes)
	5P-0747 CJ		CABLE 294.64 cm(116 in.)
11.	2M-0912	[1]	TERMINAL (solenoid switch)
12.	3D-2098	[1]	TERMINAL ASSEM. (+)
			(Includes)
13.	1M-6119 C	[1]	BOLT
	1M-6120 C	[1]	NUT
14.	8S-7713	[1]	SWITCH ASSEM. (heat-start)
			(Includes)
	8F-3437	[1]	LEVER
	5L-7200	[1]	SCREW
	3B-4501	[1]	LOCKWASHER
15.	5S-8580	[1]	WIRE ASSEM.
			(Includes)
	5P-5632 CH		WIRE .25 m(10 in.)
	2L-8066 C	[2]	TERMINAL
16.	5M-2555	[1]	CIRCUIT BREAKER
	5M-6668	[2]	SCREW
	8H-0878	[2]	LOCKWASHER
17.	8M-7892	[1]	AMMETER
18.	0S-1621	[2]	BOLT
	1D-4719	[2]	NUT
	3B-4508	[2]	LOCKWASHER
19.	0S-1594	[2]	BOLT
	1D-4717	[4]	NUT
20.	3B-4506	[5]	LOCKWASHER
21.	9M-8406	[1]	CLIP
	0S-0509	[1]	BOLT
22.	8K-6880	[1]	WIRE ASSEM.
			(Includes)
	5P-5632 CH		WIRE 1.01 m(40 in.)
	2L-8066 C	[1]	TERMINAL
23.	3M-6547	[1]	SHELL
	3M-6018	[1]	TERMINAL
	3M-6533	[1]	WASHER
24.	1V-1738	[1]	WIRE ASSEM.
			(Includes)
	2L-8066 C	[2]	TERMINAL
	5P-5632 H		WIRE .22 m(9 in.)
	C		INDICATES CHANGE
	J		ORDER BY THE CENTIMETRE
	H		ORDER BY THE METRE

#SEBP10430168

8K-6883: BATTERY AND WIRING GROUP

8K6883 BATTERY AND WIRING GROUP--24 Volt--As Viewed from Rear R.H. Side of Machine--Part 3 of 3
Serial No. 82J4151 to 82J4788 inclusive
See Page 89 for Wiring Diagram

c159298 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR:

Pos.	Part No	Qty	Parts name
1.	4D-6466	[4]	CLIP
2.	4D-6988	[2]	CLIP
3.	6B-2366	[1]	CONNECTOR
4.	3S-2093	[2]	TIE
5.	5F-5990	[2]	CLIP
6.	2D-9535	[1]	GROMMET 20.64 mm(.813 in.)O.D.
			-OR-
	6K-8180 C	[1]	GROMMET 34.92 mm(1.37 in.)O.D.
7.	5K-4694	[1]	CABLE ASSEM.
			(Includes)
	5P-0747 CJ		CABLE 309.88 cm(122 in.)
8.	2M-0912	[1]	TERMINAL (starting motor)
9.	2M-0913	[1]	TERMINAL (disconnect switch)
10.	7K-2045	[1]	CABLE ASSEM.
			(Includes)
	5P-0747 CJ		CABLE 294.64 cm(116 in.)
11.	2M-0912	[1]	TERMINAL (solenoid switch)
12.	3D-2098	[1]	TERMINAL ASSEM. (+)
			(Includes)
13.	1M-6119 C	[1]	BOLT
	1M-6120 C	[1]	NUT
14.	8S-7713	[1]	SWITCH ASSEM. (heat-start)
			(Includes)
	8F-3437	[1]	LEVER
	5L-7200	[1]	SCREW
	3B-4501	[1]	LOCKWASHER
15.	5S-8580	[1]	WIRE ASSEM.
			(Includes)
	5P-5632 CH		WIRE .25 m(10 in.)
	2L-8066 C	[2]	TERMINAL
16.	5M-2555	[1]	CIRCUIT BREAKER
	5M-6668	[2]	SCREW
	8H-0878	[2]	LOCKWASHER
17.	8M-7892	[1]	AMMETER
18.	0S-1621	[2]	BOLT
	1D-4719	[2]	NUT
	3B-4508	[2]	LOCKWASHER
19.	0S-1594	[2]	BOLT
	1D-4717	[4]	NUT
20.	3B-4506	[5]	LOCKWASHER
21.	9M-8406	[1]	CLIP
	0S-0509	[1]	BOLT
22.	8K-6880	[1]	WIRE ASSEM.
			(Includes)
	5P-5632 CH		WIRE 1.01 m(40 in.)
	2L-8066 C	[1]	TERMINAL
23.	3M-6547	[1]	SHELL
	3M-6018	[1]	TERMINAL
	3M-6533	[1]	WASHER
24.	1V-1738	[1]	WIRE ASSEM.
			(Includes)
	2L-8066 C	[2]	TERMINAL
	5P-5632 H		WIRE .22 m(9 in.)
	C		INDICATES CHANGE
	J		ORDER BY THE CENTIMETRE
	H		ORDER BY THE METRE

#SEBP10430169

8K-6883: BATTERY AND WIRING GROUP

8K6883 BATTERY AND WIRING GROUP--24 Volt--As Viewed from Rear R.H. Side of Machine--Part 1 of 3
Serial No. 82J4789-Up
7N718 Switch and 4V1603 Harness parts are shown on Pages 90 and 90A
See Page 89 for Wiring Diagram

c165760 SEBP1043

For full view, you need register

Parts for your D4D TRACK-TYPE TRACTOR: