3N7840 CLUTCH GP-POWER TAKE-OFF REPLACED BY 4W2650-PAGE 104A.01 PART OF 5N4657 POWER TAKE OFF-REAR AN ATTACHMENT 3208

BASIC ENGINE

CLUTCH GP

0. 3N-7840 CLUTCH GP
1. 2N-1373 CLUTCH AS
2. 2N-1373 CLUTCH AS

AIR COMPRESSOR GP

3. 6N-8895 AIR COMPRE
4. 6N-6090 AIR COMPRE

OPERATOR STATION

TACHOMETER GP

5. 7E-3158 TACHOMETER
6. 5N-9035 TACHOMETER

PANEL GP

7. 1W-5917 PANEL GP-I
8. 1W-5917 PANEL GP-I
9. 4W-2078 PANEL GP-I
0. INFORMATION

ENGINE - MACHINE 3208 ENGINE - MACHINE 03Z
3208 INDUSTRIAL ENGINE 03Z00001-10092 SEBP1304 3208 03Z (2018)

BASIC ENGINE

CLUTCH GP

#SEBP13040660

3N-7840: CLUTCH GP

CLUTCH GP

3N7840 CLUTCH GP-POWER TAKE-OFF
REPLACED BY 4W2650-PAGE 104A.01
PART OF 5N4657 POWER TAKE OFF-REAR
AN ATTACHMENT

c221488 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	4B-4805	[1]	RING
2.	6L-3966	[3]	PIN
	6L-3964	[3]	COTTER
3.	5D-2751	[6]	WASHER-SPRING
4.	4L-2849	[1]	NAMEPLATE-POWER TAKE-OFF (INSTRUCTION)
	1L-6931	[2]	SCREW AS-MACHINE
5.	4B-4787	[1]	LEVER AS
	0S-1587	[1]	BOLT
6.	3B-8489	[2]	FITTING-GREASE
7.	9S-1354	[1]	NUT
	6F-0253	[1]	LOCKWASHER
8.	4B-4775	[1]	HOSE AS
9.	1A-9136	[1]	BOLT
	3F-9556	[1]	LOCKWASHER
10.	7L-0116	[1]	LOCK
11.	5B-6159	[1]	SETSCREW-POINT
12.	5L-4202	[1]	HOUSING-CLUTCH
13.	6B-3224	[2]	CUP-BEARING
14.	4B-7255	[2]	CONE-BEARING
15.	4L-4866	[1]	KEY-SQUARE
16.	7F-9504 C	[1]	PLUG-PIPE
17.	1L-9088	[1]	SHAFT-CLUTCH
18.	2L-6010	[1]	PLUG-SPECIAL PIPE
19.	2L-8260	[1]	SLEEVE-SLIDING
20.	2N-9363	[1]	RETAINER-BEARING
21.	8B-7121	[2]	FITTING-HYDRAULIC
22.	4B-4715	[1]	COLLAR AS
	0L-0639	[2]	BOLT
	2L-6267	[2]	LOCKNUT
	4B-4722	[2]	SHIM
23.	6L-5151	[2]	KEY-WOODRUFF
24.	4B-4756	[1]	SHAFT
25.	4B-4725	[1]	YOKE
26.	0S-1591	[2]	BOLT
	9F-5644	[2]	LOCKWASHER
27.	6L-3965	[6]	PIN
	6L-3960	[6]	COTTER
28.	5B-5251	[6]	LINK
29.	3N-7953	[1]	PLATE AS
30.	3N-7952	[1]	PLATE-DRIVING
31.	2L-8256	[1]	PLATE-HUB & BACK
32.	2L-8257	[1]	NUT-HUB
33.	4B-4771	[1]	LOCK
34.	1L-9087	[1]	KEY
35.	2L-8259	[3]	LEVER
36.	2L-8262	[1]	RING-ADJUSTING
			THE FOLLOWING REPAIR
			KIT IS AVAILABLE:
	5N-3789 C	[1]	CLUTCH AS (INCL LEVERS,
			PINS, LINK, COLLAR AS,
			SLEEVE, RINGS & PLATES)
	C		CHANGE FROM PREVIOUS TYPE

#SEBP13040661

2N-1373: CLUTCH AS

CLUTCH AS

2N1373 CLUTCH ASSEMBLY-SIDE VIEW-PART 1 OF 2
PART OF 2N1374 POWER TAKE-OFF
AN ATTACHMENT

c155567 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	1F-5730	[1]	BEARING
2.	5L-2017	[1]	NUT
3.	5L-2026	[1]	WASHER
4.	5D-2751 C	[6]	WASHER
5.	6L-3966	[3]	PIN
	6L-3964	[3]	COTTER PIN
6.	7S-7934	[2]	PLATE ASEEM. (72 teeth)
7.	5L-2012	[1]	PLATE
8.	3N-9394 C	[1]	SLINGER
9.	2L-8259	[3]	LEVER
10.	6L-3965	[6]	PIN
	6L-3960	[6]	COTTER PIN
11.	5B-5251	[6]	LINK
12.	5B-2410	[1]	HOSE ASSEM. (39.37 cm - 15.5 in.)
13.	2N-2146	[1]	COLLAR ASSEM.
			(Includes)
	5L-3561	[2]	SHIM
14.	0L-1648	[2]	BOLT
	2L-6267	[2]	NUT
15.	2N-2145	[1]	RING
16.	2N-2142	[1]	RETAINER
17.	2N-2148	[1]	SHIM .13 mm(.005 in.) thick
	2N-2149	[1]	SHIM .18 mm(.007 in.) thick
	2N-2150	[1]	SHIM .26 mm(.010 in.) thick
	2N-2151	[1]	SHIM .51 mm(.020 in.) thick
18.	1K-6730	[1]	RING
19.	2N-2139	[2]	CONE
20.	2N-2138	[2]	CUP
21.	0S-1594	[6]	BOLT
	2N-2147	[3]	PLATE
22.	2N-2152	[1]	SEAL
23.	1B-8702	[1]	KEY
24.	6L-5151	[2]	KEY
25.	2K-2753	[1]	YOKE
26.	0S-1591	[2]	BOLT
27.	2N-2144	[1]	SLEEVE
28.	2L-8262	[1]	RING
29.	1N-7513	[1]	KEY
30.	2N-1372	[1]	RING
31.	5L-2016	[1]	PLATE
32.	3N-7953 C	[1]	PLATE ASSEM.
			(Includes)
33.	3N-7955	[1]	SPRING
	3N-7954	[1]	PIN

			AVAILABLE REPAIR KIT:

	165-0548	[1]	KIT-PARTS (INCLUDES SLEEVE-SLIDING, PIN, CLEVIS, COLLAR, YOKE, & LINK)
	C		INDICATES CHANGE

#SEBP13040662

2N-1373: CLUTCH AS

CLUTCH AS

2N1373 CLUTCH AS-END VIEW-PART 2 OF 2
PART OF 2N1374 POWER TAKE-OFF
AN ATTACHMENT

c155568 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	3N-9395 C	[1]	GAUGE ASSEM.
2.	3B-8489	[1]	FITTING
3.	9S-1354	[1]	NUT
4.	6F-0253	[1]	LOCKWASHER
5.	4B-0350	[1]	OIL CUP
6.	1N-5392	[1]	PLATE (Instruction)
8.	1L-6931	[2]	SCREW
9.	4L-4866	[1]	KEY
10.	3B-8490	[1]	FITTING
11.	4B-4787	[1]	LEVER ASSEM.
12.	0S-1587	[1]	BOLT
			(Part of 4B4787 Lever Assem.)
13.	2N-2137	[1]	SHAFT
14.	2N-2143	[2]	SLEEVE
15.	4L-7248	[2]	SEAL
16.	7H-3171	[2]	PLUG
17.	2B-7408	[1]	PLUG
18.	2N-2136	[1]	HOUSING (Clutch)
19.	4B-4756	[1]	SHAFT
20.	8B-7121	[2]	FITTING
21.	0S-1587	[8]	BOLT
22.	3N-9404 C	[1]	CARRIER ASSEM.
			(Includes)
23.	3N-9403	[1]	TUBE
	C		INDICATES CHANGE

#SEBP13040663

6N-8895: AIR COMPRESSOR GP

AIR COMPRESSOR GP

6N8895 AIR COMPRESSOR GP
6N6090-PAGE 109
ALSO AN ATTACHMENT

c456535 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	2N-3378	[1]	ELBOW
2.	6N-6090 YR	[1]	AIR COMPRESSOR GP
3.	7K-1517	[1]	ELBOW
4.	2N-1287	[1]	ELBOW-FLARED
5.	061-6750	[1]	HOSE AS
	5P-0733 E		HOSE
6.	5J-5008	[2]	FITTING
7.	1H-5166	[1]	CLIP
8.	6K-1972	[1]	ELBOW-FLARED
9.	6N-8892	[1]	ADAPTER-COMPRESSOR
10.	0S-1591	[4]	BOLT
11.	9N-1828	[1]	GASKET
12.	5K-3294	[1]	CLIP
13.	3H-5368	[4]	BOLT
14.	4S-9191	[1]	WASHER
15.	3R-5387	[1]	CONNECTOR
16.	5K-9244	[1]	ELBOW-FLARED
17.	6N-6182	[1]	TUBE AS
18.	6N-8891	[1]	GASKET
19.	3B-4618	[1]	COTTER
20.	4N-6708	[1]	PULLEY-AIR COMPRESSOR
21.	2N-1343 I	[1]	HOSE AS-END
22.	9N-6473 C	[1]	BRACKET-LIFTING
23.	4F-8965 C	[2]	BOLT
24.	5P-8244 C	[2]	WASHER
25.	9M-0397 C	[1]	ADAPTER-INLET
26.	2B-2695 C	[2]	BOLT
27.	3B-4505 C	[2]	LOCKWASHER
28.	5P-8248 C	[1]	WASHER-HARD
	C		CHANGE FROM PREVIOUS TYPE
	E		ORDER BY THE CENTIMETER
	I		SEE HOSE FABRICATION GUIDE
	R		REMFG PART MAY BE AVAILABLE
	Y		SEPARATE ILLUSTRATION

#SEBP13040664

6N-6090: AIR COMPRESSOR GP

AIR COMPRESSOR GP

6N6090 AIR COMPRESSOR GP*R
PART OF 6N8895 AIR COMPRESSOR
AN ATTACHMENT

c630533 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	3F-5289	[1]	KEY-CRANKSHAFT
2.	6N-5877	[1]	COVER-FRONT
3.	8T-6757	[1]	PLUG-PIPE
4.	6N-2099	[1]	CRANKCASE AS
5.	6N-7156	[1]	HEAD AS-COMPRESSOR (AIR)
6.	7W-6492	[2]	PLUG-PIPE
7.	6N-2098	[1]	GASKET-HEAD
8.	3L-0526 C	[4]	BOLT
9.	6N-5878	[1]	CRANKSHAFT
10.	7F-6547	[1]	NUT
11.	7N-4837	[2]	PISTON AS-COMPRESSOR
12.	8T-6764	[1]	PLUG-PIPE
13.	6N-2100	[1]	COVER AS-REAR
14.	6N-2106	[2]	ROD AS-CONNECTING
15.	2F-0194	[2]	STUD
	9S-8751	[2]	NUT-FULL
	3B-4505	[2]	LOCKWASHER
16.	9M-0384	[1]	ADAPTER
	1S-7107	[1]	GASKET
17.	0S-1619 C	[6]	BOLT
18.	8M-7065	[1]	GASKET-AIR INLET
19.	5P-0060 C	[4]	BOLT
20.	3B-4507	[8]	LOCKWASHER
21.	7N-0243	[2]	LOCK-ROD BOLT
22.	6N-5876	[1]	GASKET-FRONT COVER

23.	8N-3665 C	[1]	KIT-SEAL-O-RING
			(INCL SEALS & INSTR)
24.	5M-6509	[1]	SEAL-O-RING
25.	2H-5021	[1]	SEAL-LIP
26.	8H-9789	[1]	BALL BEARING
27.	9L-1518	[1]	WASHER-THRUST

			THE FOLLWING REPAIR
			KITS ARE AVAILABLE:
	8N-3666	[1]	KIT-AIR COMPRESSOR
			(INCL PISTONS, GUIDE,
			PLUNGER, SEAT, SPRING,
			SADDLE, RINGS, BOLTS,
			LOCKWASHERS, WASHERS,
			LOCK, BEARING, VALVES,
			GASKETS & INSTRUCTIONS)
	6N-2109	[1]	KIT-PISTON RING
	C		CHANGE FROM PREVIOUS TYPE

#SEBP13040665

7E-3158: TACHOMETER GP-ELECTRIC

TACHOMETER GP-ELECTRIC

7E3158 TACHOMETER GP-ELECTRIC
PART OF 7W3614 INSTRUMENT PANEL
AN ATTACHMENT

c485337 SEBP1304

7E3158 TACHOMETER GP-ELECTRIC Parts scheme

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	9X-1117	[1]	TACHOMETER
2.	9G-3186	[5]	TERMINAL-SPADE
3.	6V-2744 E		WIRE 130CM(51.18IN.)
	E		ORDER BY THE CENTIMETER

#SEBP13040666

5N-9035: TACHOMETER GP-ELECTRIC

TACHOMETER GP-ELECTRIC

5N9035 TACHOMETER GP-ELECTRIC
24 VOLT. REPLACED BY 7E3158
FOR USE WITH FIRE PUMP ENGINES
PART OF 4W9540 & 7W3614 PANELS. AN ATTACHMENT

c309831 SEBP1304

5N9035 TACHOMETER GP-ELECTRIC Parts scheme

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	3T-4060	[1]	TACHOMETER
2.	3T-2161	[1]	BOARD (PROGRAMMING)
3.	9B-7242	[2]	SCREW-MACHINE
4.	9G-3186	[5]	TERMINAL-SPADE
5.	6V-2744 E		WIRE 130CM(51.18IN)
	E		ORDER BY THE CENTIMETER

#SEBP13040667

1W-5917: PANEL GP-INSTRUMENT

PANEL GP-INSTRUMENT

1W5917 PANEL GP-INSTRUMENT-PART 1 OF 2
12 VOLT. R.H. MOUNTED
REPLACED BY 2W1162-PAGE 113A. 6N0355-PAGE 114
2N3909 TACHOMETER DRIVE ADAPTER IS AVAILABLE
AN ATTACHMENT

c179754 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	2N-0782	[1]	SENDER-OIL PRESSURE
2.	7B-2742	[1]	BOLT
3.	2N-1311	[1]	SENDER (WATER TEMPERATURE)
4.	2N-0179	[1]	COVER-PANEL
5.	4B-1219	[2]	SCREW-MACHINE
	4B-2040	[2]	NUT
	9B-1117	[2]	LOCKWASHER
6.	6N-0355 Y	[1]	PANEL GP-INSTRUMENT
7.	2N-0219	[1]	BRACKET-PANEL
8.	2B-0941	[2]	SPACER
9.	0S-1571	[2]	BOLT
	1D-4717	[2]	NUT
	5M-2894	[4]	WASHER
10.	4F-7957	[4]	BOLT
11.	1B-4330	[5]	NUT
	5P-0537	[10]	WASHER
12.	1W-5919	[1]	SUPPORT
13.	2N-1052	[1]	ANGLE
14.	4M-5317	[1]	BUSHING
	Y		SEPARATE ILLUSTRATION

#SEBP13040668

1W-5917: PANEL GP-INSTRUMENT

PANEL GP-INSTRUMENT

1W5917 PANEL GP-INSTRUMENT-PART 2 OF 2
12 VOLT. R.H. MOUNTED
REPLACED BY 2W1162-PAGE 113A. 9G1480-PAGE 114
2N3909 TACHOMETER DRIVE ADAPTER IS AVAILABLE
AN ATTACHMENT

c179755 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	9G-1480 Y	[1]	SWITCH GP-START (HEAT)
2.	8J-4785	[1]	PLATE-INSTRUCTION
3.	0S-1591	[3]	BOLT
	5M-2894	[3]	WASHER (SMALL)
4.	5B-9627 B	[3]	WASHER (LARGE)

	6N-0349 F	[1]	WIRING GP-INSTRUMENT
	5P-5621 DF		WIRE (12 GAUGE) 1.3M(51.18IN)
	5P-5622 DF		WIRE (10 GAUGE) 3.2M(125.98IN)
	5P-5675 DF		WIRE (6 GAUGE) 3.8M(149.61IN)
	5P-5624 DF		WIRE (14 GAUGE) 7.4M(291.34IN)
	2L-8065 JF	[1]	TERMINAL (NO 8 SCREW)
	2L-8066 JF	[1]	TERMINAL (NO 10 SCREW)
	2L-8066 LF	[3]	TERMINAL (NO 10 SCREW)
	2L-8071 LF	[1]	TERMINAL 12.7MM(.5IN)SCREW
	2L-8054 NF	[3]	TERMINAL 12.7MM(.5IN)SCREW
	2L-8049 NF	[4]	TERMINAL (NO 10 SCREW)
	2L-8051 NF	[2]	TERMINAL 7.87MM(.31IN)SCREW
	2L-8050 NF	[1]	TERMINAL 6.35MM(.25IN)SCREW
	2L-8076 SF	[9]	TERMINAL (NO 10 SCREW)
	2L-8075 SF	[4]	TERMINAL (NO 8 SCREW)
	2L-8081 SF	[1]	TERMINAL 12.7MM(.5IN)SCREW
	6L-3483 F	[2]	COVER-TERMINAL
	009-8708 F	[2]	BOOT-TERMINAL
	3S-2093 F	[10]	STRAP-CABLE
	8L-8413 F	[40]	STRAP-CABLE
	1H-5166 F	[3]	CLIP
	2L-9724 F	[3]	CLIP-WIRE

			J-USED WITH NO 12 WIRE
			L-USED WITH NO 10 WIRE
			N-USED WITH NO 6 WIRE
			S-USED WITH NO 14 WIRE
	B		USE AS REQUIRED
	D		ORDER BY THE METER
	F		NOT SHOWN
	Y		SEPARATE ILLUSTRATION

#SEBP13040669

4W-2078: PANEL GP-INSTRUMENT

PANEL GP-INSTRUMENT

4W2078 PANEL GP-INSTRUMENT
24 VOLT
5N9351-PAGE 113F
AN ATTACHMENT

c322492 SEBP1304

For full view, you need register

Parts for your 3208 ENGINE - MACHINE:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	030-2010	[1]	SENDER AS (OIL PRESSURE)
2.	0S-1571	[2]	BOLT
	1D-4717	[2]	NUT
3.	5M-2894	[7]	WASHER (SMALL)
4.	2N-0179	[1]	COVER-PANEL
5.	4B-1219	[2]	SCREW-MACHINE
	4B-2040	[2]	NUT
	9B-1117	[2]	LOCKWASHER
6.	5N-9351 Y	[1]	PANEL GP-INSTRUMENT
7.	2N-0219	[1]	BRACKET-PANEL
8.	2B-0941	[2]	SPACER
9.	7B-2742	[1]	BOLT
10.	4F-7957	[4]	BOLT
11.	1B-4330	[5]	NUT
	5P-0537	[10]	WASHER
12.	2W-0419	[1]	BRACKET-SUPPORT
13.	5L-7442	[1]	SENDING UNIT (WATER TEMPERATURE)
14.	0S-1591	[3]	BOLT
15.	5B-9627 J	[1]	WASHER (LARGE)
16.	2N-1052	[1]	ANGLE
17.	4M-5317	[1]	BUSHING
	6N-0349 F	[1]	WIRING GP-INSTRUMENT
			J-USE WITH LH MOUNTING
	F		NOT SHOWN
	Y		SEPARATE ILLUSTRATION