5P-8768 KIT-GASKET -SINGLE CYLINDER LINER S/N 4HD1-99999 FIELD INSTALLATION 120G MOTOR GRADER

Part No	Qty	Parts name
1P-0451	[1]	GASKET
5S-6735	[2]	GASKET
7B-5932	[1]	GASKET
7N-0200	[1]	GASKET
7N-0944	[1]	GASKET
8H-9788	[1]	GASKET
8S-1606	[1]	GASKET-COVER
4P-8915	[1]	GASKET-CYLINDER HEAD
2P-6132	[1]	GASKET-ELBOW
9Y-1979	[2]	GASKET-MANIFOLD
1P-1255	[1]	GASKET-OIL DRAIN
1S-6595	[1]	GASKET-OIL SUPPLY
7W-7544	[1]	GASKET-PLATE
7N-8018	[4]	SEAL
9Y-1798	[12]	SEAL
9L-9098	[4]	SEAL-CARBON STOP
3K-0360	[1]	SEAL-O-RING
3S-5496	[2]	SEAL-O-RING
4L-9564	[1]	SEAL-O-RING
8M-4448	[1]	SEAL-O-RING
9M-4849	[1]	SEAL-O-RING
7W-4486	[4]	WASHER (9.76X17.14X1.8-MM THK)
114-3364	[4]	WASHER-SPECIAL (SEALING)

#SEBP17170572

5P-9060: PLATE & FILM GP

PLATE & FILM GP

5P-9060 PLATE & FILM GP
S/N 4HD2190-99999
SPANISH
PART OF 5Y-0449, 8W-1953 CHASSIS AR

i01182358 SEBP1717

For full view, you need register

Parts for your 120G MOTOR GRADER:

Part No	Qty	Parts name
3E-3263	[2]	FILM (120 G)
		LOCATE ON BOTH SIDES OF RADIATOR GUARD BELOW LOWER GRAB IRON MOUNTING
3E-3267	[1]	FILM (CATERPILLAR)
		LOCATE BOTTOM EDGE OF STRIPE AT START OF RADIUS ON REAR OF RADIATOR GUARD
3E-3268	[2]	FILM (CATERPILLAR)
		LOCATE ON EACH SIDE OF FRONT FRAME CENTERED BETWEEN MIDDLE OF BOLTS
3E-3269	[1]	FILM (CAT, LH)
		LOCATE ON SIDE OF RADIATOR GUARD ABOVE LOWER GRAB IRON MOUNTING
3E-3270	[1]	FILM (CAT, RH)
		LOCATE ON SIDE OF RADIATOR GUARD ABOVE LOWER GRAB IRON MOUNTING
5P-1175	[1]	FILM-IDENTIFICATION (ENGINE OIL FILL)
		LOCATE ON ENGINE OIL FILLER CAP.
6V-7615	[1]	FILM-IDENTIFICATION (FUEL FILTER)
		LOCATE ON SECONDARY FUEL FILTER.
6V-7618	[1]	FILM-IDENTIFICATION (OIL FILTER)
		LOCATE ON ENGINE OIL FILTER.
3E-3309	[1]	FILM-NOTICE
		LOCATE ON LH REAR FRAME, FORWARD OF RADIATOR GUARD & SUPPORT PLATE.
1P-2807	[4]	FILM-IDENTIFICATION (LIFT EYE LOCATION)
		LOCATE 2 ON OUTBOARD SIDE OF RH & LH BLADE LIFT ARMS.
		LOCATE 2 ON OUTSIDE CENTER OF RH & LH REAR FRAMES.
7X-7644	[3]	FILM-IDENTIFICATION (TIE-DOWN)
		1-LOCATE BY CENTERING ON LH TOP OF MAIN FRAME BOLSTER AS. LOWER PLATE.
		2-LOCATE ON RH & LH SIDES OF REAR BUMPER HITCH.
5P-1426	[2]	FILM-WARNING (NO CLEARANCE)
		LOCATE ON EACH SIDE OF ENGINE DASH, NEAR BOTTOM.
5P-1436	[2]	FILM-WARNING (ROTATING FAN BLADES)
		LOCATE ON EACH RADIATOR ACCESS DOOR.
5P-4077	[1]	FILM-WARNING (HAZARD, READ OMM)
		LOCATE ON SHIFT CONSOLE INSTRUCTION PLATE, ABOVE WORD "CENTERSHIFT".
5P-4114	[1]	FILM-WARNING (SPRING LOADED PIN, READ MANUAL)
		LOCATE ON THE END OF CENTERSHIFT LOCK PIN HOUSING.
6V-4611	[1]	FILM-WARNING (JUMP START, READ OMM)
		LOCATE ON SIDE OF RH BATTERY BOX.
8T-1363	[1]	FILM-WARNING (COMPRESSED SPRING, READ OMM)
		LOCATE ON REAR OF ROTOCHAMBER.
9T-7308	[1]	FILM-WARNING (HIGH PRESSURE CYLINDER)
		LOCATE ON STEERING ACCUMULATOR.
9X-1878	[1]	PLATE-IDENTIFICATION
		LOCATE ON RIGHT SIDE OF MAIN FRAME, BEHIND LIFT CYLINDER BRACKET, BELOW MAIN FRAME PLATE.
8H-8648	[1]	PLATE-INSTRUCTION (DISCONNECT SWITCH)
		LOCATE ON ENGINE DASH.
5P-3999	[1]	PLATE-INFORMATION (DO NOT DRILL OR WELD)
		LOCATE ON RH SIDE OF FRONT FRAME, BEHIND LIFT CYLINDER BRACKET.
6V-9648	[1]	PLATE-SERVICE INFORMATION
		LOCATE ON STEERING COLUMN.
5P-8197	[1]	PLATE-WARNING (READ OMM)
		LOCATE ON REAR OF OPERATOR CONSOLE.
3F-5535	[2]	SCREW-DRIVE (NO 10X0.375-IN)
4B-4158	[16]	SCREW-DRIVE (NO 4X0.25-IN)

#SEBP17170573

5Y-1691: PLATE & FILM GP

PLATE & FILM GP

5Y-1691 PLATE & FILM GP
S/N 4HD1-99999
PORTUGUESE
AN ATTACHMENT

i01182622 SEBP1717

For full view, you need register

Parts for your 120G MOTOR GRADER:

Part No	Qty	Parts name
3E-3263	[2]	FILM (120 G)
		LOCATE ON BOTH SIDES OF RADIATOR GUARD BELOW LOWER GRAB IRON MOUNTING
3E-3267	[1]	FILM (CATERPILLAR)
		LOCATE BOTTOM EDGE OF STRIPE AT START OF RADIUS ON REAR OF RADIATOR GUARD
3E-3268	[2]	FILM (CATERPILLAR)
		LOCATE ON EACH SIDE OF FRONT FRAME CENTERED BETWEEN MIDDLE OF BOLTS
3E-3269	[1]	FILM (CAT, LH)
		LOCATE ON SIDE OF RADIATOR GUARD ABOVE LOWER GRAB IRON MOUNTING
3E-3270	[1]	FILM (CAT, RH)
		LOCATE ON SIDE OF RADIATOR GUARD ABOVE LOWER GRAB IRON MOUNTING
5P-1175	[1]	FILM-IDENTIFICATION (ENGINE OIL FILL)
		LOCATE ON ENGINE OIL FILLER CAP.
6V-7615	[1]	FILM-IDENTIFICATION (FUEL FILTER)
		LOCATE ON SECONDARY FUEL FILTER.
6V-7618	[1]	FILM-IDENTIFICATION (OIL FILTER)
		LOCATE ON ENGINE OIL FILTER.
3E-3309	[1]	FILM-NOTICE
		LOCATE ON LH REAR FRAME, FORWARD OF RADIATOR GUARD & SUPPORT PLATE.
1P-2807	[4]	FILM-IDENTIFICATION (LIFT EYE LOCATION)
		LOCATE 2 ON OUTBOARD SIDE OF RH & LH BLADE LIFT ARMS.
		LOCATE 2 ON OUTSIDE CENTER OF RH & LH REAR FRAMES.
7X-7644	[3]	FILM-IDENTIFICATION (TIE-DOWN)
		1-LOCATE BY CENTERING ON LH TOP OF MAIN FRAME BOLSTER AS. LOWER PLATE.
		2-LOCATE ON RH & LH SIDES OF REAR BUMPER HITCH.
5P-1426	[2]	FILM-WARNING (NO CLEARANCE)
		LOCATE ON EACH SIDE OF ENGINE DASH, NEAR BOTTOM.
5P-1436	[2]	FILM-WARNING (ROTATING FAN BLADES)
		LOCATE ON EACH RADIATOR ACCESS DOOR.
5P-4077	[1]	FILM-WARNING (HAZARD, READ OMM)
		LOCATE ON SHIFT CONSOLE INSTRUCTION PLATE, ABOVE WORD "CENTERSHIFT".
5P-4114	[1]	FILM-WARNING (SPRING LOADED PIN, READ MANUAL)
		LOCATE ON THE END OF CENTERSHIFT LOCK PIN HOUSING.
6V-4611	[1]	FILM-WARNING (JUMP START, READ OMM)
		LOCATE ON SIDE OF RH BATTERY BOX.
8T-1363	[1]	FILM-WARNING (COMPRESSED SPRING, READ OMM)
		LOCATE ON REAR OF ROTOCHAMBER.
9T-7308	[1]	FILM-WARNING (HIGH PRESSURE CYLINDER)
		LOCATE ON STEERING ACCUMULATOR.
9X-1878	[1]	PLATE-IDENTIFICATION
		LOCATE ON RIGHT SIDE OF MAIN FRAME, BEHIND LIFT CYLINDER BRACKET, BELOW MAIN FRAME PLATE.
8H-8648	[1]	PLATE-INSTRUCTION (DISCONNECT SWITCH)
		LOCATE ON ENGINE DASH.
5P-3999	[1]	PLATE-INFORMATION (DO NOT DRILL OR WELD)
		LOCATE ON RH SIDE OF FRONT FRAME, BEHIND LIFT CYLINDER BRACKET.
6V-9648	[1]	PLATE-SERVICE INFORMATION
		LOCATE ON STEERING COLUMN.
5P-8197	[1]	PLATE-WARNING (READ OMM)
		LOCATE ON REAR OF OPERATOR CONSOLE.
3F-5535	[2]	SCREW-DRIVE (NO 10X0.375-IN)
4B-4158	[16]	SCREW-DRIVE (NO 4X0.25-IN)

#SEBP17170574

103-2492: PLATE & FILM GP

PLATE & FILM GP

103-2492 PLATE & FILM GP
S/N 4HD1-99999
ARABIC
AN ATTACHMENT

i00144798 SEBP1717

For full view, you need register

Parts for your 120G MOTOR GRADER:

Part No	Qty	Parts name
6V-0249	[1]	FILM-WARNING (GROUND BLADE)
6V-0250	[1]	FILM-WARNING (CENTERSHIFT PIN)
6V-0251	[2]	FILM-WARNING (NO CLEARANCE)
6V-0252	[2]	FILM-WARNING (ROTATING FAN BLADES)
6V-8831	[1]	FILM-WARNING (JUMPER CABLE)
7X-0947	[1]	FILM-WARNING (HIGH PRESSURE CYLINDER)
5P-9761	[1]	PLATE-WARNING (UNIVERSAL)

#SEBP17170575

8W-6840: PROTECTION AR-VANDALISM

PROTECTION AR-VANDALISM

8W-6840 PROTECTION AR-VANDALISM
S/N 4HD1-99999
AN ATTACHMENT

i00144668 SEBP1717

For full view, you need register

Parts for your 120G MOTOR GRADER:

Part No	Qty	Parts name
6G-9000 Y	[1]	PROTECTION GP-VANDALISM (TRANSMISSION GAUGE)
6G-9005 Y	[1]	PROTECTION GP-VANDALISM (TRANSMISSION OIL FILLER)
6G-8990 Y	[1]	GUARD GP-VANDALISM
1N-4297 Y	[1]	GUARD GP-VANDALISM (OIL LEVEL GAUGE)
5N-8553 Y	[1]	PROTECTION GP-ENG OIL FILLER
Y		SEPARATE ILLUSTRATION

#SEBP17170576

6G-8995: PROTECTION GP-VANDALISM

PROTECTION GP-VANDALISM

6G-8995 PROTECTION GP-VANDALISM
S/N 4HD1-99999
RADIATOR CAP PROTECTION
PART OF 5Y-0449, 8W-1953 CHASSIS AR
ALSO AN ATTACHMENT

i00144338 SEBP1717

6G8995 PROTECTION GP-VANDALISM Parts scheme

For full view, you need register

Parts for your 120G MOTOR GRADER:

Pos.	Part No	Qty	Parts name
1.	5P-8502	[1]	PADLOCK GP
	8Y-6364 A	[1]	SLEEVE
	5P-8500 A	[1]	KEY
2.	9D-5264	[1]	PLATE AS
3.	9D-5267	[1]	CAP
4.	9M-5732	[5]	RIVET-POP
5.	9D-5266	[1]	BRACKET
6.	8F-0964	[1]	RIVET
	A		NOT PART OF THIS GROUP

#SEBP17170577

6G-9000: PROTECTION GP-VANDALISM

PROTECTION GP-VANDALISM

6G-9000 PROTECTION GP-VANDALISM
S/N 4HD1-99999
TRANSMISSION GAUGE
PART OF 8W-6840 PROTECTION AR-VANDALISM
AN ATTACHMENT

i00144339 SEBP1717

6G9000 PROTECTION GP-VANDALISM Parts scheme

For full view, you need register

Parts for your 120G MOTOR GRADER:

Pos.	Part No	Qty	Parts name
1.	5P-8502	[1]	PADLOCK GP
	8Y-6364 A	[1]	SLEEVE
	5P-8500 A	[2]	KEY
2.	8B-7179	[2]	SETSCREW-SOCKET (5/16-18X0.375-IN)
3.	9D-5298	[1]	COLLAR AS
4.	8S-4212	[1]	RIVET
5.	2P-2717	[1]	HASP
	A		NOT PART OF THIS GROUP

#SEBP17170578

6G-9005: PROTECTION GP-VANDALISM

PROTECTION GP-VANDALISM

6G-9005 PROTECTION GP-VANDALISM
S/N 4HD1-99999
PART OF 8W-6840 PROTECTION AR-VANDALISM
AN ATTACHMENT

i00144340 SEBP1717

6G9005 PROTECTION GP-VANDALISM Parts scheme

For full view, you need register

Parts for your 120G MOTOR GRADER:

Pos.	Part No	Qty	Parts name
1.	5P-8502	[1]	PADLOCK GP
	8Y-6364 A	[1]	SLEEVE
	5P-8500 A	[2]	KEY
2.	8B-7179	[2]	SETSCREW-SOCKET (5/16-18X0.375-IN)
3.	9D-5299	[1]	COLLAR AS
4.	8S-4212	[1]	RIVET
5.	2P-2717	[1]	HASP
	A		NOT PART OF THIS GROUP

#SEBP17170579

9S-7978: TOOL GP-HAND

TOOL GP-HAND

9S-7978 TOOL GP-HAND
S/N 4HD1-99999
AN ATTACHMENT

i00138408 SEBP1717

For full view, you need register

Parts for your 120G MOTOR GRADER:

Pos.	Part No	Qty	Parts name
1.	2Y-8279	[1]	TOOL GP-HAND
	1P-5522	[1]	WRENCH (CMB 5/16 IN)
	1P-5523	[1]	WRENCH (CMB 3/8 IN)
	1P-5524	[1]	WRENCH (CMB 1/2 IN)
	1P-5525	[1]	WRENCH (CMB 9/16 IN)
	1P-5526	[1]	WRENCH (CMB 5/8 IN)
	1P-5527	[1]	WRENCH (CMB 3/4 IN)
	5P-6224	[1]	WRENCH-COMBINATION (11/16-IN)(11/16 IN)
2.	5P-6227	[1]	SOCKET (1/2-IN)(1/2 IN)
	1P-5530	[1]	SOCKET (9/16-IN)(9/16 IN)
	1P-5531	[1]	SOCKET (11/16 IN)
	1P-5532	[1]	SOCKET (3/4 IN)
	1P-5533	[1]	SOCKET (13/16 IN)
	1P-5534	[1]	SOCKET (7/8 IN)
	1P-5535	[1]	SOCKET (15/16 IN)
	1P-5537	[1]	SOCKET (1 1/8 IN)
	1P-5538	[1]	SOCKET (1 1/4 IN)
	1P-5539	[1]	SOCKET (1 5/16 IN)
	1P-5540	[1]	SOCKET (1 1/2 IN)
	5P-6226	[1]	SOCKET (1-5/8-IN)(1 5/8 IN)
	1P-5541	[1]	SOCKET (1 7/8 IN)
3.	1P-5518	[1]	SCREWDRIVER
4.	1P-5521	[1]	SCREWDRIVER-PHILLIPS
5.	5S-9567	[1]	EXTENSION (NO. 2)
6.	5S-9566	[1]	WRENCH-SLIDING TOOTH
7.	8F-9866 Y	[1]	GREASE GUN GP
9.	5F-4764	[1]	BAR-PRY
10.	5P-1763	[1]	SOCKET-VALVE
11.	185-3630	[1]	WRENCH AS-STRAP
	6H-7378	[2]	RING-RETAINING
12.	1P-0551	[1]	PIN-SPRING
13.	5S-9568	[1]	SOCKET-DRAIN PLUG
14.	1P-0545	[1]	GAUGE GP-PRESSURE
		[1]	BAG-CLOTH
	Y		SEPARATE ILLUSTRATION