109-6897 WIRING GP-ELECTRONICS BAY -VIDS S/N 7HR1-278 PART OF 131-8153 WIRING GP-MONITOR 992G WHEEL LOADER

109-6897: WIRING GP-ELECTRONICS BAY

109-6897 WIRING GP-ELECTRONICS BAY -VIDS
S/N 7HR1-278
PART OF 131-8153 WIRING GP-MONITOR

Parts for your 992G WHEEL LOADER:

Pos.	Part No	Qty	Parts name
1.	112-1756	[1]	ENCLOSURE AS-ELECTRONICS BAY
	6V-9632 M	[11]	NUT-WELD (M6X1-THD)
	151-0961	[2]	BOSS
	8T-3490 M	[16]	NUT-WELD (M10X1.5-THD)
	8T-3597 M	[15]	NUT-WELD (M12X1.75-THD)
	8T-3635 M	[4]	STUD-WELD (M12X1.75X34.93-MM)
	095-2887	[2]	PLATE
2.	8T-4223	[3]	WASHER-HARD (13.5X25.5X3-MM THK)
3.	112-1757	[1]	COVER AS
	6V-2370	[5]	RIVET-POP
4.	112-1758	[1]	COVER AS
5.	8T-4137 M	[13]	BOLT (M10X1.5X20-MM)
6.	8T-4121	[19]	WASHER-HARD (11X21X2.5-MM THK)
7.	142-3363 Y	[1]	CONTROL GP-UNPROGRAMMED (POWER TRAIN)
8.	104-5612	[2]	BAR
9.	4L-6454	[4]	BOLT (3/8-16X1-IN)
10.	8T-4896	[4]	WASHER-HARD (10.2X18.5X2.5-MM THK)
11.	8T-9655	[32]	MOUNT-ISOLATION
12.	8T-9658	[8]	SPACER (8.2X12.7X25.4-MM THK)
13.	099-3649 M	[8]	BOLT (M8X1.25X40-MM)
14.	9N-0869	[16]	WASHER-HARD (8.8X25.5X2-MM THK)
15.	144-7172 Y	[1]	MODULE GP-VIDS/VIMS INTERFACE
16.	8T-4136 M	[4]	BOLT (M10X1.5X25-MM)
17.	4P-8134	[1]	CLIP (LADDER)
18.	9X-6772	[4]	STRAP-CABLE
19.	142-3371 Y	[1]	CONTROL GP-UNPROGRAMMED (IMPLEMENT)
20.	6I-1418	[8]	SPACER (8.2X12.7X28.7-MM THK)
21.	7X-0818 M	[8]	BOLT (M8X1.25X45-MM)
22.	130-5131 Y	[1]	CONTROL GP-UNPRGMED MONITOR
23.	115-1496	[1]	TUBE
24.	9X-2042 M	[13]	SCREW-TRUSS HEAD (M6X1X12-MM)
25.	8T-4244 M	[3]	NUT (M12X1.75-THD)
26.	3E-5239	[2]	RELAY AS (24-VOLT)
27.	107-3727	[4]	SCREW-PAN HEAD
28.	4B-4274	[10]	WASHER (5.5X13X1.2-MM THK)
29.	4K-5122	[15]	HOLDER AS-FUSE
	139-0178	[1]	CAP
30.	3K-8782	[8]	FUSE (10-AMPERE)
31.	8M-8948	[4]	FUSE (15-AMPERE)
32.	8M-0456	[1]	FUSE (20-AMPERE)
33.	115-1494	[1]	PLATE AS
34.	115-3038	[1]	FILM-IDENTIFICATION (FUSE)
35.	033-8248	[2]	CLIP (LOOP)
36.	8T-4191 M	[2]	BOLT (M10X1.5X16-MM)
37.	124-6704	[1]	RESISTOR AS (ETHER SOLENOID LOAD)
38.	3T-0376	[1]	SWITCH AS-MAGNETIC (FLOOD LAMP RELAY)
	4F-2294	[2]	NUT-JAM (5/16-24-THD)
	6V-8186	[2]	NUT-FULL (5/16-24-THD)
	6V-8378	[2]	NUT (10-32-THD)
39.	6B-4540	[4]	NUT (4-40-THD)
40.	6V-9497	[4]	WASHER-HARD (3.2X6X0.5-MM THK)
41.	115-1495	[1]	PLATE
42.	4B-2049	[4]	NUT (10-32-THD)
43.	3E-7294	[2]	CIRCUIT BREAKER AS (105-AMPERE)(ALTERNATOR & MAIN)
44.	7V-9275	[1]	STRAP
45.	6T-3642	[1]	CIRCUIT BREAKER AS (10-AMPERE)(KEY START)
46.	6T-3643	[1]	CIRCUIT BREAKER AS (15-AMPERE)(ENGINE ECM)
47.	3T-2662	[1]	CIRCUIT BREAKER AS (15-AMPERE, AUTOMATIC RESET)(RUNNING LAMPS)
48.	3D-9799	[6]	SCREW-MACHINE (8-32X0.875-IN)
49.	4B-4863	[6]	WASHER (4.7X11X1.2-MM THK)
50.	115-9346	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
51.	8C-6354	[1]	CAP-RECEPTACLE (ET CONNECTOR)
52.	4B-1237	[4]	SCREW-MACHINE (10-32X12.7-MM)
53.	115-9347	[1]	FILM-IDENTIFICATION (ENGINE SERVICE)
54.	122-8450	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
55.	4B-1240	[4]	SCREW-MACHINE (10-32X1-IN)
56.	114-0931	[1]	FILM-IDENTIFICATION (SERVICE CONNECTOR)
57.	9G-4360	[1]	CAP-CONNECTOR
58.	5S-4245	[4]	SCREW-MACHINE (4-40X0.5-IN)
59.	7I-3652	[1]	STRIP
60.	9X-8256	[3]	WASHER (6.6X12X2-MM THK)
61.	3E-0075 Y	[2]	SWITCH GP-MAGNETIC (24-VOLT)
62.	5P-4115	[2]	WASHER-HARD (7.2X19X2-MM THK)
63.	5C-2890 M	[2]	NUT (M6X1-THD)
64.	8T-4138 M	[2]	BOLT (M6X1X20-MM)
65.	9G-8451	[1]	BLOCK AS
	1H-3244	[1]	LOCKWASHER
	4B-4276	[2]	WASHER (7X16X1.6-MM THK)
	4L-7124	[1]	BOLT (1/4-20X1.25-IN)
	6V-8185	[2]	NUT (1/4-20-THD)
66.	112-1761	[2]	HARNESS AS-PANEL (FUSE)
67.	112-1760	[1]	WIRE AS
68.	112-1762	[1]	HARNESS AS-PANEL (FUSE)
69.	115-3039	[1]	HARNESS AS
70.	130-7239	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
71.	106-8704	[2]	SUPPRESSOR AS-ARC
72.	130-7240	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
73.	7K-1181	[17]	STRAP-CABLE
74.	108-7696	[2]	BAR
75.	132-8519	[1]	FILM-IDENTIFICATION
76.	3T-0376	[1]	SWITCH AS-MAGNETIC (MAIN POWER RELAY)
	4F-2294	[2]	NUT-JAM (5/16-24-THD)
	6V-8186	[2]	NUT-FULL (5/16-24-THD)
	6V-8378	[2]	NUT (10-32-THD)
	M		METRIC PART
	Y		SEPARATE ILLUSTRATION

131-4377: WIRING GP-ELECTRONICS BAY

WIRING GP-ELECTRONICS BAY

131-4377 WIRING GP-ELECTRONICS BAY -VIMS
S/N 7HR1-283
PART OF 131-8155 VIMS AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	112-1756	[1]	ENCLOSURE AS-ELECTRONICS BAY
	6V-9632 M	[11]	NUT-WELD (M6X1-THD)
	7X-0751 M	[2]	BOSS-WELD (M10X1.5-THD)
	8T-3490 M	[16]	NUT-WELD (M10X1.5-THD)
	8T-3597 M	[15]	NUT-WELD (M12X1.75-THD)
	8T-3635 M	[4]	STUD-WELD (M12X1.75X34.93-MM)
	095-2887	[2]	PLATE
2.	132-8520	[1]	FILM-IDENTIFICATION (VIDS, VIMS MAIN MODULE)
3.	8T-4223	[3]	WASHER-HARD (13.5X25.5X3-MM THK)
4.	108-7696	[4]	BAR
5.	112-1757	[1]	COVER AS
	1V-6755	[1]	LATCH AS
	6V-2370	[5]	RIVET-POP
6.	112-1758	[1]	COVER AS
7.	8T-4137 M	[13]	BOLT (M10X1.5X20-MM)
8.	8T-4121	[23]	WASHER-HARD (11X21X2.5-MM THK)
9.	130-5131 Y	[1]	CONTROL GP-UNPRGMED MONITOR
10.	104-5612	[2]	BAR
11.	4L-6454	[4]	BOLT (3/8-16X1-IN)
12.	8T-4896	[4]	WASHER-HARD (10.2X18.5X2.5-MM THK)
13.	8T-9655	[40]	MOUNT-ISOLATION
14.	8T-9658	[12]	SPACER (8.2X12.7X25.4-MM THK)
15.	099-3649 M	[12]	BOLT (M8X1.25X40-MM)
16.	9N-0869	[20]	WASHER-HARD (8.8X25.5X2-MM THK)
17.	144-7172 Y	[2]	MODULE GP-VIDS/VIMS INTERFACE
18.	8T-4136 M	[8]	BOLT (M10X1.5X25-MM)
19.	4P-8134	[2]	CLIP (LADDER)
20.	9X-6772	[5]	STRAP-CABLE
21.	142-3371 CY	[1]	CONTROL GP-UNPROGRAMMED (IMPLEMENT)
22.	6I-1418	[8]	SPACER (8.2X12.7X28.7-MM THK)
23.	7X-0818 M	[8]	BOLT (M8X1.25X45-MM)
24.	142-3363 CY	[1]	CONTROL GP-UNPROGRAMMED (POWER TRAIN)
25.	115-1496	[1]	TUBE
26.	9X-2042 M	[13]	SCREW-TRUSS HEAD (M6X1X12-MM)
27.	8T-4244 M	[3]	NUT (M12X1.75-THD)
28.	3E-5239	[2]	RELAY AS (24-VOLT)
29.	107-3727	[4]	SCREW-PAN HEAD
30.	4B-4274	[10]	WASHER (5.5X13X1.2-MM THK)
31.	4K-5122	[15]	HOLDER AS-FUSE
			(EACH INCLUDES)
	7N-2867	[1]	CAP-FUSE HOLDER
32.	3K-8782	[8]	FUSE (10-AMPERE)
33.	8M-8948	[4]	FUSE (15-AMPERE)
34.	8M-0456	[1]	FUSE (20-AMPERE)
35.	115-1494	[1]	PLATE AS
36.	115-3038	[1]	FILM-IDENTIFICATION (FUSE)
37.	033-8248	[2]	CLIP (LOOP)
38.	8T-4191 M	[2]	BOLT (M10X1.5X16-MM)
39.	124-6704	[1]	RESISTOR AS (ETHER SOLENOID LOAD)
40A.	3T-0376	[1]	SWITCH AS-MAGNETIC (MAIN POWER RELAY)
40B.	3T-0376	[1]	SWITCH AS-MAGNETIC (FLOODLAMP RELAY)
			(EACH INCLUDES)
	4F-2294	[2]	NUT-JAM (5/16-24-THD)
	6V-8186	[2]	NUT-FULL (5/16-24-THD)
	6V-8378	[2]	NUT (10-32-THD)
41.	6B-4540	[4]	NUT (4-40-THD)
42.	6V-9497	[4]	WASHER-HARD (3.2X6X0.5-MM THK)
43.	115-1495	[1]	PLATE
44.	4B-2049	[4]	NUT (10-32-THD)
45.	3E-7294	[2]	CIRCUIT BREAKER AS (105-AMPERE)(ALTERNATOR)
			(EACH INCLUDES)
	1H-3244	[3]	LOCKWASHER
	6V-8365	[2]	SCREW-MACHINE (1/4-28X0.5-IN)
46.	7V-9275	[1]	STRAP
47.	6T-3642	[1]	CIRCUIT BREAKER AS (10-AMPERE)(KEY START)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
48.	6T-3643	[1]	CIRCUIT BREAKER AS (15-AMPERE)(ENGINE ECM)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
49.	3T-2662	[1]	CIRCUIT BREAKER AS (15-AMPERE, AUTOMATIC RESET)(RUNNING LAMPS)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
50.	3D-9799	[6]	SCREW-MACHINE (8-32X0.875-IN)
51.	4B-4863	[6]	WASHER (4.7X11X1.2-MM THK)
52.	115-9346	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
53.	8C-6354	[1]	CAP-RECEPTACLE (ET CONNECTOR)
54.	4B-1237	[4]	SCREW-MACHINE (10-32X12.7-MM)
55.	115-9347	[1]	FILM-IDENTIFICATION (ENGINE SERVICE)
56.	122-8450	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
57.	4B-1240	[4]	SCREW-MACHINE (10-32X1-IN)
58.	114-0931	[1]	FILM-IDENTIFICATION (SERVICE CONNECTOR)
59.	9G-4360	[1]	CAP-CONNECTOR
60.	5S-4245	[4]	SCREW-MACHINE (4-40X0.5-IN)
61.	7I-3652	[1]	STRIP
62.	9X-8256	[3]	WASHER (6.6X12X2-MM THK)
63.	3E-0075 Y	[2]	SWITCH GP-MAGNETIC (24-VOLT)(START RELAY)
64.	5P-4115	[2]	WASHER-HARD (7.2X19X2-MM THK)
65.	5C-2890 M	[2]	NUT (M6X1-THD)
66.	8T-4138 M	[2]	BOLT (M6X1X20-MM)
67.	9G-8451	[1]	BLOCK AS
	1H-3244	[1]	LOCKWASHER
	4B-4276	[2]	WASHER (7X16X1.6-MM THK)
	4L-7124	[1]	BOLT (1/4-20X1.25-IN)
	6V-8185	[2]	NUT (1/4-20-THD)
68.	112-1761	[2]	HARNESS AS-PANEL (FUSE)
69.	112-1760	[1]	WIRE AS
70.	112-1762	[1]	HARNESS AS-PANEL (FUSE)
71.	115-3039	[1]	HARNESS AS
72.	130-7239	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
73.	106-8704	[2]	SUPPRESSOR AS-ARC
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES WEDGE)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
74.	130-7240	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
75.	7K-1181	[15]	STRAP-CABLE
	C		CHANGE FROM PREVIOUS TYPE
	M		METRIC PART
	Y		SEPARATE ILLUSTRATION

168-4358: WIRING GP-ELECTRONICS BAY

WIRING GP-ELECTRONICS BAY

168-4358 WIRING GP-ELECTRONICS BAY -VIDS
S/N 7HR1-UP
PART OF 170-2472, 170-8463 LIFT AR, 131-8153 WIRING GP-MONITOR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	112-1756	[1]	ENCLOSURE AS-ELECTRONICS BAY
2.	8T-4223	[3]	WASHER-HARD (13.5X25.5X3-MM THK)
3.	112-1757	[1]	COVER AS
	1V-6755	[1]	LATCH AS
	6V-2370	[5]	RIVET-POP
4.	112-1758	[1]	COVER AS
5.	8T-4137 M	[13]	BOLT (M10X1.5X20-MM)
6.	8T-4121	[19]	WASHER-HARD (11X21X2.5-MM THK)
7.	160-1758 Y	[1]	CONTROL GP-UNPROGRAMMED (POWER TRAIN)
8.	104-5612	[2]	BAR
9.	4L-6454	[4]	BOLT (3/8-16X1-IN)
10.	8T-4896	[4]	WASHER-HARD (10.2X18.5X2.5-MM THK)
11.	8T-9655	[32]	MOUNT-ISOLATION
12.	8T-9658	[8]	SPACER (8.2X12.7X25.4-MM THK)
13.	099-3649 M	[8]	BOLT (M8X1.25X40-MM)
14.	9N-0869	[16]	WASHER-HARD (8.8X25.5X2-MM THK)
15.	144-7172 Y	[1]	MODULE GP-VIDS/VIMS INTERFACE
16.	8T-4136 M	[4]	BOLT (M10X1.5X25-MM)
17.	4P-8134	[1]	CLIP (LADDER)
18.	9X-6772	[4]	STRAP-CABLE
19.	160-1759 Y	[1]	CONTROL GP-UNPROGRAMMED (IMPLEMENT)
20.	6I-1418	[8]	SPACER (8.2X12.7X28.7-MM THK)
21.	7X-0818 M	[8]	BOLT (M8X1.25X45-MM)
22.	165-8682 Y	[1]	CONTROL GP-UNPRGMED MONITOR (VIDS, VIMS MAIN MODULE)
23.	115-1496	[1]	TUBE
24.	9X-2042 M	[13]	SCREW-TRUSS HEAD (M6X1X12-MM)
25.	8T-4244 M	[3]	NUT (M12X1.75-THD)
26.	3E-5239	[2]	RELAY AS (24-VOLT)
27.	107-3727	[4]	SCREW-PAN HEAD
28.	4B-4274	[10]	WASHER (5.5X13X1.2-MM THK)
29.	4K-5122	[15]	HOLDER AS-FUSE
			(EACH INCLUDES)
	139-0178	[1]	CAP
30.	3K-8782	[8]	FUSE (10-AMPERE)
31.	8M-8948	[4]	FUSE (15-AMPERE)
32.	8M-0456	[1]	FUSE (20-AMPERE)
33.	115-1494	[1]	PLATE AS
34.	115-3038	[1]	FILM-IDENTIFICATION (FUSE)
35.	033-8248	[2]	CLIP (LOOP)
36.	8T-4191 M	[2]	BOLT (M10X1.5X16-MM)
37.	124-6704	[1]	RESISTOR AS (ETHER SOLENOID LOAD)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES WEDGE)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	5P-5623 D		WIRE-ELECTRICAL (16-GA, BLACK)(.4M)
	5P-6008	[1]	TUBE-HEAT SHRINK (6.35-MM DIA)
	8C-3334	[1]	RIVET-TUBULAR
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
38.	165-4026	[2]	SWITCH AS-MAGNETIC (24-VOLT)
			(MAIN & FLOODLAMP RELAYS)
			(EACH INCLUDES)
	4F-2294	[2]	NUT-JAM (5/16-24-THD)
	6V-8186	[2]	NUT-FULL (5/16-24-THD)
	6V-8378	[2]	NUT (10-32-THD)
39.	6B-4540	[4]	NUT (4-40-THD)
40.	6V-9497	[4]	WASHER-HARD (3.2X6X0.5-MM THK)
41.	115-1495	[1]	PLATE
42.	4B-2049	[4]	NUT (10-32-THD)
43.	3E-7294	[2]	CIRCUIT BREAKER AS (105-AMPERE)(ALTERNATOR-MAIN)
			(EACH INCLUDES)
	1H-3244	[2]	LOCKWASHER
	6V-8187	[2]	NUT (1/4-28-THD)
	8T-4205	[2]	WASHER-HARD (7.2X14.5X2-MM THK)
44.	7V-9275	[1]	STRAP
45.	6T-3642	[1]	CIRCUIT BREAKER AS (10-AMPERE)(KEY START)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
46.	6T-3643	[1]	CIRCUIT BREAKER AS (15-AMPERE)(ENGINE ECM)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
47.	3T-2662	[1]	CIRCUIT BREAKER AS (15-AMPERE, AUTOMATIC RESET)(RUNNING LAMPS)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
48.	3D-9799	[6]	SCREW-MACHINE (8-32X0.875-IN)
49.	4B-4863	[6]	WASHER (4.7X11X1.2-MM THK)
50.	115-9346	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
51.	8C-6354	[1]	CAP-RECEPTACLE (ET CONNECTOR)
52.	4B-1237	[4]	SCREW-MACHINE (10-32X12.7-MM)
53.	115-9347	[1]	FILM-IDENTIFICATION (ENGINE SERVICE)
54.	122-8450	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
55.	4B-1240	[4]	SCREW-MACHINE (10-32X1-IN)
56.	114-0931	[1]	FILM-IDENTIFICATION (SERVICE CONNECTOR)
57.	9G-4360	[1]	CAP-CONNECTOR
58.	5S-4245	[4]	SCREW-MACHINE (4-40X0.5-IN)
59.	7I-3652	[1]	STRIP
60.	9X-8256	[3]	WASHER (6.6X12X2-MM THK)
61.	3E-0075 Y	[2]	SWITCH GP-MAGNETIC (24-VOLT)(START RELAYS)
62.	5P-4115	[2]	WASHER-HARD (7.2X19X2-MM THK)
63.	5C-2890 M	[2]	NUT (M6X1-THD)
64.	8T-4138 M	[2]	BOLT (M6X1X20-MM)
65.	9G-8451	[1]	BLOCK AS
	1H-3244	[1]	LOCKWASHER
	4B-4276	[2]	WASHER (7X16X1.6-MM THK)
	4L-7124	[1]	BOLT (1/4-20X1.25-IN)
	6V-8185	[2]	NUT (1/4-20-THD)
66.	112-1761	[2]	HARNESS AS-PANEL (FUSE)
67.	112-1760	[1]	WIRE AS
68.	112-1762	[1]	HARNESS AS-PANEL (FUSE)
69.	168-4357	[1]	HARNESS AS
70.	130-7239	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
71.	106-8704	[2]	SUPPRESSOR AS-ARC
			(EACH INCLUDES)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES WEDGE)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
72.	130-7240	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
73.	7K-1181	[17]	STRAP-CABLE
74.	108-7696	[2]	BAR
75.	132-8520	[1]	FILM-IDENTIFICATION (VIDS, VIMS MAIN MODULE)
	D		ORDER BY THE METER
	M		METRIC PART
	Y		SEPARATE ILLUSTRATION

168-4359: WIRING GP-ELECTRONICS BAY

WIRING GP-ELECTRONICS BAY

168-4359 WIRING GP-ELECTRONICS BAY -VIMS
S/N 7HR284-99999
PART OF 131-8155 VIMS AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	112-1756	[1]	ENCLOSURE AS-ELECTRONICS BAY
	6V-9632 M	[11]	NUT-WELD (M6X1-THD)
	7X-0751 M	[2]	BOSS-WELD (M10X1.5-THD)
	8T-3490 M	[16]	NUT-WELD (M10X1.5-THD)
	8T-3597 M	[15]	NUT-WELD (M12X1.75-THD)
	8T-3635 M	[4]	STUD-WELD (M12X1.75X34.93-MM)
	095-2887	[2]	PLATE
2.	132-8520	[1]	FILM-IDENTIFICATION (VIDS, VIMS MAIN MODULE)
3.	8T-4223	[3]	WASHER-HARD (13.5X25.5X3-MM THK)
4.	108-7696	[4]	BAR
5.	112-1757	[1]	COVER AS
	1V-6755	[1]	LATCH AS
	6V-2370	[5]	RIVET-POP
6.	112-1758	[1]	COVER AS
7.	8T-4137 M	[13]	BOLT (M10X1.5X20-MM)
8.	8T-4121	[23]	WASHER-HARD (11X21X2.5-MM THK)
9.	165-8682 Y	[1]	CONTROL GP-UNPRGMED MONITOR (VIDS, VIMS MAIN MODULE)
10.	104-5612	[2]	BAR
11.	4L-6454	[4]	BOLT (3/8-16X1-IN)
12.	8T-4896	[4]	WASHER-HARD (10.2X18.5X2.5-MM THK)
13.	8T-9655	[40]	MOUNT-ISOLATION
14.	8T-9658	[12]	SPACER (8.2X12.7X25.4-MM THK)
15.	099-3649 M	[12]	BOLT (M8X1.25X40-MM)
16.	9N-0869	[20]	WASHER-HARD (8.8X25.5X2-MM THK)
17.	144-7172 Y	[2]	MODULE GP-VIDS/VIMS INTERFACE
18.	8T-4136 M	[8]	BOLT (M10X1.5X25-MM)
19.	4P-8134	[2]	CLIP (LADDER)
20.	9X-6772	[5]	STRAP-CABLE
21.	160-1759 Y	[1]	CONTROL GP-UNPROGRAMMED (IMPLEMENT)
22.	6I-1418	[8]	SPACER (8.2X12.7X28.7-MM THK)
23.	7X-0818 M	[8]	BOLT (M8X1.25X45-MM)
24.	160-1758 Y	[1]	CONTROL GP-UNPROGRAMMED (POWER TRAIN)
25.	115-1496	[1]	TUBE
26.	9X-2042 M	[13]	SCREW-TRUSS HEAD (M6X1X12-MM)
27.	8T-4244 M	[3]	NUT (M12X1.75-THD)
28.	3E-5239	[2]	RELAY AS (24-VOLT)
29.	107-3727	[4]	SCREW-PAN HEAD
30.	4B-4274	[10]	WASHER (5.5X13X1.2-MM THK)
31.	4K-5122	[15]	HOLDER AS-FUSE
			(EACH INCLUDES)
	7N-2867	[1]	CAP-FUSE HOLDER
32.	3K-8782	[8]	FUSE (10-AMPERE)
33.	8M-8948	[4]	FUSE (15-AMPERE)
34.	8M-0456	[1]	FUSE (20-AMPERE)
35.	115-1494	[1]	PLATE AS
36.	115-3038	[1]	FILM-IDENTIFICATION (FUSE)
37.	033-8248	[2]	CLIP (LOOP)
38.	8T-4191 M	[2]	BOLT (M10X1.5X16-MM)
39.	124-6704	[1]	RESISTOR AS (ETHER SOLENOID LOAD)
40A.	165-4026	[1]	SWITCH AS-MAGNETIC (24-VOLT)(MAIN POWER RELAY)
40B.	165-4026	[1]	SWITCH AS-MAGNETIC (24-VOLT)(FLOODLAMP RELAY)
			(EACH SWITCH INCLUDES)
	4F-2294	[2]	NUT-JAM (5/16-24-THD)
	6V-8186	[2]	NUT-FULL (5/16-24-THD)
	6V-8378	[2]	NUT (10-32-THD)
41.	6B-4540	[4]	NUT (4-40-THD)
42.	6V-9497	[4]	WASHER-HARD (3.2X6X0.5-MM THK)
43.	115-1495	[1]	PLATE
44.	4B-2049	[4]	NUT (10-32-THD)
45.	3E-7294	[1]	CIRCUIT BREAKER AS (105-AMPERE)(MAIN)
	8T-4205	[2]	WASHER-HARD (7.2X14.5X2-MM THK)
	1H-3244	[2]	LOCKWASHER
	6V-8187	[2]	NUT (1/4-28-THD)
45A.	3E-7294	[1]	CIRCUIT BREAKER AS (105-AMPERE)(ALTERNATOR)
	8T-4205	[2]	WASHER-HARD (7.2X14.5X2-MM THK)
	1H-3244	[2]	LOCKWASHER
	6V-8187	[2]	NUT (1/4-28-THD)
46.	7V-9275	[1]	STRAP
47.	6T-3642	[1]	CIRCUIT BREAKER AS (10-AMPERE)(KEY START)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
48.	6T-3643	[1]	CIRCUIT BREAKER AS (15-AMPERE)(ENGINE ECM)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
49.	3T-2662	[1]	CIRCUIT BREAKER AS (15-AMPERE, AUTOMATIC RESET)(RUNNING LAMPS)
	6V-8376	[2]	SCREW-MACHINE (8-32X0.25-IN)
	9B-7233	[2]	LOCKWASHER
50.	3D-9799	[6]	SCREW-MACHINE (8-32X0.875-IN)
51.	4B-4863	[6]	WASHER (4.7X11X1.2-MM THK)
52.	115-9346	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
53.	8C-6354	[1]	CAP-RECEPTACLE (ET CONNECTOR)
54.	4B-1237	[4]	SCREW-MACHINE (10-32X12.7-MM)
55.	115-9347	[1]	FILM-IDENTIFICATION (ENGINE SERVICE)
56.	122-8450	[1]	PLATE-IDENTIFICATION (CIRCUIT BREAKER)
57.	4B-1240	[4]	SCREW-MACHINE (10-32X1-IN)
58.	114-0931	[1]	FILM-IDENTIFICATION (SERVICE CONNECTOR)
59.	9G-4360	[1]	CAP-CONNECTOR
60.	5S-4245	[4]	SCREW-MACHINE (4-40X0.5-IN)
61.	7I-3652	[1]	STRIP
62.	9X-8256	[3]	WASHER (6.6X12X2-MM THK)
63.	3E-0075 Y	[2]	SWITCH GP-MAGNETIC (24-VOLT)(START RELAY)
64.	5P-4115	[2]	WASHER-HARD (7.2X19X2-MM THK)
65.	5C-2890 M	[2]	NUT (M6X1-THD)
66.	8T-4138 M	[2]	BOLT (M6X1X20-MM)
67.	9G-8451	[1]	BLOCK AS
	1H-3244	[1]	LOCKWASHER
	4B-4276	[2]	WASHER (7X16X1.6-MM THK)
	4L-7124	[1]	BOLT (1/4-20X1.25-IN)
	6V-8185	[2]	NUT (1/4-20-THD)
68.	112-1761	[2]	HARNESS AS-PANEL (FUSE)
69.	112-1760	[1]	WIRE AS
70.	112-1762	[1]	HARNESS AS-PANEL (FUSE)
71.	227-0870	[1]	HARNESS AS
	155-2270	[1]	KIT-CONNECTING PLUG (2-PIN)
	155-2274	[1]	KIT-CONNECTING PLUG (6-PIN)
	155-2255	[1]	KIT-CONNECTING PLUG (12-PIN)
	110-6846	[1]	PLUG AS-CONNECTOR (40-PIN)
	3S-2093	[19]	STRAP-CABLE
	3T-0204	[1]	RECEPTACLE AS-CONNECTOR (20-PIN)
	8N-1536	[1]	NUT (1-5/8-18-THD)
	3T-3410	[2]	RECEPTACLE AS-CONNECTOR (37-PIN)
	8N-1522	[1]	NUT (2-1/4-16-THD)
	7K-1181	[26]	STRAP-CABLE
	8N-1513	[2]	RECEPTACLE AS-CONNECTOR (37-PIN)
	8N-1522	[1]	NUT (2-1/4-16-THD)
	8N-1514	[1]	PLUG AS-CONNECTOR (37-PIN)
	8N-1517	[1]	RECEPTACLE AS-CONNECTOR (25-PIN)
	8N-1522	[1]	NUT (2-1/4-16-THD)
	8N-1519	[1]	RECEPTACLE AS-CONNECTOR (12-PIN)
	8N-1522	[1]	NUT (2-1/4-16-THD)
	8T-8737	[131]	PLUG-SEAL
	8T-9834	[2]	PLUG AS-CONNECTOR (40-PIN)
	9W-1951	[1]	RECEPTACLE-CONNECTOR (9-PIN)
	9X-1054	[2]	PLUG AS-CONNECTOR (4-PIN)
	110-6848	[2]	PLUG AS-CONNECTOR (40-PIN)
	115-3082	[2]	JUNCTION BLOCK
	115-3083	[1]	BRACKET-BLOCK CONNECTOR
72.	130-7239	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
73.	106-8704	[2]	SUPPRESSOR AS-ARC
			(EACH INCLUDES)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
74.	130-7240	[1]	HARNESS AS-MONITOR (ARC SUPPRESSOR)
75.	7K-1181	[15]	STRAP-CABLE
	M		METRIC PART
	Y		SEPARATE ILLUSTRATION

112-6045: WIRING GP-ENGINE

WIRING GP-ENGINE

112-6045 WIRING GP-ENGINE
S/N 2GR1-1297
PART OF 107-8762 ENGINE AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	124-0289	[2]	CLIP
2.	0S-0509	[15]	BOLT (3/8-16X0.75-IN)
3.	5M-2894	[29]	WASHER-HARD (10.2X18.5X2.5-MM THK)
4.	9S-8752	[5]	NUT-FULL (3/8-16-THD)
5.	4P-8134	[36]	CLIP (LADDER)
6.	9X-6772	[67]	STRAP-CABLE
7.	9N-1909	[1]	BRACKET
8.	109-4367 Y	[2]	SENSOR GP-EXHAUST TEMPERATURE (LH/RH TURBO)
9.	8L-2786	[1]	SEAL-O-RING
10.	127-1008 Y	[1]	SENSOR GP-SPEED (ENGINE SPEED TIMING)
11.	5P-8245	[2]	WASHER-HARD (13.5X25.5X3-MM THK)
12.	0S-1620	[1]	BOLT (1/2-13X0.75-IN)
13.	3K-6905	[1]	VALVE-BREATHER
14.	6V-5048	[12]	SEAL-O-RING
15.	9X-0263	[1]	ADAPTER
16A.	103-6093 Y	[1]	SENSOR GP-PRESSURE (CRANKCASE)
16B.	103-6093 Y	[1]	SENSOR GP-PRESSURE (ATMOSPHERE)
16C.	103-6093 Y	[1]	SENSOR GP-PRESSURE (RH TURBO INLET)
16D.	103-6093 Y	[1]	SENSOR GP-PRESSURE (LH TURBO INLET)
17.	0S-1594	[3]	BOLT (3/8-16X1-IN)
18.	9L-9132	[2]	WASHER (10.2X25.5X2.5-MM THK)
19.	6V-1889	[1]	CLIP (LOOP)
20.	7N-2256	[1]	PLATE
21.	6H-1717	[1]	BOLT (1/2-13X1.125-IN)
22.	6W-6672	[2]	SPACER (10.5X20X38-MM THK)
23.	117-0067	[1]	ELBOW
24.	4P-7581	[12]	CLIP (LADDER)
25.	120-4351	[1]	PLATE
26.	7E-6016	[1]	GASKET
27.	7E-5326	[1]	COVER
28.	8T-6767	[2]	PLUG-PIPE (3/8-18-THD)
29.	3K-0360	[1]	SEAL-O-RING
30.	102-2240	[1]	SENSOR GP-TEMPERATURE (3-PIN)(COOLANT)
	3E-3371	[1]	WEDGE-RECEPTACLE LOCK (3-PIN)
	8T-8729	[3]	PIN-CONNECTOR (16-GA TO 18-GA)
	9X-1813 E		SLEEVE (31CM)
31.	7W-6492	[1]	PLUG-PIPE (1/2-14-THD)
32.	4P-7428	[3]	CLIP (LADDER)
33.	3H-7654	[8]	WASHER-HARD (13.5X22.5X3-MM THK)
34.	0S-1621	[2]	BOLT (1/2-13X1-IN)
35.	1F-7958	[2]	NUT-FULL (1/2-13-THD)
36.	5V-6949	[1]	STRIP
37.	2A-1531	[3]	BOLT (1/2-13X6.5-IN)
38.	117-0069	[1]	BLOCK-SENSOR MOUNTING
39.	9X-0262	[3]	ADAPTER
40.	103-6091	[1]	SENSOR GP-PRESSURE (TURBO OUTLET)
	3E-3368	[1]	WEDGE-PLUG LOCK (3-PIN)
	8T-8730	[3]	SOCKET-CONNECTOR (16-GA TO 18-GA)
	9X-1813 E		SLEEVE (34CM)
41.	8D-9059	[1]	BRACKET
42.	114-5333	[1]	SWITCH AS-PRESSURE (HIGH LOW)(REFRIGERANT)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
43.	9U-2277	[5]	CLIP AS
44.	8M-2771	[1]	CLIP
45.	4P-7429	[2]	CLIP (LADDER)
46.	0S-1588	[5]	BOLT (3/8-16X1.25-IN)
47.	0T-0102	[2]	BOLT (3/8-16X0.625-IN)
48.	121-5729	[1]	ELBOW
49.	117-0068 I	[1]	HOSE AS
50.	030-7946	[1]	ELBOW
51.	4N-3841	[1]	GASKET
52.	138-3672 Y	[1]	SWITCH GP-FLOW (COOLANT)
53.	9M-1974	[2]	WASHER-HARD (8.8X16X2-MM THK)
54.	2B-2695	[2]	BOLT (5/16-18X0.875-IN)
55.	6T-2723	[1]	BRACKET
56.	4E-0718	[1]	WIRE AS
57.	2H-3855	[1]	BOLT (1/2-13X0.875-IN)
58.	4B-4281	[1]	WASHER (16.8X33X2.5-MM THK)
59.	6V-2455	[1]	SENSOR GP-SPEED (ENGINE)
60.	9X-0435	[1]	ADAPTER
61.	103-6092 Y	[1]	SENSOR GP-PRESSURE (ENGINE OIL)
62.	0S-1619	[2]	BOLT (3/8-16X3-IN)
63.	6K-8179	[1]	CLIP
64.	112-6046	[1]	HARNESS AS-WIRING
	E		ORDER BY THE CENTIMETER
	I		REFER TO HYDRAULIC INFORMATION SYSTEM
	Y		SEPARATE ILLUSTRATION

112-6045: WIRING GP-ENGINE

WIRING GP-ENGINE

112-6045 WIRING GP-ENGINE
S/N 2GR1298-1716
PART OF 107-8762 ENGINE AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	124-0289	[2]	CLIP
2.	0S-0509	[16]	BOLT (3/8-16X0.75-IN)
3.	5M-2894	[32]	WASHER-HARD (10.2X18.5X2.5-MM THK)
4.	9S-8752	[5]	NUT-FULL (3/8-16-THD)
5.	4P-8134	[43]	CLIP (LADDER)
6.	9X-6772	[92]	STRAP-CABLE
7.	9N-1909	[1]	BRACKET
8.	109-4367 Y	[2]	SENSOR GP-EXHAUST TEMPERATURE (LH / RH TURBO)
9.	8L-2786	[1]	SEAL-O-RING
10.	129-6628 Y	[1]	SENSOR GP-SPEED (ENGINE SPEED/TIMING)
11.	5P-8245	[2]	WASHER-HARD (13.5X25.5X3-MM THK)
12.	153-7485	[1]	WIRE AS-GROUND
13.	3K-6905	[1]	VALVE-BREATHER
14.	6V-5048	[12]	SEAL-O-RING
15.	9X-0263	[1]	ADAPTER
16.	143-9696 Y	[2]	SENSOR GP-PRESSURE (RH/LH TURBO INLET)
17.	0S-1594	[5]	BOLT (3/8-16X1-IN)
18.	9L-9132	[2]	WASHER (10.2X25.5X2.5-MM THK)
19.	6V-1889	[1]	CLIP (LOOP)
20.	7N-2256	[1]	PLATE
21.	6H-1717	[1]	BOLT (1/2-13X1.125-IN)
22.	6W-6672	[2]	SPACER (10.5X20X38-MM THK)
23.	117-0067	[1]	ELBOW
24.	4P-7581	[16]	CLIP (LADDER)
25.	120-4351	[2]	PLATE
26.	7E-6016	[1]	GASKET
27.	7E-5326	[1]	COVER
28.	8T-6767	[2]	PLUG-PIPE (3/8-18-THD)
29.	3K-0360	[1]	SEAL-O-RING
30.	102-2240	[1]	SENSOR GP-TEMPERATURE (3-PIN)(COOLANT)
31.	7W-6492	[1]	PLUG-PIPE (1/2-14-THD)
32.	4P-7428	[5]	CLIP (LADDER)
33.	3H-7654	[8]	WASHER-HARD (13.5X22.5X3-MM THK)
34.	0S-1621	[2]	BOLT (1/2-13X1-IN)
35.	1F-7958	[2]	NUT-FULL (1/2-13-THD)
36.	5V-6949	[1]	STRIP
37.	2A-1531	[4]	BOLT (1/2-13X6.5-IN)
38.	117-0069	[1]	BLOCK-SENSOR MOUNTING
39.	9X-0262	[3]	ADAPTER
40.	143-9694 Y	[1]	SENSOR GP-PRESSURE (TURBO OUTLET)
41.	8D-9059	[1]	BRACKET
42.	114-5333	[1]	SWITCH AS-PRESSURE (HIGH LOW)(REFRIGERANT)
43.	9U-2277	[2]	CLIP AS
44.	8M-2771	[1]	CLIP
45.	4P-7429	[5]	CLIP (LADDER)
46.	0S-1588	[5]	BOLT (3/8-16X1.25-IN)
47.	0T-0102	[2]	BOLT (3/8-16X0.625-IN)
48.	121-5729	[1]	ELBOW
49.	117-0068 I	[1]	HOSE AS
50.	030-7946	[1]	ELBOW
51.	4N-3841	[1]	GASKET
52.	138-3672 Y	[1]	SWITCH GP-FLOW (COOLANT)
53.	9M-1974	[2]	WASHER-HARD (8.8X16X2-MM THK)
54.	2B-2695	[2]	BOLT (5/16-18X0.875-IN)
55.	6T-2723	[1]	BRACKET
56.	1B-9575	[1]	BOLT (5/16-18X1.56-IN)
57.	2H-3855	[1]	BOLT (1/2-13X0.875-IN)
58.	4B-4281	[1]	WASHER (16.8X33X2.5-MM THK)
59.	6V-2455	[1]	SENSOR GP-SPEED (ENGINE)
60.	9X-0435	[1]	ADAPTER
61.	143-9695 Y	[1]	SENSOR GP-PRESSURE (ENGINE OIL)
62.	0S-1619	[2]	BOLT (3/8-16X3-IN)
63.	3E-4352	[1]	WASHER-HARD (8.8X20.5X2.5-MM THK)
64.	152-0996	[1]	HARNESS AS-WIRING
65.	0S-1620	[1]	BOLT (1/2-13X0.75-IN)
66.	143-9696 Y	[1]	SENSOR GP-PRESSURE (CRANKCASE)
67.	143-9696 Y	[1]	SENSOR GP-PRESSURE (ATMOSPHERE)
	I		REFER TO HYDRAULIC INFORMATION SYSTEM
	Y		SEPARATE ILLUSTRATION

112-6045: WIRING GP-ENGINE

WIRING GP-ENGINE

112-6045 WIRING GP-ENGINE
S/N 2GR1717-1880
PART OF 107-8762 ENGINE AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	124-0289	[2]	CLIP
2.	0S-0509	[16]	BOLT (3/8-16X0.75-IN)
3.	5M-2894	[33]	WASHER-HARD (10.2X18.5X2.5-MM THK)
4.	9S-8752	[4]	NUT-FULL (3/8-16-THD)
5.	4P-8134	[44]	CLIP (LADDER)
6.	9X-6772	[93]	STRAP-CABLE
7.	1A-5183	[1]	BOLT (3/8-16X4.75-IN)
8.	163-7882 Y	[2]	SENSOR GP-EXHAUST TEMPERATURE (LH/RH TURBO)
9.	8L-2786	[1]	SEAL-O-RING
10.	129-6628 Y	[1]	SENSOR GP-SPEED (ENGINE TIMING)
11.	5P-8245	[2]	WASHER-HARD (13.5X25.5X3-MM THK)
12.	153-7485	[1]	WIRE AS-GROUND
13.	3K-6905	[1]	VALVE-BREATHER
14.	6V-5048	[12]	SEAL-O-RING
15.	9X-0263	[1]	ADAPTER
16.	143-9696 Y	[2]	SENSOR GP-PRESSURE (RH/LH TURBO INLET)
17.	0S-1594	[6]	BOLT (3/8-16X1-IN)
18.	9L-9132	[2]	WASHER (10.2X25.5X2.5-MM THK)
19.	6V-1889	[1]	CLIP (LOOP)
20.	7N-2256	[1]	PLATE
21.	6H-1717	[1]	BOLT (1/2-13X1.125-IN)
22.	6W-6672	[2]	SPACER (10.5X20X38-MM THK)
23.	117-0067	[1]	ELBOW
24.	4P-7581	[16]	CLIP (LADDER)
25.	120-4351	[2]	PLATE
26.	7E-6016	[1]	GASKET
27.	7E-5326	[1]	COVER
28.	8T-6767	[2]	PLUG-PIPE (3/8-18-THD)
29.	3K-0360	[1]	SEAL-O-RING
30.	102-2240 Y	[1]	SENSOR GP-TEMPERATURE (3-PIN)(COOLANT)
31.	7W-6492	[1]	PLUG-PIPE (1/2-14-THD)
32.	4P-7428	[5]	CLIP (LADDER)
33.	3H-7654	[8]	WASHER-HARD (13.5X22.5X3-MM THK)
34.	0S-1621	[2]	BOLT (1/2-13X1-IN)
35.	1F-7958	[2]	NUT-FULL (1/2-13-THD)
36.	5V-6949	[1]	STRIP
37.	2A-1531	[4]	BOLT (1/2-13X6.5-IN)
38.	117-0069	[1]	BLOCK-SENSOR MOUNTING
39.	9X-0262	[3]	ADAPTER
40.	143-9694 Y	[1]	SENSOR GP-PRESSURE (TURBOCHARGER OUTLET)
41.	8D-9059	[1]	BRACKET
42.	114-5333	[1]	SWITCH AS-PRESSURE (HIGH LOW)(REFRIGERANT COMPRESSOR)
43.	9U-2277	[2]	CLIP AS
44.	8M-2771	[1]	CLIP
45.	4P-7429	[5]	CLIP (LADDER)
46.	0S-1588	[5]	BOLT (3/8-16X1.25-IN)
47.	0T-0102	[2]	BOLT (3/8-16X0.625-IN)
48.	121-5729	[1]	ELBOW
49.	117-0068 I	[1]	HOSE AS
50.	030-7946	[1]	ELBOW
51.	4N-3841	[1]	GASKET
52.	138-3672 Y	[1]	SWITCH GP-FLOW (COOLANT)
53.	9M-1974	[2]	WASHER-HARD (8.8X16X2-MM THK)
54.	2B-2695	[2]	BOLT (5/16-18X0.875-IN)
55.	6T-2723	[1]	BRACKET
57.	2H-3855	[1]	BOLT (1/2-13X0.875-IN)
58.	4B-4281	[1]	WASHER (16.8X33X2.5-MM THK)
59.	6V-2455	[1]	SENSOR GP-SPEED (ENGINE)
60.	9X-0435	[1]	ADAPTER
61.	143-9695 Y	[1]	SENSOR GP-PRESSURE (ENGINE OIL)
62.	0S-1619	[2]	BOLT (3/8-16X3-IN)
64.	152-0996	[1]	HARNESS AS-WIRING
65.	0S-1620	[1]	BOLT (1/2-13X0.75-IN)
66.	143-9696 Y	[1]	SENSOR GP-PRESSURE (CRANKCASE)
67.	143-9696 Y	[1]	SENSOR GP-PRESSURE (ATMOSPHERIC AIR)
	I		REFER TO HYDRAULIC INFORMATION SYSTEM
	Y		SEPARATE ILLUSTRATION

112-6045: WIRING GP-ENGINE

WIRING GP-ENGINE

112-6045 WIRING GP-ENGINE
S/N 2GR1881-2333
PART OF 107-8762 ENGINE AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	124-0289	[2]	CLIP
2.	0S-0509	[16]	BOLT (3/8-16X0.75-IN)
3.	5M-2894	[34]	WASHER-HARD (10.2X18.5X2.5-MM THK)
4.	9S-8752	[4]	NUT-FULL (3/8-16-THD)
5.	4P-8134	[49]	CLIP (LADDER)
6.	9X-6772	[98]	STRAP-CABLE
7.	163-7882 Y	[2]	SENSOR GP-EXHAUST TEMPERATURE (LH/RH TURBO)
8.	161-9929 Y	[1]	SENSOR GP-PRESSURE (TURBO OUTLET)
9.	8L-2786	[1]	SEAL-O-RING
10.	129-6628 Y	[1]	SENSOR GP-SPEED (ENGINE TIMING)
11.	5P-8245	[2]	WASHER-HARD (13.5X25.5X3-MM THK)
12.	153-7485	[1]	WIRE AS-GROUND
13.	3K-6905	[1]	VALVE-BREATHER
14.	6V-5048	[12]	SEAL-O-RING
15.	9X-0263	[1]	ADAPTER
16.	161-9926 Y	[2]	SENSOR GP-PRESSURE (TURBOCHARGER INLET)
16A.	161-9926 Y	[1]	SENSOR GP-PRESSURE (ATMOSPHERIC AIR)
16B.	161-9926 Y	[1]	SENSOR GP-PRESSURE (CRANKCASE)
17.	0S-1594	[5]	BOLT (3/8-16X1-IN)
18.	9L-9132	[2]	WASHER (10.2X25.5X2.5-MM THK)
19.	6V-1889	[1]	CLIP (LOOP)
20.	7N-2256	[1]	PLATE
21.	6H-1717	[1]	BOLT (1/2-13X1.125-IN)
22.	6W-6672	[2]	SPACER (10.5X20X38-MM THK)
23.	117-0067	[1]	ELBOW
24.	4P-7581	[16]	CLIP (LADDER)
25.	120-4351	[2]	PLATE
26.	7E-6016	[1]	GASKET
27.	7E-5326	[1]	COVER
28.	8T-6767	[2]	PLUG-PIPE (3/8-18-THD)
29.	3K-0360	[1]	SEAL-O-RING
30.	102-2240 Y	[1]	SENSOR GP-TEMPERATURE (3-PIN)(COOLANT)
31.	7W-6492	[1]	PLUG-PIPE (1/2-14-THD)
32.	4P-7428	[5]	CLIP (LADDER)
33.	3H-7654	[8]	WASHER-HARD (13.5X22.5X3-MM THK)
34.	0S-1621	[2]	BOLT (1/2-13X1-IN)
35.	1F-7958	[2]	NUT-FULL (1/2-13-THD)
36.	167-9579	[1]	STRIP
37.	2A-1531	[4]	BOLT (1/2-13X6.5-IN)
38.	117-0069	[1]	BLOCK-SENSOR MOUNTING
39.	9X-0262	[3]	ADAPTER
40.	161-9931 Y	[1]	SENSOR GP-PRESSURE (ENGINE OIL)
41.	8D-9059	[1]	BRACKET
42.	114-5333	[1]	SWITCH AS-PRESSURE (HIGH LOW)(REFRIGERANT COMPRESSOR)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES WEDGE)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
43.	9U-2277	[2]	CLIP AS
44.	8M-2771	[1]	CLIP
45.	4P-7429	[5]	CLIP (LADDER)
46.	0S-1588	[5]	BOLT (3/8-16X1.25-IN)
47.	0T-0102	[2]	BOLT (3/8-16X0.625-IN)
48.	121-5729	[1]	ELBOW
49.	117-0068 I	[1]	HOSE AS
50.	030-7946	[1]	ELBOW
51.	4N-3841	[1]	GASKET
52.	138-3672 Y	[1]	SWITCH GP-FLOW (COOLANT)
53.	9M-1974	[2]	WASHER-HARD (8.8X16X2-MM THK)
54.	2B-2695	[2]	BOLT (5/16-18X0.875-IN)
55.	6T-2723	[1]	BRACKET
56.	7E-4227	[1]	CAP
57.	2H-3855	[1]	BOLT (1/2-13X0.875-IN)
58.	4B-4281	[1]	WASHER (16.8X33X2.5-MM THK)
59.	6V-2455	[1]	SENSOR GP-SPEED (TIMING CALIBRATION)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
	9X-1386 E		SLEEVE (14CM)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES WEDGE)
60.	9X-0435	[1]	ADAPTER
61.	1A-2029	[2]	BOLT (3/8-16X1.125-IN)
62.	0S-1619	[2]	BOLT (3/8-16X3-IN)
64.	152-0996	[1]	HARNESS AS-WIRING
65.	0S-1620	[1]	BOLT (1/2-13X0.75-IN)
66.	1A-5183	[1]	BOLT (3/8-16X4.75-IN)
	E		ORDER BY THE CENTIMETER
	I		REFER TO HYDRAULIC INFORMATION SYSTEM
	Y		SEPARATE ILLUSTRATION

112-6045: WIRING GP-ENGINE

WIRING GP-ENGINE

112-6045 WIRING GP-ENGINE
S/N 2GR2334-3435
PART OF 107-8762 ENGINE AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	124-0289	[2]	CLIP
2.	0S-0509	[16]	BOLT (3/8-16X0.75-IN)
3.	5M-2894	[34]	WASHER-HARD (10.2X18.5X2.5-MM THK)
4.	9S-8752	[4]	NUT-FULL (3/8-16-THD)
5.	4P-8134	[49]	CLIP (LADDER)
6.	9X-6772	[98]	STRAP-CABLE
7.	163-7882 Y	[1]	SENSOR GP-EXHAUST TEMPERATURE (TURBOCHARGER, RH)
7A.	163-7882 Y	[1]	SENSOR GP-EXHAUST TEMPERATURE (TURBOCHARGER, LH)
8.	161-9929 Y	[1]	SENSOR GP-PRESSURE (TURBOCHARGER OUTLET)
9.	8L-2786	[1]	SEAL-O-RING
10.	129-6628 Y	[1]	SENSOR GP-SPEED (ENGINE SPEED/TIMING)
11.	5P-8245	[2]	WASHER-HARD (13.5X25.5X3-MM THK)
12.	153-7485	[1]	WIRE AS-GROUND
13.	3K-6905	[1]	VALVE-BREATHER
14.	6V-5048	[12]	SEAL-O-RING
15.	9X-0263	[1]	ADAPTER
16.	161-9926 Y	[1]	SENSOR GP-PRESSURE (TURBOCHARGER INLET, RH)
16A.	161-9926 Y	[1]	SENSOR GP-PRESSURE (TURBOCHARGER INLET, LH)
16B.	161-9926 Y	[1]	SENSOR GP-PRESSURE (ATMOSPHERIC AIR)
16C.	161-9926 Y	[1]	SENSOR GP-PRESSURE (CRANKCASE)
17.	0S-1594	[5]	BOLT (3/8-16X1-IN)
18.	9L-9132	[2]	WASHER (10.2X25.5X2.5-MM THK)
19.	6V-1889	[1]	CLIP (LOOP)
20.	7N-2256	[1]	PLATE
21.	6H-1717	[1]	BOLT (1/2-13X1.125-IN)
22.	6W-6672	[2]	SPACER (10.5X20X38-MM THK)
23.	117-0067	[1]	ELBOW
24.	4P-7581	[16]	CLIP (LADDER)
25.	120-4351	[2]	PLATE
26.	7E-6016	[1]	GASKET
27.	7E-5326	[1]	COVER
28.	8T-6767	[2]	PLUG-PIPE (3/8-18-THD)
29.	3K-0360	[1]	SEAL-O-RING
30.	102-2240 Y	[1]	SENSOR GP-TEMPERATURE (3-PIN)(COOLANT)
31.	7W-6492	[1]	PLUG-PIPE (1/2-14-THD)
32.	4P-7428	[5]	CLIP (LADDER)
33.	3H-7654	[8]	WASHER-HARD (13.5X22.5X3-MM THK)
34.	0S-1621	[2]	BOLT (1/2-13X1-IN)
35.	1F-7958	[2]	NUT-FULL (1/2-13-THD)
36.	167-9579	[1]	STRIP
37.	2A-1531	[4]	BOLT (1/2-13X6.5-IN)
38.	117-0069	[1]	BLOCK-SENSOR MOUNTING
39.	9X-0262	[3]	ADAPTER
40.	161-9931 Y	[1]	SENSOR GP-PRESSURE (ENGINE OIL)
41.	8D-9059	[1]	BRACKET
42.	114-5333	[1]	SWITCH AS-PRESSURE (HIGH LOW)(REFRIGERANT COMPRESSOR)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES RECEPTACLE AS & WEDGE)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
43.	9U-2277	[2]	CLIP AS
44.	8M-2771	[1]	CLIP
45.	4P-7429	[5]	CLIP (LADDER)
46.	0S-1588	[5]	BOLT (3/8-16X1.25-IN)
47.	0T-0102	[2]	BOLT (3/8-16X0.625-IN)
48.	121-5729	[1]	ELBOW
49.	117-0068 I	[1]	HOSE AS
50.	030-7946	[1]	ELBOW
51.	4N-3841	[1]	GASKET
52.	183-3862 CY	[1]	SWITCH GP-FLOW (COOLANT)
53.	9M-1974	[2]	WASHER-HARD (8.8X16X2-MM THK)
54.	2B-2695	[2]	BOLT (5/16-18X0.875-IN)
55.	6T-2723	[1]	BRACKET
56.	7E-4227	[1]	CAP
57.	2H-3855	[1]	BOLT (1/2-13X0.875-IN)
58.	4B-4281	[1]	WASHER (16.8X33X2.5-MM THK)
59.	6V-2455	[1]	SENSOR GP-SPEED (TIMING CALIBRATION)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
	8T-8729	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
	9X-1386 E		SLEEVE (14CM)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES RECEPTACLE AS & WEDGE)
60.	9X-0435	[1]	ADAPTER
61.	1A-2029	[2]	BOLT (3/8-16X1.125-IN)
62.	0S-1619	[2]	BOLT (3/8-16X3-IN)
64.	152-0996	[1]	HARNESS AS-WIRING
65.	0S-1620	[1]	BOLT (1/2-13X0.75-IN)
66.	1A-5183	[1]	BOLT (3/8-16X4.75-IN)
	C		CHANGE FROM PREVIOUS TYPE
	E		ORDER BY THE CENTIMETER
	I		REFER TO HYDRAULIC INFORMATION SYSTEM
	Y		SEPARATE ILLUSTRATION

112-6045: WIRING GP-ENGINE

WIRING GP-ENGINE

112-6045 WIRING GP-ENGINE
S/N 2GR3436-7323
PART OF 107-8762 ENGINE AR

Parts for your 992G WHEEL LOADER:

CATERPILLAR SIS

Pos.	Part No	Qty	Parts name
1.	3A-3692 C	[2]	CLIP
2.	0S-0509 C	[19]	BOLT (3/8-16X0.75-IN)
3.	5M-2894 C	[40]	WASHER-HARD (10.2X18.5X2.5-MM THK)
4.	9S-8752 C	[7]	NUT-FULL (3/8-16-THD)
5.	4P-8134 C	[46]	CLIP (LADDER)
6.	9X-6772 C	[93]	STRAP-CABLE
7.	163-7882 Y	[1]	SENSOR GP-EXHAUST TEMPERATURE (TURBOCHARGER, RH)
7A.	163-7882 Y	[1]	SENSOR GP-EXHAUST TEMPERATURE (TURBOCHARGER, LH)
8.	194-6724 CY	[1]	SENSOR GP-PRESSURE (TURBOCHARGER OUTLET)
9.	8L-2786	[1]	SEAL-O-RING
10.	129-6628 Y	[1]	SENSOR GP-SPEED (ENGINE/TIMING)
11.	5P-8245	[2]	WASHER-HARD (13.5X25.5X3-MM THK)
12.	153-7485	[1]	WIRE AS-GROUND
13.	3K-6905	[1]	VALVE-BREATHER
14.	6V-5048	[12]	SEAL-O-RING
15.	9X-0263	[1]	ADAPTER
16.	161-9926 Y	[1]	SENSOR GP-PRESSURE (TURBOCHARGER INLET, RH)
16A.	161-9926 Y	[1]	SENSOR GP-PRESSURE (TURBOCHARGER INLET, LH)
16B.	161-9926 Y	[1]	SENSOR GP-PRESSURE (ATMOSPHERIC AIR)
16C.	161-9926 Y	[1]	SENSOR GP-PRESSURE (CRANKCASE)
17.	0S-1594 C	[6]	BOLT (3/8-16X1-IN)
18.	9L-9132	[2]	WASHER (10.2X25.5X2.5-MM THK)
19.	6V-1889	[1]	CLIP (LOOP)
20.	7N-2256	[1]	PLATE
21.	6H-1717	[1]	BOLT (1/2-13X1.125-IN)
22.	6W-6672 C	[1]	SPACER (10.5X20X38-MM THK)
23.	117-0067	[1]	ELBOW
24.	4P-7581 C	[17]	CLIP (LADDER)
25.	120-4351 C	[1]	PLATE
26.	7E-6016	[1]	GASKET
27.	7E-5326	[1]	COVER
28.	8T-6767	[2]	PLUG-PIPE (3/8-18-THD)
29.	3K-0360	[1]	SEAL-O-RING
30.	102-2240 Y	[1]	SENSOR GP-TEMPERATURE (3-PIN)(COOLANT)
31.	7W-6492	[1]	PLUG-PIPE (1/2-14-THD)
32.	4P-7428 C	[3]	CLIP (LADDER)
33.	3H-7654 C	[6]	WASHER-HARD (13.5X22.5X3-MM THK)
34.	0S-1621 C	[1]	BOLT (1/2-13X1-IN)
35.	1F-7958 C	[1]	NUT-FULL (1/2-13-THD)
36.	167-9579	[1]	STRIP
37.	2A-1531 C	[3]	BOLT (1/2-13X6.5-IN)
38.	117-0069	[1]	BLOCK-SENSOR MOUNTING
39.	9X-0262	[3]	ADAPTER
40.	194-6725 CY	[1]	SENSOR GP-PRESSURE (ENGINE OIL)
41.	6B-5072	[1]	ADAPTER
42.	114-5333	[1]	SWITCH AS-PRESSURE (HIGH LOW)(REFRIGERANT COMPRESSOR)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES RECEPTACLE AS & WEDGE)
	186-3735	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
	3E-3365	[1]	WEDGE-RECEPTACLE LOCK (2-PIN)
43.	115-3069 C	[2]	CLIP AS-CONNECTING (3-PIN)
44.	8M-2771 C	[2]	CLIP
45.	4P-7429 C	[1]	CLIP (LADDER)
46.	0S-1588 C	[6]	BOLT (3/8-16X1.25-IN)
47.	0T-0102	[2]	BOLT (3/8-16X0.625-IN)
48.	121-5729	[1]	ELBOW
49.	117-0068 I	[1]	HOSE AS
50.	030-7946	[1]	ELBOW
51.	4N-3841	[1]	GASKET
52.	183-3862 Y	[1]	SWITCH GP-FLOW (COOLANT)
53.	9M-1974	[2]	WASHER-HARD (8.8X16X2-MM THK)
54.	2B-2695	[2]	BOLT (5/16-18X0.875-IN)
55.	6T-2723 C	[2]	BRACKET
56.	7E-4227	[1]	CAP
57.	2H-3855	[1]	BOLT (1/2-13X0.875-IN)
58.	4B-4281	[1]	WASHER (16.8X33X2.5-MM THK)
59.	189-5746 CY	[1]	SENSOR GP-SPEED (TIMING CALIBRATION)
60.	9X-0435	[1]	ADAPTER
61.	1A-2029 C	[1]	BOLT (3/8-16X1.125-IN)
62.	0S-1619 C	[1]	BOLT (3/8-16X3-IN)
63.	161-1546 C	[1]	HARNESS AS-WIRING (ENGINE)
	3T-3454	[1]	BELL-END
	8N-1521	[2]	BELL AS-END
	112-3587	[2]	BOOT (40-PIN)
	8T-8827	[1]	BOOT (RED)
	3T-3622	[1]	CLAMP
	155-2270	[17]	KIT-CONNECTING PLUG (2-PIN)
	155-2260	[4]	KIT-CONNECTING PLUG (3-PIN)
			(EACH INCLUDES PLUG AS & WEDGE)
	102-8802	[2]	KIT-RECEPTACLE (2-PIN)
	102-8803	[7]	KIT-RECEPTACLE (3-PIN)
			(EACH INCLUDES RECEPTACLE AS & WEDGE)
	9G-3695	[29]	PLUG-SEAL
	101-0205	[1]	PLUG AS-CONNECTOR (40-PIN)(40-PIN)
	8N-1518	[1]	PLUG AS-CONNECTOR (25-PIN)
	8N-1514	[1]	PLUG AS-CONNECTOR (37-PIN)
	101-0204	[1]	PLUG AS-CONNECTOR (40-PIN)
	7G-7920	[1]	PLUG-SEAL
	7G-7918	[2]	PLUG-SEAL
	7G-7917	[16]	PLUG-SEAL
	3T-0204	[1]	RECEPTACLE AS-CONNECTOR (20-PIN)
	3E-7842	[2]	RESISTOR AS (START RELAY)
	102-8802	[1]	KIT-RECEPTACLE (2-PIN)
			(INCLUDES RECEPTACLE AS & WEDGE)
	6T-3610	[1]	RESISTOR
	186-3735	[2]	PIN-CONNECTOR (16-GA TO 18-GA)
	8L-8413	[1]	STRAP-CABLE (WHITE)
	106-8704	[1]	SUPPRESSOR AS-ARC
65.	0S-1620	[1]	BOLT (1/2-13X0.75-IN)
66.	1A-5183	[1]	BOLT (3/8-16X4.75-IN)
67.	1D-4597	[2]	BOLT (5/8-11X6.5-IN)
68.	9H-8260	[2]	BOLT (1/2-13X6.25-IN)
	C		CHANGE FROM PREVIOUS TYPE
	I		REFER TO HYDRAULIC INFORMATION SYSTEM
	Y		SEPARATE ILLUSTRATION

Information:

ELECTRICAL AND STARTING SYSTEM

WIRING GP

Engine News

270-5051 Repair Kit (Electrical Connectors) Available for Repairs to Wiring Harnesses with Ampseal 16 and A4E 2 Connectors {0709, 1408}
2006/03/20

Bulk Wiring Harnesses Are Available for Use with Caterpillar Products {1408}
2010/05/13

Special Instruction

Cross-Reference for Electrical Connectors {7553}
Cross-Reference for Electrical Connectors {7553}

Circuit Breaker Harness Assembly {1420}
Circuit Breaker Harness Assembly {1420}

Service Of Machined Terminals And Service of Stamped and Formed Terminals{7553}
Service Of Machined Terminals And Service of Stamped and Formed Terminals{7553}

Installation and Operation of the Exhaust Monitor Used in All Diesel Particulate Filter (DPF) Retrofit Emissions Applications{1091, 1408, 7490, 7498}
Installation and Operation of the Exhaust Monitor Used in All Diesel Particulate Filter (DPF) Retrofit Emissions Applications{1091, 1408, 7490, 7498}

Technical Information Bulletin

Improper Installation of the 274-6717 Crankcase Pressure Sensor on 3500 Commercial Engines{1408, 1439, 1916}
Improper Installation of the 274-6717 Crankcase Pressure Sensor on 3500 Commercial Engines{1408, 1439, 1916}

Tool Operating Manual

Using the 362-3555 Connector Repair Kit to Service Harnesses with Ampseal 16 Connectors{0685, 1408}
Using the 362-3555 Connector Repair Kit to Service Harnesses with Ampseal 16 Connectors{0685, 1408}

Using the U5MK1110 Ampseal Connector Kit for Wiring Harness Repairs on Perkins Engines{7553}
Using the U5MK1110 Ampseal Connector Kit for Wiring Harness Repairs on Perkins Engines{7553}

Using the U5MK1110 Ampseal Connector Kit for Wiring Harness Repairs on Perkins Engines{0374, 0599, 0701, 0709}
Using the U5MK1110 Ampseal Connector Kit for Wiring Harness Repairs on Perkins Engines{0374, 0599, 0701, 0709}

Using the 453-3204 Pressure and Temperature Test Group{0374, 0599, 0706, 0708, 0709, 0731, 0732, 0738, 1408, 1439}
Using the 453-3204 Pressure and Temperature Test Group{0374, 0599, 0706, 0708, 0709, 0731, 0732, 0738, 1408, 1439}

Systems Operation

Throttle Position Sensor
3508B Engine for Caterpillar Built Machines

Hardware and Schematics
Oil Renewal System for Off-Highway Trucks

Engine Speed Controlled by the Transmission ECM
3508B Engine for Caterpillar Built Machines

Controlled Throttle Shift/Direction Shift Management
3508B Engine for Caterpillar Built Machines

Decelerator Pedal
3508B Engine for Caterpillar Built Machines

Engine Oil Pressure
3508B Engine for Caterpillar Built Machines

Permanent Timing Calibration Sensor
3508B Engine for Caterpillar Built Machines

Atmospheric Pressure Sensor
3508B Engine for Caterpillar Built Machines

Engine Oil Pressure
3500B Engines

Hardware and Schematics
Oil Renewal System

Axle Protection
3508B Engine for Caterpillar Built Machines

Engine Oil Pressure
3508B Engine for Caterpillar Built Machines

Reuse And Salvage Guidelines

Guideline for Visual Inspection and Repair of Foam Wiring Harness {0649, 1408, 1408, 1408, 1408}
Guideline for Visual Inspection and Repair of Foam Wiring Harness {0649, 1408, 1408, 1408, 1408}

Testing and Adjusting

Electric Starting System
3508B Engine for Caterpillar Built Machines

Troubleshooting

MID 036 - CID 0091 - FMI 08 Throttle Position signal abnormal
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0101 - FMI 03 Crankcase Pressure open/short to +batt
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0101 - FMI 04 Crankcase Pressure short to ground
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0262 - FMI 04 5 Volt Sensor DC Power Supply short to ground
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0262 - FMI 03 5 Volt Sensor DC Power Supply short to +batt
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0263 - FMI 03 Digital Sensor Supply short to +batt
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0263 - FMI 04 Digital Sensor Supply short to ground
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0274 - FMI 04 Atmospheric Pressure short to ground
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0274 - FMI 13 Atmospheric Pressure calibration required
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0827 - FMI 08 Left Exhaust Temperature signal abnormal
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0261 - FMI 13 Engine Timing calibration required
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0101 - FMI 13 Crankcase Pressure calibration required
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0110 - FMI 03 Engine Coolant Temperature open/short to +batt
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0110 - FMI 04 Engine Coolant Temperature short to ground
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0168 - FMI 01 System Voltage Low
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0168 - FMI 02 System Voltage intermittent/erratic
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0274 - FMI 03 Atmospheric Pressure open/short to +batt
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0542 - FMI 04 Unfiltered Engine Oil Pressure short to ground
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0542 - FMI 13 Unfiltered Engine Oil Pressure cal required
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0100 - FMI 13 Engine Oil Pressure calibration required
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0100 - FMI 03 Engine Oil Pressure open/short to +batt
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0100 - FMI 04 Engine Oil Pressure short to ground
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0542 - FMI 02 Unfiltered Engine Oil Pressure misinstalled
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0190 - FMI 02 Loss of Engine Speed signal
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0190 - FMI 03 Engine Speed open/short to +batt
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

MID 036 - CID 0190 - FMI 08 Engine Speed signal abnormal
3500B Engines for 5130B and 5230B Excavators

Engine Speed/Timing Sensor
3500B Engines for 5130B and 5230B Excavators

Analog Sensor - Calibrate
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

Analog Sensor Supply
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

Digital Sensor Supply
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

Electrical Connectors and Functions
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

Engine Speed/Timing Sensor - Calibrate
3500B Engines for 5130B and 5230B Excavators

Throttle Position Sensor
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

Engine Sensor Open/Short Test
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

Electrical Connectors and Functions
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0091 - FMI 00 Throttle Switch not released
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0264 - FMI 08 Decel Throttle Position signal abnormal
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0277 - FMI 08 Timing Calibration signal abnormal
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0290 - FMI 03 Engine Fan Pump Pressure open/short to +batt
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0290 - FMI 04 Engine Fan Pump Pressure short to ground
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0861 - FMI 05 Service Engine Lamp open/short to +batt
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0861 - FMI 06 Service Engine Lamp short to ground
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0865 - FMI 05 Engine Exhaust Temp Lamp open/short to +batt
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0865 - FMI 06 Engine Exhaust Temp Lamp short to ground
3508B Engine for D11R Track-Type Tractors

Analog Sensor Supply
3508B Engine for D11R Track-Type Tractors

Decelerator Position Sensor
3508B Engine for D11R Track-Type Tractors

Digital Sensor Supply
3508B Engine for D11R Track-Type Tractors

Engine Speed/Timing Sensor - Calibrate
3508B Engine for D11R Track-Type Tractors

Engine Speed/Timing Sensor
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0091 - FMI 02 Incorrect Throttle Switch inputs
3508B Engine for D11R Track-Type Tractors

Electrical Connectors and Functions
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

Throttle Position Sensor
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

Engine Sensor Open/Short Test
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0542 - FMI 03 Unfiltered Engine Oil Pressure open/short to +batt
3500B Engines for 776D, 777D, 784C, 785C, 789C and 793C Off-Highway Trucks

Engine Sensor Open/Short Test
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0828 - FMI 08 Right Exhaust Temperature signal abnormal
3500B Engines for 5130B and 5230B Excavators

Analog Sensor Supply
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

Engine Speed/Timing Sensor
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

Permanent Timing Calibration Sensor
3508B Engine for 854G Wheel Dozers and 992G Wheel Loaders

MID 036 - CID 0091 - FMI 02 Incorrect Throttle Switch inputs
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0542 - FMI 04 Unfiltered Engine Oil Pressure short to ground
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0580 - FMI 03 Power Shift Pres Sensor open/short to +batt
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0580 - FMI 04 Power Shift Pres Sensor short to ground
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0580 - FMI 08 Power Shift Pres Sensor signal is abnormal
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0581 - FMI 05 Power Shift Solenoid open circuit
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0581 - FMI 06 Power Shift Solenoid short to ground
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0581 - FMI 13 Power Shift Solenoid cal required
3500B Engines for 5130B and 5230B Excavators

Electrical Connectors and Functions
3500B Engines for 5130B and 5230B Excavators

Analog Sensor Supply
3500B Engines for 5130B and 5230B Excavators

Digital Sensor Supply
3500B Engines for 5130B and 5230B Excavators

Power Shift Solenoid Circuit - Test
3500B Engines for 5130B and 5230B Excavators

Power Shift Solenoid - Calibrate
3500B Engines for 5130B and 5230B Excavators

MID 036 - CID 0290 - FMI 03 Engine Fan Pump Pressure open/short to +batt
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 0290 - FMI 04 Engine Fan Pump Pressure short to ground
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 1076 - FMI 05 Engine Cooling Fan Bypass Solenoid open circuit
3508B Engine for D11R Track-Type Tractors

MID 036 - CID 1076 - FMI 06 Engine Cooling Fan Bypass Solenoid short to ground
3508B Engine for D11R Track-Type Tractors

Engine Cooling Fan Bypass Solenoid
3508B Engine for D11R Track-Type Tractors

Service Magazine

Dielectric Grease Should Not Be Used in Electrical Connectors {1408, 7553}
2012/05/04

Service of the Machined Terminals and the Stamped and Formed Terminals {7553}
2006/11/13

Updated Instruction For The Bypass Harness {0785, 1408}
2008/03/17

Bulk Wiring Harnesses Are Available for Use with Caterpillar Products {1408}
2012/03/05

Striped Wire Is Replaced With Improved Ink Jet Identification for Legacy (Parts Service) Wire harnesses {1408}
2012/06/08

Use Conductive Fasteners for Electrical Grounding on All Cat Products {7553, 7556}
2012/05/08

Information On Battery Cables and Wire Assemblies for Assembling at Dealer Site {4459}
2012/09/21

Caterpillar Parts SIS Catalog 992G :

Truck sale:

Caterpillar 992G
- Wheel loaders
J.A. DELMAS S.A.S.

Caterpillar 992G, Radlader, Bau-Und Bergbauausrüstung