AVSPARE.COM
parts catalog
  1. Home
  2. Caterpillar catalog

9X-4452 STARTING MOTOR GP-ELECTRIC S/N 9WR1-2410 24-VOLT PART OF 6N-1889 STARTING MOTOR GP-ELECTRIC FIELD REPLACEMENT ORDER @@@@@ 6V-5539@@@@@ AN ATTACHMENT 3406E


ELECTRICAL AND STARTING SYSTEM
STARTING MOTOR GP
CONTROL GP-SPEED
SWITCH GP
STARTING MOTOR GP

MARINE ENGINE 3406E MARINE ENGINE 9WR
 3406E Marine Engine 9WR00001-UP SEBP2555 3406E 9WR   (1996)

ELECTRICAL AND STARTING SYSTEM

STARTING MOTOR GP
STARTING MOTOR GP-ELECTRIC
8C-3644 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
8C-3649 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
9X-4452 STARTING MOTOR GP-ELECTRIC
9Y-7129 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
9Y-7129 STARTING MOTOR GP-ELECTRIC
VALVE GP-AIR STARTING
1L-5011 VALVE GP-AIR STARTING
 

#SEBP25550600
 

9X-4452: STARTING MOTOR GP-ELECTRIC

9X-4452 STARTING MOTOR GP-ELECTRIC
S/N 9WR1-2410
24-VOLT
PART OF 6N-1889 STARTING MOTOR GP-ELECTRIC
FIELD REPLACEMENT ORDER @@@@@ 6V-5539@@@@@
AN ATTACHMENT
i00147512 SEBP2555
9X4452 STARTING MOTOR GP-ELECTRIC Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 6V-8188 [3] NUT (1/2-13-THD)  
2. 7X-0562 [3] WASHER-HARD (13.5X19X0.8-MM THK)  
3. 4B-2049 [1] NUT (10-32-THD)  
4. 8F-1434 [1] LOCKWASHER  
5. 8T-0328 [1] WASHER-HARD (5.5X10X1-MM THK)  
6. 8T-4133 M [1] NUT (M10X1.5-THD)  
7. 8T-4121 [1] WASHER-HARD (11X21X2.5-MM THK)  
8. 3E-0142 [1] HOUSING AS (DRIVE)  
9. 3E-0141 [1] STOP-STARTING MOTOR  
10. 4N-7521 [1] RING-LOCK  
11. 3E-0146 [1] DRIVE AS-STARTING MOTOR  
12. 3E-0144 [1] HOUSING AS  
13. 3E-0140 [1] LEVER AS-STARTING MOTOR  
14. 3E-0139 [1] HOUSING AS  
15. 3E-0138 [1] ARMATURE AS (24-VOLT)  
16. 3E-0137 [1] HOLDER AS-BRUSH (STARTING MOTOR)  
17. 3E-0136 [1] HOUSING AS  
18. 3E-0133 [1] WIRE AS-STARTING MOTOR  
19. 3E-0135 [1] SOLENOID AS (24-VOLT)(STARTING MOTOR)  
20. 3E-0132 [1] CONNECTOR  
21. 3E-0134 [1] COVER-PLUNGER  
   
    AVAILABLE REPAIR KIT(S):
  3E-0127 [1] KIT-BEARING  
    (INCLUDES SEAL, BUSHING & BEARING AS.)
  3E-0128 [1] KIT-BRUSH (24-VOLT)  
    (INCLUDES O-RINGS, SCREWS, SPRINGS, & BRUSHES)
  3E-0129 [1] KIT-HARDWARE (24-VOLT)  
    (INCLUDES BOLTS, NUTS, WASHERS, BUSHINGS & PLATE)
  3E-0130 [1] KIT-STARTING MOTOR SEAL (24-VOLT)  
    (INCLUDES SEAL & O-RINGS)
  3E-0131 [1] KIT-WASHER (24-VOLT)  
    (INCLUDES WASHERS)
  3E-0145 [1] KIT-STARTING MOTOR PIN (24-VOLT)  
    (INCLUDES SHAFT, RING & O-RINGS)
  M   METRIC PART
 

#SEBP25550601
 

9Y-7129: STARTING MOTOR GP-ELECTRIC

9Y-7129 STARTING MOTOR GP-ELECTRIC
12-VOLT. STARTING AID RECOMMENDED BELOW 0 DEG CELSIUS (32 DEG F)
Type 1
AN ATTACHMENT
i00445969 SEBP2555
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
  8C-3592 Y [1] STARTING MOTOR GP-ELECTRIC  
  8S-2332 [3] BOLT-12 POINT HEAD (5/8-11X1.75-IN)  
  4H-7869 [1] GASKET  
  Y   SEPARATE ILLUSTRATION
 

#SEBP25550602
 

9Y-7129: STARTING MOTOR GP-ELECTRIC

9Y-7129 STARTING MOTOR GP-ELECTRIC
12-VOLT. STARTING AID RECOMMENDED BELOW 0 DEG CELSIUS (32 DEG F)
Type 2
AN ATTACHMENT
i01602766 SEBP2555
9Y7129 STARTING MOTOR GP-ELECTRIC Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 8S-2332 [3] BOLT-12 POINT HEAD (5/8-11X1.75-IN)  
2. 207-1537 CY [1] STARTING MOTOR GP-ELECTRIC  
3. 4H-7869 [1] GASKET  
  C   CHANGE FROM PREVIOUS TYPE
  Y   SEPARATE ILLUSTRATION
 

#SEBP25550603
 

379-3359: SWITCH AS-SPEED

379-3359 SWITCH AS-SPEED
AN ATTACHMENT
i05031932 SEBP2555
3793359 SWITCH AS-SPEED Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
    (NO SERVICED PARTS)
 

#SEBP25550604
 

7W-2743: SWITCH AS-SPEED

7W-2743 SWITCH AS-SPEED
AN ATTACHMENT
i02345294 SEBP2555
7W2743 SWITCH AS-SPEED Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
    (NO SERVICED PARTS)
 

#SEBP25550605
 

125-1302: SWITCH GP-MAGNETIC

125-1302 SWITCH GP-MAGNETIC
24-VOLT
PART OF 147-7848 KIT-CRUISE
AN ATTACHMENT
i01763082 SEBP2555
1251302 SWITCH GP-MAGNETIC Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 102-8802 [1] KIT-RECEPTACLE (2-PIN)  
    (INCLUDES RECEPTACLE AS & WEDGE)
2. 8T-8729 [2] PIN-CONNECTOR (16-GA TO 20-GA)  
3. 1H-3338 [2] LOCKWASHER  
4. 3B-4504 [2] LOCKWASHER  
5. 5C-2890 M [2] NUT (M6X1-THD)  
6. 9X-1813 E SLEEVE (16-CM)  
  E   ORDER BY THE CENTIMETER
  M   METRIC PART
 

#SEBP25550606
 

209-5582: SWITCH GP-MAGNETIC

209-5582 SWITCH GP-MAGNETIC
24-VOLT
PART OF 304-6650 CONTROL GP-AUTO START/STOP
AN ATTACHMENT
i02555109 SEBP2555
2095582 SWITCH GP-MAGNETIC Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 102-8802 [1] KIT-RECEPTACLE (2-PIN)  
    (INCLUDES RECEPTACLE AS & WEDGE)
2. 8T-8729 [2] PIN-CONNECTOR (16-GA TO 20-GA)  
3. 3F-9556 [2] LOCKWASHER  
4. 6V-8186 [2] NUT-FULL (5/16-24-THD)  
5. 6V-8378 [2] NUT (10-32-THD)  
6. 8F-1434 [2] LOCKWASHER  
 

#SEBP25550607
 

3N-8782: SWITCH GP-REMOTE STARTING

3N-8782 SWITCH GP-REMOTE STARTING
FOR USE WITH DIRECT INJECTION ENGINE
AN ATTACHMENT
i00366891 SEBP2555
3N8782 SWITCH GP-REMOTE STARTING Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 9W-1077 Y [1] SWITCH GP-START (REMOTE)  
2. 8J-4785 [1] PLATE-INSTRUCTION (START SWITCH)(REMOTE)  
  Y   SEPARATE ILLUSTRATION
 

#SEBP25550608
 

9W-1077: SWITCH GP-START

9W-1077 SWITCH GP-START
PART OF 3N-8782 SWITCH GP-REMOTE STARTING
AN ATTACHMENT
i00446926 SEBP2555
9W1077 SWITCH GP-START Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 8F-3437 [1] LEVER-SWITCH (START)  
  5L-7200 [1] SCREW (8-32X0.375-IN)  
  3B-4501 [1] LOCKWASHER  
2. 8C-6808 [1] NUT (5/8-32-THD)  
  7M-0327 [1] WASHER-THRUST (17.4X25.4X1.6-MM THK)  
3. 6V-8364 [4] SCREW-MACHINE (10-32X9.52-MM)  
  8F-1434 [4] LOCKWASHER  
 

#SEBP25550609
 

1L-5011: VALVE GP-AIR STARTING

1L-5011 VALVE GP-AIR STARTING
REQUIRED WHEN AIR SUPPLY PRESSURE EXCEEDS 1034 KPA. REGULATING AND PRESSURE REDUCING
FOR USE WITH AIR STARTING MOTOR
AN ATTACHMENT
i00351962 SEBP2555
1L5011 VALVE GP-AIR STARTING Parts scheme
  For full view, you need register

Parts for your 3406E MARINE ENGINE:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 1L-9048 [1] NUT-PLATED JAM (7/16-14-THD)  
2. 1H-9569 [1] BUTTON-SPRING  
3. 1L-9049 [1] SPRING-PRESSURE  
4. 1L-9060 [1] BUTTON  
5. 1H-9572 [1] PLATE-PRESSURE  
6. 1L-9064 [1] PISTON AS  
7. 7L-8705 [1] CYLINDER  
8. 1L-9067 [1] SPRING-PISTON  
9. 1H-9580 [1] GASKET-PLUG  
10. 1L-9069 [1] PLUG AS  
11. 1L-9066 [1] SCREEN-STRAINER (AIR STARTING VALVE)  
12. 1L-9063 [1] DIAPHRAGM  
13. 1L-9068 [1] BODY-VALVE  
14. 1L-9062 [6] BOLT (3/8-24X1.5-IN)  
15. 1L-9059 [1] HOUSING-SPRING  
16. 0T-0320 C [1] BOLT (7/16-14X1.25-IN)  
   
  1B-4203 F [6] NUT-FULL (3/8-24-THD)  
  C   CHANGE FROM PREVIOUS TYPE
  F   NOT SHOWN
 

Information:

General Service Information
Introduction
DELCO REMY CRANKING MOTORS 30-MT, 35-MT, 40-MT, 50-MT SERIES
Delco Remy
DELCO REMY CRANKING MOTORS 30-MT, 35-MT, 40-MT, 50-MT SERIES
Engine News
New Starting Motors Used {1453}
2002/05/01
A New Air Motor Lubricator Gp Is Used and A New Fitting Is Available for Service on Certain Engines {1451, 1451}
2010/11/05
Operation and Maintenance Manual
Starting Motor - Inspect
3406E and C15 Marine Engines
Cold Weather Starting
3406E and C15 Marine Engines
Starting the Engine
3406E and C15 Marine Engines
Cold Start Strategy
3406E and C15 Marine Engines
Special Instruction
Caterpillar PRELUB<SUP>&reg;</SUP> Diagnostics{1469}
Caterpillar PRELUB® Diagnostics{1469}
Installation of New Shift Lever Assembly for All Starter Motors {1453}
Installation of New Shift Lever Assembly for All Starter Motors {1453}
Procedure to Install the Insulator on to Series Starters on All Engines {1453}
Procedure to Install the Insulator on to Series Starters on All Engines {1453}
Installation of Repair Kit-Solenoid Plunger Assembly on All Engines {1453}
Installation of Repair Kit-Solenoid Plunger Assembly on All Engines {1453}
Procedure to Install Terminal Kit on All Engines {1453}
Procedure to Install Terminal Kit on All Engines {1453}
Procedure to Install Brush Holder Assembly in All Engines {1453}
Procedure to Install Brush Holder Assembly in All Engines {1453}
Procedure to Replace Armature of Starter Motor On All Cat<SUP>&reg;</SUP> Products {1408, 1450, 1453}
Procedure to Replace Armature of Starter Motor On All Cat® Products {1408, 1450, 1453}
Procedure to Replace Commutator End (CE) Housing of Starter Motor On All Cat<SUP>&reg;</SUP> Products {1408, 1450, 1453}
Procedure to Replace Commutator End (CE) Housing of Starter Motor On All Cat® Products {1408, 1450, 1453}
Procedure to Replace Drive Assembly of Starter Motor On All Cat<SUP>&reg;</SUP> Products {1453}
Procedure to Replace Drive Assembly of Starter Motor On All Cat® Products {1453}
Service Letter-NACD
The Starter Solenoid Needs To Be Replaced On Certain 3176B, 3176C, 3196 And 3406E Marine Engines
The Starter Solenoid Needs To Be Replaced On Certain 3176B, 3176C, 3196 And 3406E Marine Engines
Service Letter-Australia
Service Letter-CFEL
Service Letter-CSARL
Service Letter-Americas
Service Letter-Truck/Ag/Marine
Specifications
Air Starting Motor Pressure Regulating Valve
3406E and C15 Marine Engines
Starting Motor
37-MT, 41-MT, and 42-MT Series Starting Motors
Electric Starting Motor
3406E and C15 Marine Engines
Electric Starting Motor
3406E and C15 Marine Engines
Electric Starting Motor
3406E and C15 Marine Engines
Electric Starting Motor
3406E and C15 Marine Engines
Electric Starting Motor
3406E and C15 Marine Engines
Electric Starting Motor
3406E Marine Engine
Electric Starting Motor
3406E and C15 Marine Engines
Electric Starting Motor
3406E and C15 Marine Engines
Service Letter-China
The Starter Solenoid Needs To Be Replaced On Certain 3176B, 3176C, 3196 And 3406E Marine Engines
The Starter Solenoid Needs To Be Replaced On Certain 3176B, 3176C, 3196 And 3406E Marine Engines
Service Letter-Asia
Systems Operation
General Information
37-MT, 41-MT, and 42-MT Series Starting Motors
Component Description
37-MT, 41-MT, and 42-MT Series Starting Motors
Normal Operation
37-MT, 41-MT, and 42-MT Series Starting Motors
Information Release Memo
CAT REMAN ANNOUNCES AN ADDITIONAL AIR STARTER AND ADDITIONAL ALTERNATORS FOR CERTAIN ENGINE MODELS
CAT REMAN ANNOUNCES AN ADDITIONAL AIR STARTER AND ADDITIONAL ALTERNATORS FOR CERTAIN ENGINE MODELS
Service Letter-APD
The Starter Solenoid Needs To Be Replaced On Certain 3176B, 3176C, 3196 And 3406E Marine Engines
The Starter Solenoid Needs To Be Replaced On Certain 3176B, 3176C, 3196 And 3406E Marine Engines
Testing and Adjusting
Electric Starting System - Test
3406E and C15 Marine Engines
Pinion Clearance - Adjust
3406E and C15 Marine Engines
Pinion Clearance - Adjust
3406E and C15 Marine Engines
No Load - Test
37-MT, 41-MT, and 42-MT Series Starting Motors
Brush and Brush Holder - Check
37-MT, 41-MT, and 42-MT Series Starting Motors
Pinion Clearance - Adjust
37-MT, 41-MT, and 42-MT Series Starting Motors
Starting Motor Solenoid - Test
37-MT, 41-MT, and 42-MT Series Starting Motors
Troubleshooting
Engine Does Not Crank with Starting Motor On and Pinion Engaging Ring Gear
37-MT, 41-MT, and 42-MT Series Starting Motors
Starting Motor Does Not Turn or Turns Slowly
37-MT, 41-MT, and 42-MT Series Starting Motors
General Information
37-MT, 41-MT, and 42-MT Series Starting Motors
Disassembly and Assembly
Electric Starting Motor - Remove and Install
3406E and C15 Marine Engines
Starting Motor - Disassemble - 37-MT and 41-MT
37-MT, 41-MT, and 42-MT Series Starting Motors
General Information
37-MT, 41-MT, and 42-MT Series Starting Motors
Starting Motor - Assemble - 37-MT and 41-MT
37-MT, 41-MT, and 42-MT Series Starting Motors
Starting Motor - Disassemble - 42-MT
37-MT, 41-MT, and 42-MT Series Starting Motors
Starting Motor - Assemble - 42-MT
37-MT, 41-MT, and 42-MT Series Starting Motors

Caterpillar Parts SIS Catalog 3406E :

STARTING MOTOR GP-ELECTRIC
8C-3649 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
8C-3644 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
8C-3593 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
8C-3592 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
7T-0795 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
7T-0794 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
6V-5582 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
6V-5540 STARTING MOTOR GP-ELECTRIC
9Y-7129 STARTING MOTOR GP-ELECTRIC
STARTING MOTOR GP-ELECTRIC
9Y-7129 STARTING MOTOR GP-ELECTRIC
SWITCH AS-SPEED
379-3359 SWITCH AS-SPEED
SWITCH AS-SPEED
7W-2743 SWITCH AS-SPEED
SWITCH GP-MAGNETIC
125-1302 SWITCH GP-MAGNETIC
SWITCH GP-MAGNETIC
209-5582 SWITCH GP-MAGNETIC
SWITCH GP-REMOTE STARTING
3N-8782 SWITCH GP-REMOTE STARTING
SWITCH GP-START
9W-1077 SWITCH GP-START

Truck sale:

2000 CAT 3406E
USD $8,785 
2000 CAT 3406E

Transgear Truck Supplies
Back to top
Contacts Request list Affiliate disclosure
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.