5N-9421 EXCITER & HEAT SINK AS S/N 5DD625-UP PART OF 7W-4367, 7W-4369 GENERATOR GP 3406B GEN SET ENGINE



GENERATORS
GENERATOR GP

GEN SET ENGINE 3406B GEN SET ENGINE 2WB
 3406C Generator Set 2WB11476-UP SEBP2753 3406B 2WB   (1983)

GENERATORS

GENERATOR GP
COUPLING GP-GENERATOR DRIVE
6L-3916 COUPLING GP-GENERATOR DRIVE
EXCITER & HEAT SINK AS
5N-5025 EXCITER & HEAT SINK AS
EXCITER & HEAT SINK AS
5N-9421 EXCITER & HEAT SINK AS
109-3777 GENERATOR AR
109-3779 GENERATOR AR
109-3781 GENERATOR AR
 

#SEBP27530930
 

5N-9421: EXCITER & HEAT SINK AS

5N-9421 EXCITER & HEAT SINK AS
S/N 5DD625-UP
PART OF 7W-4367, 7W-4369 GENERATOR GP
i00391276 SEBP2753
5N9421 EXCITER & HEAT SINK AS Parts scheme
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
1. 9Y-7175 Y [1] HEAT SINK AS-POSITIVE  
2. 9Y-7174 Y [1] HEAT SINK AS-NEGATIVE  
3. 5N-9424 [1] STATOR AS-EXCITER  
4. 5N-5043 [2] VARISTOR AS  
5. 5P-4116 [7] WASHER-HARD (8.8X20.5X2-MM THK)  
6. 3N-1645 [4] SCREW-FORMING (5/16-18X1-IN)  
7. 4B-3903 [3] BOLT (5/16-18X4-IN)  
8. 4P-5853 [1] HUB-HOLDER  
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530931
 

109-3777: GENERATOR AR

109-3777 GENERATOR AR
S/N 8JF1-UP
240-480 VOLT, 60 HERTZ
i00490324 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  7W-0571 Y [1] CONNECTION GP-GENERATOR LEADS  
  109-3776 Y [1] GENERATOR GP  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL
  4W-9449 [1] FILM-INFORMATION (GENERATOR WIRING DIAGRAM)  
    INSTALL ON INSIDE OF GENERATOR ENCLOSURE ON INSIDE OF CONTROL PANEL DOOR DIRECTLY BELOW "SR" WIRING DIAGRAM.
  6L-6523 [1] FILM-INSTRUCTION (GENERATOR-VOLTAGE CONTROL)  
    INSTALL ON INSIDE OF GENERATOR SIDE PANEL.
    IF FOREIGN LANGUAGE IS REQUIRED INSTALL ON LH SIDE OF GENERATOR ON SIDE PANEL IN UPPER CORNER TOWARD THE FRONT OF
    ENGINE.
  7C-5711 [1] FILM-INSTRUCTION (VOLTAGE CONTROL ADJUSTMENT)  
    INSTALL INSIDE OF GENERATOR SIDE PANEL
    IF FOREIGN LANGUAGE IS REQUIRED INSTALL ON LH SIDE OF GENERATOR ON SIDE OF PANEL IN UPPER CORNER TOWARD THE FRONT OF
    ENGINE
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR CONNECTION POINT
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE PANELS
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)  
    INSTALL ON RH SIDE OF GENERATOR
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530932
 

109-3779: GENERATOR AR

109-3779 GENERATOR AR
S/N 8KF1-UP
60 HERTZ 240-480 VOLTS
i00490347 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  5N-4123 Y [1] CONNECTION GP-GENERATOR LEADS  
  109-3778 Y [1] GENERATOR GP  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE PANELS
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR CONNECTION POINT
  118-8452 [1] FILM-INFORMATION (GENERATOR)  
    INSTALL ON LH SIDE OF GENERATOR BARREL OR ON FRONT PANEL TOWARDS LH SIDE OF PACKAGE.
    APPLY CLEAR LAMINATE 122-9525 OVER INSTALLED GENERATOR FILM.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL ASSEMBLY ON LH SIDE OF PACKAGE
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL ASSEMBLY ON LH SIDE OF PACKAGE
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)  
    INSTALL ON RH SIDE OF GENERATOR USING 2K3219 DRIVE SCREW
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
    INSTALL GENERATOR SERIAL NUMBER PLATE
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530933
 

109-3781: GENERATOR AR

109-3781 GENERATOR AR
S/N 8LF1-UP
60 HERTZ, 240-480 VOLT
i00490350 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  5N-4125 Y [1] CONNECTION GP-GENERATOR LEADS  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR GROUND CUSTOMER CONNECTION POINT
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH AND LH GENERATOR SIDE PANELS LOCATED 4-5 INCHES FROM REAR & TOP OF GENERATOR
  109-3780 Y [1] GENERATOR GP  
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL ASSEMBLY ON LH SIDE OF PACKAGE
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)(GENERATOR)  
    INSTALL ON RH SIDE OF GENERATOR USING DRIVE SCREWS
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
    INSTALL GENERATOR SERIAL NUMBER PLATE
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530934
 

109-3783: GENERATOR AR

109-3783 GENERATOR AR
S/N 9FF1-UP
60 HERTZ, 240-480 VOLT
i00490353 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  5N-4125 Y [1] CONNECTION GP-GENERATOR LEADS  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL.
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL.
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT
    OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE
    PANELS. LOCATED 4-5 INCHS FROM REAR & TOP
    OF GENERATOR.
  109-3782 Y [1] GENERATOR GP  
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL AS
    ON LH SIDE OF PACKAGE.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL AS ON
    LH SIDE OF PACKAGE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)(GENERATOR)  
    INSTALL ON FRONT OF RH GENERATOR FOOT
    USING DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  153-5927 [1] TAG-INSTRUCTION (GENSET ALIGNMENT)  
    INSTALL LH SIDE OF GENERATOR FOOT
    NEAR DRIVE END.
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530935
 

109-3789: GENERATOR AR

109-3789 GENERATOR AR
S/N 8LF1-UP
60 HERTZ, 240-480 VOLT
i00490362 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  5N-4125 Y [1] CONNECTION GP-GENERATOR LEADS  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL.
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL.
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR GENERATOR
    GROUND CUSTOMER CONNECTION POINT.
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE PANELS.
    LOCATED 4-5 INCHES FROM REAR & TOP OF GENERATOR
  109-3788 Y [1] GENERATOR GP  
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL AS
    ON LH SIDE OF PACKAGE.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL AS ON
    LH SIDE OF PACKAGE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)(GENERATOR)  
    INSTALL ON FRONT OF RH GENERATOR FOOT
    USING DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530936
 

109-3791: GENERATOR AR

109-3791 GENERATOR AR
S/N 9FF1-UP
60 HERTZ, 240-480 VOLT
i00490365 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  5N-4125 Y [1] CONNECTION GP-GENERATOR LEADS  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL.
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL.
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT
    OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE
    PANELS. LOCATED 4-5 INCHES FROM REAR & TOP
    OF GENERATOR.
  109-3790 Y [1] GENERATOR GP  
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL AS
    ON LH SIDE OF PACKAGE.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL AS ON
    LH SIDE OF PACKAGE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)(GENERATOR)  
    INSTALL ON FRONT OF RH GENERATOR FOOT
    USING DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  153-5927 [1] TAG-INSTRUCTION (GENSET ALIGNMENT)  
    INSTALL LH SIDE OF GENERATOR FOOT
    NEAR DRIVE END.
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530937
 

109-3801: GENERATOR AR

109-3801 GENERATOR AR
S/N 8LF1-UP
60 HERTZ, 600 VOLT
i00490403 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL.
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL.
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT OR
    GENERATOR GROUND CUSTOMER CONNECTION POINT.
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE PANELS.
    LOCATED 4-5 INCHES FROM REAR & TOP OF GENERATOR
  109-3800 Y [1] GENERATOR GP  
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL AS
    ON LH SIDE OF PACKAGE.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL AS ON
    LH SIDE OF PACKAGE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)(GENERATOR)  
    INSTALL ON FRONT OF RH GENERATOR FOOT
    USING DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530938
 

109-3803: GENERATOR AR

109-3803 GENERATOR AR
S/N 9FF1-UP
60 HERTZ, 600 VOLT
i00490426 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  109-3802 Y [1] GENERATOR GP  
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL.
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL.
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT
    OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE
    PANELS. LOCATED 4-5 IN. FROM REAR & TOP
    OF GENERATOR.
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL AS
    ON LH SIDE OF PACKAGE.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL AS ON
    LH SIDE OF PACKAGE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)  
    INSTALL ON FRONT OF RH GENERATOR FOOT
    USING 2K3219 DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  153-5927 [1] TAG-INSTRUCTION (GENSET ALIGNMENT)  
    INSTALL LH SIDE OF GENERATOR FOOT
    NEAR DRIVE END.
  Y   SEPARATE ILLUSTRATION
 

#SEBP27530939
 

109-3807: GENERATOR AR

109-3807 GENERATOR AR
S/N 9FF1-UP
60 HERTZ, 208 VOLT
i00490434 SEBP2753
  For full view, you need register

Parts for your 3406B GEN SET ENGINE:

Pos. Part No Qty Parts name Comments
  9Y-4335 [1] FILM (CSA CONTROL PANEL APPROVAL)(CSA CONTROL PANEL)  
    INSTALL INSIDE OF CONTROL PANEL.
  9Y-4336 [1] FILM (CSA CONTROL PANEL APPROVAL)  
    INSTALL INSIDE OF CONTROL PANEL.
  4W-5138 [1] FILM-INSTRUCTION (GROUND)  
    INSTALL NEAR GENERATOR GROUND BOLT
    OR GENERATOR GROUND CUSTOMER CONNECTION POINT.
  7W-4445 [2] FILM-WARNING (DANGER VOLTAGE)  
    INSTALL ONE ON RH & LH GENERATOR SIDE
    PANELS. LOCATED 4-5 INCHES FROM REAR & TOP
    OF GENERATOR.
  109-3806 Y [1] GENERATOR GP  
  7W-0096 [1] PLATE-INFORMATION (GENERATOR INFORMATION)  
    INSTALL ON GENERATOR FRONT PANEL AS
    ON LH SIDE OF PACKAGE.
  4P-6410 [1] PLATE-INFORMATION (GENERATOR)  
    INSTALL ON GENERATOR FRONT PANEL AS ON
    LH SIDE OF PACKAGE.
  1W-7848 [1] PLATE-SERIAL NUMBER (ENGLISH)(GENERATOR)  
    INSTALL ON FRONT OF RH GENERATOR FOOT
    USING DRIVE SCREWS TO INSTALL.
  2K-3219 [2] SCREW-DRIVE (NO 6X0.25-IN)  
  153-5927 [1] TAG-INSTRUCTION (GENSET ALIGNMENT)  
    INSTALL LH SIDE OF GENERATOR FOOT
    NEAR DRIVE END.
  Y   SEPARATE ILLUSTRATION
 

Information:

General Service Information
Identification
CONTROL PANEL SR4 GENERATOR MOUNTED
Abbreviations
CONTROL PANEL SR4 GENERATOR MOUNTED
Symbols
CONTROL PANEL SR4 GENERATOR MOUNTED
How To Read Control Panel DC Schematics
CONTROL PANEL SR4 GENERATOR MOUNTED
Location Of Components
CONTROL PANEL SR4 GENERATOR MOUNTED
Standard Components
CONTROL PANEL SR4 GENERATOR MOUNTED
Optional Components
CONTROL PANEL SR4 GENERATOR MOUNTED
Energize To Run Engine System
CONTROL PANEL SR4 GENERATOR MOUNTED
Energize To Shut Off Engine System
CONTROL PANEL SR4 GENERATOR MOUNTED
Latching Fuel Solenoid System
CONTROL PANEL SR4 GENERATOR MOUNTED
Point To Point Wiring Diagrams
CONTROL PANEL SR4 GENERATOR MOUNTED
D.C. Schematic (JIC)
CONTROL PANEL SR4 GENERATOR MOUNTED
Wiring Diagram (Instrument Panel)
CONTROL PANEL SR4 GENERATOR MOUNTED
Wiring Diagram (Subpan Side One)
CONTROL PANEL SR4 GENERATOR MOUNTED
Wiring Diagram (Subpan Side Two)
CONTROL PANEL SR4 GENERATOR MOUNTED
Control Panel Wiring Harness
CONTROL PANEL SR4 GENERATOR MOUNTED
Customer/Contactor Wiring
CONTROL PANEL SR4 GENERATOR MOUNTED
Standby Generator Wiring Diagram
CONTROL PANEL SR4 GENERATOR MOUNTED
Identification
ELECTRONIC MODULAR CONTROL PANEL (SR-4 GENERATOR MOUNTED)
Location Of Components
ELECTRONIC MODULAR CONTROL PANEL (SR-4 GENERATOR MOUNTED)
Control Panel Operation
ELECTRONIC MODULAR CONTROL PANEL (SR-4 GENERATOR MOUNTED)
Optional Modules
ELECTRONIC MODULAR CONTROL PANEL (SR-4 GENERATOR MOUNTED)
Troubleshooting
ELECTRONIC MODULAR CONTROL PANEL (SR-4 GENERATOR MOUNTED)
Service Procedures
ELECTRONIC MODULAR CONTROL PANEL (SR-4 GENERATOR MOUNTED)
Identification
SR4 GENERATOR MOUNTED CONTROL PANEL
Abbreviations & Symbols
SR4 GENERATOR MOUNTED CONTROL PANEL
How To Read Control Panel DC Schematics
SR4 GENERATOR MOUNTED CONTROL PANEL
Components
SR4 GENERATOR MOUNTED CONTROL PANEL
Introduction
SR4 GENERATOR MOUNTED CONTROL PANEL
Automatic Start/Stop Control Panel
SR4 GENERATOR MOUNTED CONTROL PANEL
Manual Start/Stop Control Panel
SR4 GENERATOR MOUNTED CONTROL PANEL
Operation
FLOOR-STANDING SWITCHGEAR
Automatic Start-Stop
FLOOR-STANDING SWITCHGEAR
Alternating Current Components Troubleshooting
FLOOR-STANDING SWITCHGEAR
Automatic Start-Stop Troubleshooting
FLOOR-STANDING SWITCHGEAR
Engine News
Several Types Of Automatic Voltage Regulators (AVR) Used In SR4 Generators
1985/04/01
Meter Panel Cover Folds Down Completely
1985/11/01
Troubleshooting Solid State Suppressors
1986/04/01
Bearing Information For SR4 Generators
1986/09/01
Generator Sets Wired For Use With Customer-Supplied Switch Gear; Do Not Run Without Switchgear
1987/01/01
Guidebook For Caterpillar Inspection And Maintenance Program For Standby Generator Sets
1987/02/01
Two New Self-Powered Digital Tachometers And Signal Generator Available
1987/05/01
Ground Wire Added To SR 4 Generators With 580, 680, And 800 Frames
1988/08/01
Corrections For Systems Operation, Troubleshooting, And Specifications For 2301 Electric Governors For Generator Set And Industrial Engines, SENR2928-01
1991/05/01
Procedure To Set Voltage Droop On SR 4 Generators With VR3 Voltage Regulators Using Resistive Load Bank
1991/05/01
Changes To EMCP I Control Panel{4450}
1996/11/01
Use 152-7143 Cable Assembly For Flash-Programming Generator Status Control Module{4450}
1999/02/01
A List Of Contacts For Caterpillar Product Support Is Available {1000, 4450, 7000}
2002/04/01
Special Instruction
Instructions For EMCP II+ Field Retrofit Onto EMCP II Equipped Generator Sets{7490, 7451}
Instructions For EMCP II+ Field Retrofit Onto EMCP II Equipped Generator Sets{7490, 7451}
Replacement Of 5N1848, 5N1849 And 5N1850 A1 Module Regulator Assemblies{4467}
Replacement Of 5N1848, 5N1849 And 5N1850 A1 Module Regulator Assemblies{4467}
Use of 8T5200 Signal Generator/Counter Group{0778, 0783, 0785}
Use of 8T5200 Signal Generator/Counter Group{0778, 0783, 0785}
Installation of 4P1976 Base Group (3406) and/or 4P1980 Base Group (3306) for Marine Auxiliary Generator Sets{7060}
Installation of 4P1976 Base Group (3406) and/or 4P1980 Base Group (3306) for Marine Auxiliary Generator Sets{7060}
Installing Warning Films For 111-2413 Non-Metallic Generator Fans{7405}
Installing Warning Films For 111-2413 Non-Metallic Generator Fans{7405}
3406/3408/3412 Packaged Generator Set Wiring Diagram{1400}
3406/3408/3412 Packaged Generator Set Wiring Diagram{1400}
3406/3408/3412 Package Generator Sets With EMCP{1400}
3406/3408/3412 Package Generator Sets With EMCP{1400}
Installation Of 7W417 Enclosure Group For Package Generator Sets{7002}
Installation Of 7W417 Enclosure Group For Package Generator Sets{7002}
Installing Heli-Coil Inserts In Caterpillar Cylinder Heads{1117}
Installing Heli-Coil Inserts In Caterpillar Cylinder Heads{1117}
Alignment of Single-Bearing Generators {4471}
Alignment of Single-Bearing Generators {4471}
Replacement of the Generator Information Plate{7405}
Replacement of the Generator Information Plate{7405}
Grounding Design Guide for Electric Power Generation Products {4450, 4459}
Grounding Design Guide for Electric Power Generation Products {4450, 4459}
Winding Insulation Maintenance and Cleaning and Drying of the Generators {4450}
Winding Insulation Maintenance and Cleaning and Drying of the Generators {4450}
Generator Bearing Service {4457}
Generator Bearing Service {4457}
Service Letter-NACD
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Service Letter-Australia
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Service Letter-CFEL
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Service Letter-CSARL
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Service Letter-Americas
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Service Letter-Brazil
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Technical Information Bulletin
Correct bolt torque when securing the generator flex plate coupling
Correct bolt torque when securing the generator flex plate coupling
Service Letter-China
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Service Letter-Asia
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Systems Operation
Systems Operation
ELECTRONIC MODULAR CONTROL PANEL (EMCP)
Systems Operation
SR4 GENERATOR
Systems Operation
SR4 GENERATOR
Generator Operation
SR4B Generators
General Information
SR4B Generators
Component Descriptions
SR4B Generators
Glossary
SR4B Generators
Main Revolving Field Connections (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Options (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Main Revolving Field Connections (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Options (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
General Information (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
General Information (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Generator Wiring Diagrams (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Main Stator and Voltage Sensing Lead Connections (All Except SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Main Stator and Voltage Sensing Lead Connections (SR4B for 3500 Engines)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Oil Field Generator Connections (SR4)
Connection Diagrams: SR4 and SR4B Generators, Voltage Regulators, Options
Glossary
SR4 Generator with VR3 or VR4 Voltage Regulator
General Information
SR4 Generator with VR3 or VR4 Voltage Regulator
Component Descriptions
SR4 Generator with VR3 or VR4 Voltage Regulator
Generator Operation
SR4 Generator with VR3 or VR4 Voltage Regulator
Service Letter-APD
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Reworking The Customer Communication Module (CCM) On Certain Generator Sets And G3600 Industrial Engines
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Product Support Program For Installing A New Voltage Regulator In Certain Engine Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Circuit Breakers Need To Be Inspected On Certain 3208, 3304, 3304B, G3306, 3306, 3306B, 3406, 3406C, 3408B, 3408C, 3412, Generator Sets
Testing and Adjusting
Testing And Adjusting
ELECTRONIC MODULAR CONTROL PANEL (EMCP)
Testing And Adjusting
SR4 GENERATOR
General Information
SR4B Generators
Troubleshooting
SR4B Generators
Generator Set - Test
SR4B Generators
Varistor - Test
SR4 Generator with VR3 or VR4 Voltage Regulator
Rotating Rectifier - Test
SR4B Generators
Winding - Test
SR4 Generator with VR3 or VR4 Voltage Regulator
Resistor - Test
SR4B Generators
Exciter Field - Flash
SR4 Generator with VR3 or VR4 Voltage Regulator
Generator - Dry
SR4 Generator with VR3 or VR4 Voltage Regulator
Insulation - Test
SR4 Generator with VR3 or VR4 Voltage Regulator
General Information
SR4 Generator with VR3 or VR4 Voltage Regulator
Troubleshooting
SR4 Generator with VR3 or VR4 Voltage Regulator
Rotating Rectifier - Test
SR4 Generator with VR3 or VR4 Voltage Regulator
Disassembly and Assembly
Engine And Generator
3406B DIESEL ENGINE FOR GENERATOR SETS
Control Panel
SR4 GENERATOR
Generator Bearing<BR> (Outside Bearing Type RFA)
SR4 GENERATOR
Generator Bearing (Inside Bearing Type RFA)
SR4 GENERATOR
Generator Removal
SR4 GENERATOR
Alignment Of Single-Bearing Generators<BR> (Typical)
SR4 GENERATOR
Rotor Assembly
SR4 GENERATOR
Stator Assembly
SR4 GENERATOR
Coupling - Install
SR4 Generator with VR3 or VR4 Voltage Regulator
Coupling - Remove
SR4B Generators
Bearing - Remove and Install
SR4B Generators
Rotor - Remove and Install
SR4B Generators
Generator - Align
SR4B Generators
Generator - Install
SR4B Generators
Generator - Remove
SR4B Generators
Exciter - Remove and Install
SR4B Generators
Bearing - Remove and Install
SR4 Generator with VR3 or VR4 Voltage Regulator
Exciter - Remove and Install
SR4 Generator with VR3 or VR4 Voltage Regulator
Generator - Remove
SR4 Generator with VR3 or VR4 Voltage Regulator
Generator - Install
SR4 Generator with VR3 or VR4 Voltage Regulator
Generator - Align
SR4 Generator with VR3 or VR4 Voltage Regulator
Rotor - Remove and Install
SR4 Generator with VR3 or VR4 Voltage Regulator
Coupling - Remove
SR4 Generator with VR3 or VR4 Voltage Regulator
Service Magazine
New Regulator And Field Coil Assemblies Used{1410,1405}
1981/11/23
Several Types Of Automatic Voltage Regulators (AVR) Used In SR4 Generators{4450}
1985/04/08
Incorrect Connection Of Battery Charger Can Open Circuit Breaker And Damage Woodward 2301 Governor Control{1400,1401,4450}
1986/03/24
Troubleshooting Solid State Suppressors{4467,4466,4450}
1986/04/07
Change Wiring To Prevent Low Oil Pressure Shutdown Immediately After Start-Up {4450}
1986/07/28
Bearing Information For SR4 Generators{4471}
1986/09/01
Generator Sets Wired For Use With Customer-Supplied Switch Gear; Do Not Run Without Switch Gear{7002,7400}
1987/01/19
Guidebook For Caterpillar Inspection And Maintenance Program For Standby Generator Sets{0354,0370,0372}
1987/02/16
Alternator/Generator Output Test On The Engine{1401,1404,1405,1406}
1987/05/04
Two New Self-Powered Digital Tachometers And Signal Generator Available {7462}
1987/05/11
Parts Information For VR3 Automatic Voltage Regulators{4467}
1987/11/09
Ground Wire Added To SR 4 Generators With 580, 680, And 800 Frames{4478}
1988/08/01
Worldwide Service Directories Available For Marine, Petroleum, Power Generation Products{0354,0370,0374,0375,1022,4450}
1989/08/14
Special Instruction Available With Replacement Information For 7C2662, 7C2664 Or 7C3507 VR3 Voltage Regulators{4467}
1990/02/19
Procedure To Set Voltage Droop On SR 4 Generators With VR3 Voltage Regulators Using Resistive Load Bank{4475,4467}
1991/04/22
Procedure To Check 7C2700 Voltage Control Module{4450,4467}
1992/01/20
Troubleshooting 04 Diagnostic Code On Electronic Modular Control Panels (EMCP){4490,4450}
1992/05/11
New Engine Control Module For EMCP Now Available{4450,4490}
1992/07/27
A List Of Contacts For Caterpillar Product Support Is Available {1000, 4450, 7000}
2002/03/25

Caterpillar Parts SIS Catalog 3406B :

EXCITER & HEAT SINK AS
5N-5025 EXCITER & HEAT SINK AS
COUPLING GP-GENERATOR DRIVE
6L-3916 COUPLING GP-GENERATOR DRIVE
COUPLING GP-GENERATOR DRIVE
5N-1713 COUPLING GP-GENERATOR DRIVE
154-6193 CONVERSION GP-GENERATOR
CONNECTION GP-TERMINAL STRIP
9Y-2583 CONNECTION GP-TERMINAL STRIP
CONNECTION GP-TERMINAL STRIP
9Y-0903 CONNECTION GP-TERMINAL STRIP
CONNECTION GP-TERMINAL STRIP
7W-0927 CONNECTION GP-TERMINAL STRIP
CONNECTION GP-TERMINAL STRIP
7W-0925 CONNECTION GP-TERMINAL STRIP
109-3777 GENERATOR AR
109-3779 GENERATOR AR
109-3781 GENERATOR AR
109-3783 GENERATOR AR
109-3789 GENERATOR AR
109-3791 GENERATOR AR
109-3801 GENERATOR AR
109-3803 GENERATOR AR

Truck sale:

1990 CAT 3406B
USD $25,000 
1990 CAT 3406B

Power Generation Enterprises Inc.
North Hollywood, California
1991 CAT 3406B
USD $22,000 
1991 CAT 3406B

Ransome CAT
Bensalem, Pennsylvania
1989 CAT 3406B
USD $35,000 
1989 CAT 3406B

Worldwide Power Products LLC
Houston, Texas
1988 CAT 3406B
USD $29,000 
1988 CAT 3406B

Ransome CAT
Bensalem, Pennsylvania
CATERPILLAR 3406B 1988
$29,000 USD 
CATERPILLAR 3406B 1988
- MARINE - PROPULSION
RANSOME ENGINE POWER
United States