AVSPARE.COM
parts catalog
  1. Home
  2. Caterpillar catalog

6I-1098 GOVERNOR GP S/N 3FZ1-UP PART OF 8N-6951 GOVERNOR GP 3412C GENERATOR SET


FUEL SYSTEM
GOVERNOR GP
PUMP GP-FUEL INJECTION
LINES GP-FUEL
FILTER GP-FUEL

GENERATOR SET 3412C GENERATOR SET PTL
 3412C Generator Set PTL00001-UP SEBP3445 3412C PTL   (2001)

FUEL SYSTEM

GOVERNOR GP
GOVERNOR AS-ELECTRONIC
7E-1232 GOVERNOR AS-ELECTRONIC
GOVERNOR AS-ELECTRONIC
7E-1233 GOVERNOR AS-ELECTRONIC
GOVERNOR GP
6I-1098 GOVERNOR GP
GOVERNOR GP
8N-6951 GOVERNOR GP
GOVERNOR GP-ELECTRONIC
4W-8180 GOVERNOR GP-ELECTRONIC
GOVERNOR GP-ELECTRONIC
4W-8185 GOVERNOR GP-ELECTRONIC
 

#SEBP34450140
 

6I-1098: GOVERNOR GP

6I-1098 GOVERNOR GP
S/N 3FZ1-UP
PART OF 8N-6951 GOVERNOR GP
i00391809 SEBP3445
6I1098 GOVERNOR GP Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 6I-0984 [1] KIT-RELIEF VALVE (GOVERNOR)  
    (INCLUDES SLEEVE, PLUNGER, SPRINGS, & PLUG)
2. 4P-8388 [1] CLUTCH AS  
3. 4P-9624 [1] KIT-COVER REPAIR (GOVERNOR)  
    (INCLUDES SCREWS, NUTS, WASHERS, & COVER)
4. 6I-1178 [1] KIT-DROOP SHAFT (GOVERNOR)  
    (INCLUDES NUT, WASHER, SCREWS, SHAFT, BRACKET, & LEVER)
5. 4P-9622 [1] KIT-REPAIR (GOVERNOR)  
    (INCLUDES LOCKING NUT, TERMINAL SHAFT BUSHINGS, TERMINAL SHAFTS, & PIVOT PIN)
6. 4W-5123 [1] MOTOR AS  
  7N-7779 [1] SOCKET-CONNECTOR (14-GA TO 18-GA)  
  7N-7780 [1] PIN-CONNECTOR (14-GA TO 18-GA)  
  7N-9738 [1] HOUSING-RECEPTACLE (14-GA TO 18-GA)  
7. 4P-9623 [1] KIT-PLUG REPAIR (GOVERNOR)  
    (INCLUDES PLUGS & NEEDLE VALVE)
8. 4P-9625 [1] KIT-GOVERNOR CONTROL STOP  
    (INCLUDES NUT, WASHER, & SCREW)
9. 4P-9627 [1] KIT-GOVERNOR VALVE  
    (INCLUDES IDLER GEAR, GEAR POST, GUIDE BUSHING, VALVE PLUNGER, PLUNGER NUT, & PILOT VALVE BUSHING)
10. 6I-1103 [1] SPRING AS  
11. 7N-0001 [1] BALL HEAD AS  
12. 4P-9626 [1] KIT-GOVERNOR LINKAGE  
    (INCLUDES NUT, SPRING, BLOCKS, PIN, SPACER, & FLOATING LEVER)
13. 4P-9629 [1] KIT-GOVERNOR PISTON  
    (INCLUDES POWER PISTON & BUFFER PISTON)
14. 4P-9628 [1] KIT-BUFFER SPRING (GOVERNOR)  
    (INCLUDES BUFFER SPRINGS & BUFFER SEAT)
   
    AVAILABLE REPAIR KIT(S):
  4P-9621 [1] KIT-GOVERNOR REPAIR  
    (INCLUDES GASKET, SPRING PIN, SEALS, ROLL PINS, WASHER, PLUGS, SEAL-O-RINGS, & RETAINING RINGS)
 

#SEBP34450141
 

8N-6951: GOVERNOR GP

8N-6951 GOVERNOR GP
S/N 3FZ1-UP
WOODWARD PSG-24 VOLT MOTOR
i00413391 SEBP3445
8N6951 GOVERNOR GP Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 4F-7957 C [1] BOLT (1/4-20X0.875-IN)  
2. 8N-0771 C [1] LEVER-GOVERNOR  
3. 6I-1098 CY [1] GOVERNOR GP  
4. 5P-0537 C [1] WASHER-HARD (7.2X14.5X2-MM THK)  
  C   CHANGE FROM PREVIOUS TYPE
  R   REMANUFACTURED PART MAY BE AVAILABLE
  Y   SEPARATE ILLUSTRATION
 

#SEBP34450142
 

4W-8180: GOVERNOR GP-ELECTRONIC

4W-8180 GOVERNOR GP-ELECTRONIC
S/N 6KA1-UP
PART OF 7W-0700 PANEL AR-CONTROL
FOR USAGE REFER TO CHART @@@@@ 4W-8000@@@@@
AN ATTACHMENT
i00380400 SEBP3445
4W8180 GOVERNOR GP-ELECTRONIC Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 131-5453 [1] CONTROL AS-ELECTRONIC GOVERNOR  
2. 4W-5971 [1] POTENTIOMETER (100-OHM)(ENGINE SPEED CONTROL)  
3. 4W-5972 [1] KNOB (ENGINE SPEED CONTROL)  
4. 7T-0037 [1] FUSE (0.75-AMPERE)  
5. 4W-8790 [1] BLOCK-FUSE  
 

#SEBP34450143
 

4W-8185: GOVERNOR GP-ELECTRONIC

4W-8185 GOVERNOR GP-ELECTRONIC
S/N 6KA1-UP
WITH PREREGULATOR
PART OF 7W-0700 PANEL AR-CONTROL
FOR USAGE REFER TO CHART @@@@@ 4W-8000@@@@@
AN ATTACHMENT
i00380405 SEBP3445
4W8185 GOVERNOR GP-ELECTRONIC Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 131-5453 [1] CONTROL AS-ELECTRONIC GOVERNOR  
2. 4W-5391 [1] BOX AS-GOVERNOR PREREGULATOR  
  7T-0037 [3] FUSE (0.75-AMPERE)  
3. 4W-5971 [1] POTENTIOMETER (100-OHM)(ENGINE SPEED CONTROL)  
4. 4W-5972 [1] KNOB (ENGINE SPEED CONTROL)  
 

#SEBP34450144
 

2W-4533: HOUSING AS-GOVERNOR DRIVE

2W-4533 HOUSING AS-GOVERNOR DRIVE
S/N 3FZ1-UP
GOVERNOR ADAPTER
PART OF 6N-1656 DRIVE GP-GOVERNOR
i05010971 SEBP3445
2W4533 HOUSING AS-GOVERNOR DRIVE Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 4H-8920 [1] DOWEL  
2. 4N-0898 [1] DOWEL-HOLLOW  
3. 2L-7103 [1] BEARING AS-NEEDLE  
4. 5P-0796 [1] SEAL-LIP TYPE  
5. 1F-4622 [1] BEARING AS-NEEDLE  
 

#SEBP34450145
 

4N-2117: HOUSING GP-FUEL PUMP

4N-2117 HOUSING GP-FUEL PUMP
S/N 3FZ1-UP
PART OF 4W-6073 PUMP GP-FUEL INJECTION
i00370045 SEBP3445
4N2117 HOUSING GP-FUEL PUMP Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 6N-7266 [1] SHAFT-PUMP IDLER  
2. 7N-0242 C [2] BUSHING  
3. 5B-9318 [1] BALL  
4. 1S-7984 [2] BUSHING  
5. 2M-2489 [2] SEAL-LIP TYPE  
6. 4M-1474 [6] PIN-LIFTER GUIDE  
7. 9L-9766 [2] PIN-PLUNGER LIFT  
8. 1P-0232 [12] BALL  
  1P-0234 [12] DOWEL  
9. 1S-2199 [1] DOWEL  
10. 9S-4160 [2] BUSHING  
11. 6N-8442 [1] BUSHING  
12. 7M-5839 [1] PLUG-CUP  
13. 6N-8441 [2] BUSHING  
14. 4N-0775 [2] DOWEL-HOLLOW  
15. 8L-6565 [1] PIN-SPRING  
  C   CHANGE FROM PREVIOUS TYPE
 

#SEBP34450146
 

3N-6668: LINES GP-FLEXIBLE FUEL

3N-6668 LINES GP-FLEXIBLE FUEL
S/N PTL1-UP
AN ATTACHMENT
i00366588 SEBP3445
3N6668 LINES GP-FLEXIBLE FUEL Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 2L-3331 C [2] CONNECTOR-PIPE  
2. 3N-6667 I [2] HOSE AS  
3. 003-2143 C [1] ELBOW  
  C   CHANGE FROM PREVIOUS TYPE
  I   REFER TO HYDRAULIC INFORMATION SYSTEM
 

#SEBP34450147
 

7W-1077: LINES GP-FUEL FILTER

7W-1077 LINES GP-FUEL FILTER
S/N 3FZ1-UP
Type 1
i00431505 SEBP3445
7W1077 LINES GP-FUEL FILTER Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 2P-7214 [2] ELBOW  
2. 6V-5049 [8] SEAL-O-RING  
3. 7J-4026 [1] ELBOW  
4. 6N-4379 I [1] HOSE AS  
5. 6N-4376 I [1] HOSE AS  
6. 6K-9194 [1] ELBOW-FLARED  
7. 030-7947 [3] ELBOW  
8. 030-7942 [1] ELBOW  
9. 0L-1351 [3] BOLT (3/8-16X0.875-IN)  
10. 5M-2894 [13] WASHER-HARD (10.2X18.5X2.5-MM THK)  
11. 8M-2773 [1] CLIP (LOOP)  
12. 7D-7233 [3] CLIP  
13. 9X-7378 [3] SEAL-O-RING  
14. 4W-1968 [1] DAMPER-SURGE  
15. 6V-8349 [1] TEE-O-RING PORT  
16. 6K-0806 [5] STRAP-CABLE  
17. 0S-1619 J [1] BOLT (3/8-16X3-IN)  
18. 0S-1590 P [1] BOLT (3/8-16X2-IN)  
  1B-4971 F [1] SPACER (0.406X1X1-IN THK)  
19. 2F-4967 [2] SPACER (10.5X19X5.512-MM THK)  
20. 0L-2070 L [1] BOLT (3/8-16X2.25-IN)  
21. 6N-4378 I [1] HOSE AS  
22. 6N-4377 I [1] HOSE AS  
23. 9S-4191 [1] PLUG (9/16-18-THD)  
24. 9S-4182 [1] PLUG (7/16-20-THD)  
25. 4D-7733 [1] CLIP  
26. 0S-1588 [2] BOLT (3/8-16X1.25-IN)  
  9S-8752 F [2] NUT-FULL (3/8-16-THD)  
27. 1A-2029 N [1] BOLT (3/8-16X1.125-IN)  
28. 0T-0065 [1] BOLT (3/8-16X3.5-IN)  
29. 8N-3962 [1] BRACKET AS-FUEL FILTER  
30. 4B-4043 [4] BOLT (5/8-11X1.375-IN)  
  5P-8247 F [4] WASHER-HARD (17X32X3.5-MM THK)  
31. 6N-3797 [1] JUNCTION BLOCK  
32. 0S-1591 [1] BOLT (3/8-16X1.5-IN)  
33. 0S-1608 P [1] BOLT (3/8-16X3.75-IN)  
  6H-7127 FP [1] SPACER (13/32X5/8X9/16-IN THK)  
34. 3B-1915 [1] BOLT (3/8-16X1.375-IN)  
35. 0S-1591 L [1] BOLT (3/8-16X1.5-IN)  
  F   NOT SHOWN
  I   REFER TO HYDRAULIC INFORMATION SYSTEM
  J   FOR USE WITH AFTERCOOLED ENGINES
  L   FOR USE WITH DRY MANIFOLDS
  N   FOR USE WITH NON-AFTERCOOLED ENGINES
  P   FOR USE WITH WATER-COOLED MANIFOLDS
 

#SEBP34450148
 

7W-1077: LINES GP-FUEL FILTER

7W-1077 LINES GP-FUEL FILTER
S/N 3FZ1-UP
Type 2
i02707054 SEBP3445
7W1077 LINES GP-FUEL FILTER Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 2P-7214 [2] ELBOW  
2. 6V-5049 [8] SEAL-O-RING  
3. 7J-4026 [1] ELBOW  
4. 6N-4379 I [1] HOSE AS  
5. 6N-4376 I [1] HOSE AS  
6. 6K-9194 [1] ELBOW-FLARED  
7. 030-7947 [3] ELBOW  
8. 030-7942 [1] ELBOW  
9. 0L-1351 [3] BOLT (3/8-16X0.875-IN)  
10. 5M-2894 [13] WASHER-HARD (10.2X18.5X2.5-MM THK)  
11. 8M-2773 [1] CLIP (LOOP)  
12. 7D-7233 [3] CLIP  
13. 9X-7378 [3] SEAL-O-RING  
14. 4W-1968 [1] DAMPER-SURGE  
15. 6V-8349 [1] TEE-O-RING PORT  
16. 6K-0806 [5] STRAP-CABLE  
17. 0S-1619 J [1] BOLT (3/8-16X3-IN)  
18. 0S-1590 P [1] BOLT (3/8-16X2-IN)  
19. 2F-4967 [2] SPACER (10.5X19X5.512-MM THK)  
20. 0L-2070 L [1] BOLT (3/8-16X2.25-IN)  
21. 103-7481 CI [1] HOSE AS  
22. 6N-4377 I [1] HOSE AS  
23. 9S-4191 [1] PLUG (9/16-18-THD)  
24. 9S-4182 [1] PLUG (7/16-20-THD)  
25. 4D-7733 [1] CLIP  
26. 0S-1588 [2] BOLT (3/8-16X1.25-IN)  
27. 1A-2029 N [1] BOLT (3/8-16X1.125-IN)  
28. 0T-0065 [1] BOLT (3/8-16X3.5-IN)  
29. 8N-3962 [1] BRACKET AS-FUEL FILTER  
30. 4B-4043 [4] BOLT (5/8-11X1.375-IN)  
31. 6N-3797 [1] JUNCTION BLOCK  
32. 0S-1591 [1] BOLT (3/8-16X1.5-IN)  
33. 0S-1608 P [1] BOLT (3/8-16X3.75-IN)  
34. 3B-1915 [1] BOLT (3/8-16X1.375-IN)  
35. 0S-1591 L [1] BOLT (3/8-16X1.5-IN)  
36. 1B-4971 [1] SPACER (0.406X1X1-IN THK)  
37. 9S-8752 [2] NUT-FULL (3/8-16-THD)  
38. 5P-8247 [4] WASHER-HARD (17X32X3.5-MM THK)  
39. 6H-7127 P [1] SPACER (13/32X5/8X9/16-IN THK)  
  C   CHANGE FROM PREVIOUS TYPE
  I   REFER TO HYDRAULIC INFORMATION SYSTEM
  J   FOR USE WITH AFTERCOOLED ENGINES
  L   FOR USE WITH DRY MANIFOLDS
  N   FOR USE WITH NON-AFTERCOOLED ENGINES
  P   FOR USE WITH WATER-COOLED MANIFOLDS
 

#SEBP34450149
 

7W-1077: LINES GP-FUEL FILTER

7W-1077 LINES GP-FUEL FILTER
S/N 3FZ1-UP
Type 3
i05762338 SEBP3445
7W1077 LINES GP-FUEL FILTER Parts scheme 7W1077 LINES GP-FUEL FILTER Parts scheme
  For full view, you need register

Parts for your 3412C GENERATOR SET:

CATERPILLAR SIS
Pos. Part No Qty Parts name Comments
1. 4W-1968 [1] DAMPER-SURGE  
2. 6H-7127 P [1] SPACER (13/32X5/8X9/16-IN THK)  
3. 6K-0806 [4] STRAP-CABLE  
4. 6N-3797 [1] JUNCTION BLOCK  
5. 6N-4376 I [1] HOSE AS  
6. 6N-4377 I [1] HOSE AS  
7. 6N-4379 I [1] HOSE AS  
8. 8N-3962 [1] BRACKET AS-FUEL FILTER  
  6N-3278 [1] BRACKET  
9. 8P-5115 [1] BRACKET  
10. 103-7481 I [1] HOSE AS  
11. 191-7805 C [3] ELBOW AS  
    (EACH INCLUDES)
  030-7947 [1] ELBOW  
  214-7568 [1] SEAL-O-RING  
12. 349-8383 C [1] ADAPTER AS  
  7J-4026 [1] ELBOW  
  214-7568 [1] SEAL-O-RING  
13. 0L-1143 CN [1] BOLT (3/8-16X2.5-IN)  
14. 0L-1351 C [4] BOLT (3/8-16X0.875-IN)  
15. 0L-1352 CL [1] BOLT (3/8-16X3.25-IN)  
16. 0S-1588 [2] BOLT (3/8-16X1.25-IN)  
17. 0S-1591 [1] BOLT (3/8-16X1.5-IN)  
18. 0S-1608 P [1] BOLT (3/8-16X3.75-IN)  
19. 0S-1619 CP [1] BOLT (3/8-16X3-IN)  
20. 0T-0065 [1] BOLT (3/8-16X3.5-IN)  
21. 1A-5964 CJ [1] BOLT (3/8-16X4.5-IN)  
22. 214-7566 [2] SEAL-O-RING  
23. 244-3712 C [1] PLUG AS  
  9S-4191 [1] PLUG (9/16-18-THD)  
  214-7568 [1] SEAL-O-RING  
24. 2F-4967 [2] SPACER (10.5X19X5.512-MM THK)  
25. 309-5130 C [1] PLUG AS  
  9S-4182 [1] PLUG (7/16-20-THD)  
  214-7566 [1] SEAL-O-RING  
26. 353-5103 C [1] ADAPTER AS  
  030-7942 [1] ELBOW  
  214-7568 [1] SEAL-O-RING  
27. 353-5108 C [2] ELBOW AS  
    (EACH INCLUDES)
  2P-7214 [1] ELBOW  
  214-7568 [1] SEAL-O-RING  
28. 3B-1915 [1] BOLT (3/8-16X1.375-IN)  
29. 4B-4043 [4] BOLT (5/8-11X1.375-IN)  
30. 4D-7733 [1] CLIP  
31. 5M-2894 C [12] WASHER-HARD (10.2X18.5X2.5-MM THK)  
32. 5P-8247 [4] WASHER-HARD (17X32X3.5-MM THK)  
33. 6K-9194 [1] ELBOW-FLARED  
34. 6V-8349 [1] TEE-O-RING PORT  
35. 6W-6672 [2] SPACER (10.5X20X38-MM THK)  
36. 7D-7233 [3] CLIP (LOOP)  
37. 8M-2773 C [2] CLIP (LOOP)(LOOP)  
38. 9S-8752 [3] NUT-FULL (3/8-16-THD)  
39. 9X-6458 [3] WASHER-HARD (10.2X22.5X3-MM THK)  
40. 6K-0806 J [1] STRAP-CABLE  
41. 0S-1591 L [1] BOLT (3/8-16X1.5-IN)  
  C   CHANGE FROM PREVIOUS TYPE
  I   REFER TO HYDRAULIC INFORMATION SYSTEM
  J   FOR USE WITH AFTERCOOLED ENGINES
  L   FOR USE WITH DRY MANIFOLDS
  N   FOR USE WITH NON-AFTERCOOLED ENGINES
  P   FOR USE WITH WATER-COOLED MANIFOLDS
 

Information:

Special Instruction
Troubleshooting Tips Will Help Maintain Steady Engine RPM{1264, 1280}
Troubleshooting Tips Will Help Maintain Steady Engine RPM{1264, 1280}

Caterpillar Parts SIS Catalog 3412C :

GOVERNOR AS-ELECTRONIC
7E-1233 GOVERNOR AS-ELECTRONIC
GOVERNOR AS-ELECTRONIC
7E-1232 GOVERNOR AS-ELECTRONIC
GOVERNOR AS-ELECTRONIC
4P-2788 GOVERNOR AS-ELECTRONIC
FILTER GP-FUEL
8H-7204 FILTER GP-FUEL
FILTER GP-FUEL
4N-6925 FILTER GP-FUEL
FASTENER GP-GOVERNOR
6N-4703 FASTENER GP-GOVERNOR
FASTENER GP-GOVERNOR
4N-9792 FASTENER GP-GOVERNOR
DRIVE GP-GOVERNOR & FUEL PUMP
6N-3195 DRIVE GP-GOVERNOR & FUEL PUMP
GOVERNOR GP
8N-6951 GOVERNOR GP
GOVERNOR GP-ELECTRONIC
4W-8180 GOVERNOR GP-ELECTRONIC
GOVERNOR GP-ELECTRONIC
4W-8185 GOVERNOR GP-ELECTRONIC
HOUSING AS-GOVERNOR DRIVE
2W-4533 HOUSING AS-GOVERNOR DRIVE
HOUSING GP-FUEL PUMP
4N-2117 HOUSING GP-FUEL PUMP
LINES GP-FLEXIBLE FUEL
3N-6668 LINES GP-FLEXIBLE FUEL
LINES GP-FUEL FILTER
7W-1077 LINES GP-FUEL FILTER
LINES GP-FUEL FILTER
7W-1077 LINES GP-FUEL FILTER

Truck sale:

Caterpillar 3412C
 
Caterpillar 3412C
- Stationary Generator Sets
MACALLISTER MACHINERY CO., INC
Caterpillar 3412C, Stationary Generator Sets, Construction
95,000 
Caterpillar 3412C, Stationary Generator Sets, Construction
- Stationary Generator Sets
MACALLISTER MACHINERY CO., INC
Caterpillar 3412C, Stationary Generator Sets, Construction
145,000 
Caterpillar 3412C, Stationary Generator Sets, Construction
- Stationary Generator Sets
MACALLISTER MACHINERY CO., INC
 
74,900 
Caterpillar 3412CEP, Stationary Generator Sets, Construction


Caterpillar 3412C
 
Caterpillar 3412C
- Marine Propulsion / Auxiliary Engines
HAWTHORNE POWER SYSTEMS
Back to top
Contacts Request list Affiliate disclosure
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.