0996117 SHIM Caterpillar parts
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
Rating:
Alternative (cross code) number:
CA0996117
099-6117
0996117
CA0996117
099-6117
0996117
Weight: 0.01 pounds 0 kg.
Information:
ID
20
mm
MATERIAL THICKNESS
1.35
mm
OD
29
mm
EXCAVATOR, WHEELED EXCAVATOR,
Compatible equipment models: 0996117:
EXCAVATOR
318C
319C
320 L
320C
320C FM
320C L
320D
320D FM
320D FM RR
320D GC
320D L
320D LN
320D LRR
320D RR
320D2
320D2 GC
320D2 L
320E
320E L
320E LN
320E LRR
320E RR
321C
321D LCR
322C
322C FM
323D L
323D LN
323D SA
323D2 L
323E L
324D
324D FM
324D FM LL
324D L
324D LN
324E
324E L
324E LN
325C
325C FM
325D
325D FM
325D FM LL
325D L
325D MH
326D L
328D LCR
329D
329D L
329D LN
329E
329E L
329E LN
E180
E200B
E240
E240C
EL240B
M325D L MH
M325D MH
LOGGER
322C
Information:
Illustration 1 g01289178
Connections of "Secondary Steer Right" solenoid
This diagnostic code is associated with the "secondary steer right" solenoid. The FMI 05 means that the Transmission/Chassis ECM has determined that the current for the solenoid circuit is below normal.Conditions that could cause this diagnostic code to be activated are listed below:
The energize circuit of the solenoid is open.
The return circuit of the solenoid is open.
The solenoid has failed.
The ECM has failed. This is unlikely. Before performing this procedure, inspect the harness connectors that are involved in the circuit. Poor connections can often be the cause of a problem in an electrical circuit. Verify that all connections in the circuit are clean, that all connections are secure and that all connections are in good condition. If a problem with a connection is found, correct the problem and verify that this diagnostic code is active before performing this procedure. Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected.Note: The resistance of the solenoid coil should be 2.2 .2 ohms at 25 °C (77.0 °F).Test Step 1. CHECK THE SOLENOID
Disconnect the solenoid from the machine harness.
At the machine harness connector for the solenoid, place a jumper wire from contact 1 (wire X755-WH(White)) to contact 2 (wire 925-YL(Yellow)).
Turn the disconnect switch and the key start switch to the ON position. Do not start the engine.
Observe the status of the CID 2176 FMI 05 diagnostic code. Expected Result:The CID 2176 FMI 05 diagnostic code is no longer active. A CID 2176 FMI 06 diagnostic code becomes active when the jumper wire is connected.Results:
YES - The CID 2176 FMI 05 diagnostic code is no longer active. A CID 2176 FMI 06 diagnostic code becomes active when the jumper wire is connected. The solenoid has failed.Repair: The solenoid has failed. Repeat this Test Step "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid. Verify that the new solenoid corrects the problem.STOP
NO - The CID 2176 FMI 05 diagnostic code remains active. The jumper wire does not affect the status of the diagnostic code. The solenoid is not causing the problem. Proceed to Test Step 2.Test Step 2. CHECK THE CIRCUIT FOR AN OPEN
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness connector J1 from the Transmission/Chassis ECM.
The jumper wire that was installed in the previous Test Step remains in place.
At the machine harness connector J1 for the Transmission/Chassis ECM, measure the resistance from contact J1-54 (wire 925-YL(Yellow)) to the contact J1-68 (wire X755-WH(White)). Expected Result:The resistance measurement is less than 5 ohms.Results:
OK - The measurement of the resistance is less than 5 ohms. The circuit is not open in the machine harness. Proceed to Test Step 3.
NOT OK - The resistance measurement is greater than 5000 ohms. The resistance measurement is not correct. There is an open or a bad connection in the machine harness.Repair: A
Cat SIS web machinery list:
Parts shim Caterpillar catalog:
1661490
SHIM
314C, 314D CR, 314D LCR, 314E CR, 314E LCR, 324D, 325C, 330C, 330C FM, 330C L, 330C MH, 330D, 330D FM, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E H, 336E L, 336E LH, 3...
314C, 314D CR, 314D LCR, 314E CR, 314E LCR, 324D, 325C, 330C, 330C FM, 330C L, 330C MH, 330D, 330D FM, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E H, 336E L, 336E LH, 3...
1661489
SHIM
324D, 325C, 325C FM, 325C L, 325D, 325D FM, 325D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330C, 330C FM, 330C L, 330C MH, 330D, 330D FM, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2,...
324D, 325C, 325C FM, 325C L, 325D, 325D FM, 325D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330C, 330C FM, 330C L, 330C MH, 330D, 330D FM, 330D L, 330D LN, 330D MH, 336D, 336D L, 336D LN, 336D2,...
0996018
SHIM
320B FM LL, 320C, 320C FM, 322B L, 322C, 322C FM, 324D FM, 324D FM LL, 325B, 325C, 325C L, 330C L, E300B
320B FM LL, 320C, 320C FM, 322B L, 322C, 322C FM, 324D FM, 324D FM LL, 325B, 325C, 325C L, 330C L, E300B
0965741
SHIM
320 L, 320B, 320B FM LL, 320C, 320C FM, 320C L, 320N, 321C, 322, 322B, 322C, 325B, 325B L, 325C, 325C L, 328D LCR, E200B, E300B, E450
320 L, 320B, 320B FM LL, 320C, 320C FM, 320C L, 320N, 321C, 322, 322B, 322C, 325B, 325B L, 325C, 325C L, 328D LCR, E200B, E300B, E450
7Y1759
SHIM
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
7Y1760
SHIM
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
7Y1761
SHIM
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
7Y1762
SHIM
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
320 L, 320B, 320B L, 320N, 321B, 345B, 345B L, OEMS
2676863
SHIM
320D, 320D FM, 320D FM RR, 322C, 323D LN, 323D SA, 323E L, 324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 325C, 325D, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, OEMS
320D, 320D FM, 320D FM RR, 322C, 323D LN, 323D SA, 323E L, 324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 325C, 325D, 325D L, 325D MH, 326D L, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, OEMS
4I6604
SHIM
115, 324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 325B L, 325C, 325D, 325D L, 326D L, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330, 330 FM L, 330 L, 330B, 330B L, 330C, 330C L, 330D, 3...
115, 324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 325B L, 325C, 325D, 325D L, 326D L, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330, 330 FM L, 330 L, 330B, 330B L, 330C, 330C L, 330D, 3...
4I6605
SHIM
115, 324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 325B L, 325C, 325D, 325D L, 326D L, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330, 330 FM L, 330 L, 330B, 330B L, 330C, 330C L, 330D, 3...
115, 324D, 324D L, 324D LN, 324E, 324E L, 324E LN, 325B L, 325C, 325D, 325D L, 326D L, 328D LCR, 329D, 329D L, 329D LN, 329E, 329E L, 329E LN, 330, 330 FM L, 330 L, 330B, 330B L, 330C, 330C L, 330D, 3...
4I4039
SHIM
324D L, 325D L, 328D LCR, 329D L, 330D, 330D L, 330D LN, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E H, 336E L, 336E LN, 340D L, 340D2 L, 345B II, 345B L, 345C, 345C L, 345D, 345D L, 345D L VG, ...
324D L, 325D L, 328D LCR, 329D L, 330D, 330D L, 330D LN, 336D, 336D L, 336D LN, 336D2, 336D2 L, 336E, 336E H, 336E L, 336E LN, 340D L, 340D2 L, 345B II, 345B L, 345C, 345C L, 345D, 345D L, 345D L VG, ...
0996118
SHIM
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
0996119
SHIM
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
0996121
SHIM
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
0996122
SHIM
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
0996124
SHIM
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
0996123
SHIM
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
318C, 319C, 320 L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321C, 321D LCR, 32...
1992313
SHIM
303, 304
303, 304
4J7385
SHIM
215, 245, 318C, 319C, 320 L, 320B, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 32...
215, 245, 318C, 319C, 320 L, 320B, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 32...
1850403
SHIM
318C, 320C, 321C, 322C, 322C FM, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325C FM, 325D, 325D L, 329D, 329D L, 329D LN, 330C, 330D, 330D L, 330D LN, 336D L
318C, 320C, 321C, 322C, 322C FM, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325C FM, 325D, 325D L, 329D, 329D L, 329D LN, 330C, 330D, 330D L, 330D LN, 336D L
1850402
SHIM
318C, 320C, 321C, 322C, 322C FM, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325C FM, 325D, 325D L, 329D, 329D L, 329D LN, 330C, 330D, 330D L, 330D LN, 336D L
318C, 320C, 321C, 322C, 322C FM, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325C FM, 325D, 325D L, 329D, 329D L, 329D LN, 330C, 330D, 330D L, 330D LN, 336D L
1850401
SHIM
318C, 320C, 321C, 322C, 322C FM, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325C FM, 325D, 325D L, 329D, 329D L, 329D LN, 330C, 330D, 330D L, 330D LN, 336D L
318C, 320C, 321C, 322C, 322C FM, 323D L, 323D LN, 324D, 324D L, 324D LN, 325C, 325C FM, 325D, 325D L, 329D, 329D L, 329D LN, 330C, 330D, 330D L, 330D LN, 336D L
5I4616
SHIM
318C, 320B L, 320C, 320C FM, 320C L, 321B, 321C, 322C, 325C L, 330D L
318C, 320B L, 320C, 320C FM, 320C L, 321B, 321C, 322C, 325C L, 330D L