0964306 SPACER Caterpillar parts
320 L, 320C, 994F, E200B, E240, EL240B
Rating:
Alternative (cross code) number:
CA0964306
096-4306
0964306
CA0964306
096-4306
0964306
Weight: 0.30 pounds 0 kg.
Information:
ID
38.23
mm
MATERIAL THICKNESS
10.5
mm
OD
58.6
mm
EXCAVATOR, WHEEL LOADER,
Compatible equipment models: 0964306:
Number on catalog scheme:
None
For full view, you need register
Information:
Illustration 1 g06104390
Schematic for the demand fan solenoid
This diagnostic code is associated with the demand fan solenoid. The FMI 03 means that the ECM has detected an above normal voltage in the solenoid circuit.Conditions that could cause this diagnostic code to be activated are:
The energize circuit of the solenoid is shorted to another voltage source.
The ECM has failed. The failure of the ECM is unlikely.Note: Before performing this procedure, inspect the harness connectors that are involved in the circuit. Poor connections can often be the cause of a problem in an electrical circuit. Verify that all connections in the circuit are clean, secure, and in good condition. If a problem with a connection is found, correct the problem and verify that this diagnostic code is active before performing this procedure.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected.Note: The resistance of the solenoid coil should be 7.3 ohms at 20 °C (68.0 °F).Test Step 1. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT
Disconnect the negative battery cable and turn the key start switch to the OFF position.
Disconnect the machine harness connector from the solenoid. Disconnect the machine harness connectors J1 from the ECM.
At the machine harness ECM connectors, measure the resistance from contact J1-62 (wire H746-YL(Yellow)) to all the other contacts that are used in the J1 connectors for the ECM.Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
YES - Each resistance measurement is greater than 5000 ohms. The resistance measurement does not indicate a short in the machine harness. Proceed to Test Step 2.
NO - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness.Repair: The short is between wire H746-YL(Yellow)and the circuit that has a low-resistance measurement.For information on testing for short circuits and finding short circuits, refer to Testing and Adjusting, "Wiring Harness (Short Circuit) - Test". Repair the machine harness or replace machine harness.STOPTest Step 2. CHECK THE OPERATION OF THE ECMThe key start switch remains in the OFF position. The machine harness connectors for the solenoid and the ECM remain disconnected.
At the machine harness connector J1 for the ECM, use a 151-6320 Removal Tool to remove the solenoid energize wire H746-YL(Yellow)and socket at contact J1-62 from the harness connector.
Reconnect the machine harness J1 and J2 connectors to the ECM.
Reconnect the negative battery cable and Turn the key start switch to the ON position.
Observe the status of the active CID 1076 FMI 03 diagnostic code.Expected Result:The CID 1076 FMI 03 diagnostic code is no longer active. A CID 1076 FMI 05 diagnostic code is now active.Results:
YES - The CID 1076 FMI 03 diagnostic code is no longer active. A CID 1076 FMI 05 diagnostic code has been activated after the solenoid energize circuit was disconnected. The ECM has responded correctly to the open circuit condition in the solenoid circuit. Reinstall the disconnected solenoid energize wire back
Caterpillar parts catalog:
Parts spacer Caterpillar catalog:
1090, 1190, 1190T, 1290T, 1390, 2290, 2390, 2391, 2491, 2590, 315C, 315D L, 318B, 318C, 318E L, 319C, 319D, 319D L, 319D LN, 320 L, 320B, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320...
315C, 315D L, 318B, 318C, 318E L, 319C, 319D, 319D L, 319D LN, 320 L, 320B, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 3...
305.5, 305.5E, 306, 307C, 307D, 307E, 308E, 308E CR, 308E SR, 308E2 CR, 312E, 312E L, 315B, 316E L, 317B LN, 318B, 318C, 318E L, 319C, 320B, 320B FM LL, 320B U, 320C, 320C FM, 320C L, 320D, 320D FM, 3...
311C, 313D2 LGP, 315C, 315D L, 316E L, 318B, 318C, 318D L, 318D2 L, 318E L, 319C, 319D, 319D L, 319D LN, 320 L, 320B, 320B FM LL, 320B L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320...
311, 311B, 311C, 311D LRR, 312B, 312C, 312C L, 312D, 312D L, 313D, 314C, 314D CR, 314D LCR, 315D L, 318C, 318D L, 319C, 319D, 319D L, 319D LN, 320 L, 320B, 320C, 320C FM, 320C L, 320D, 320D FM, 320D F...
311, 311B, 311C, 311D LRR, 312, 312B, 312C, 312C L, 312D, 312D L, 313D, 314C, 314D CR, 314D LCR, 315D L, 318C, 318D L, 319C, 319D, 319D L, 319D LN, 320, 320 L, 320B, 320B L, 320C, 320C FM, 320C L, 320...
315C, 315D L, 318C, 319C, 319D, 319D LN, 320 L, 320B, 320B FM LL, 320B L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E,...
312C, 312D, 312E, 312E L, 314E CR, 314E LCR, 315C, 315D L, 316E L, 318C, 318E L, 319C, 319D, 320C, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 322C, 323D L, 323D LN, 323E L, 324D, 324D L, 324D LN, 324E,...
24H, 5110B, 572R, 572R II, 583R, 583T, 587R, 587T, 621G, 623G, 627G, 631D, 631G, 637G, 657B, 769D, 771D, 814F, 814F II, 815F, 815F II, 816F, 816F II, 824C, 824G II, 824H, 824K, 825G II, 825H, 825K, 82...
826K, 834H, 836H, 836K, 916, 918F, 924F, 926, 926A, 928F, 931C II, 933, 933C, 936, 936F, 939, 939C, 950B, 950B/950E, 950F II, 962G, 963, 963B, 963C, 963D, 966D, 966F II, 980C, 988B, 994, 994D, 994F, 9...
322, 322 FM L, 322 LN, 322B L, 322B LN, 325, 325 L, 325 LN, 325B, 325B L, 330, 330 FM L, 330 L, 330B, 330B L, 350, 375, 375 L, 5080, E240C, E300B, EL240B, M325B, TK1051, W330B
322, 322 FM L, 322 LN, 322B L, 322B LN, 325, 325 L, 325 LN, 325B, 325B L, 330, 330 FM L, 330 L, 330B, 330B L, 350, 375, 375 L, 5080, E240C, E300B, EL240B, M325B, TK1051, W330B
6D6433
SPACER
12F, 14E, 994F
12F, 14E, 994F
1692679
SPACER
994F, 994H
994F, 994H
2102204
SPACER
966G II, 972G II
966G II, 972G II
2183806
SPACER
950G II, 962G II, 966G II, 972G II, CP-573E, CP-663E, CS-563E, CS-583E, CS-663E, CS-683E
950G II, 962G II, 966G II, 972G II, CP-573E, CP-663E, CS-563E, CS-583E, CS-663E, CS-683E
1905629
SPACER
966G II, 972G II
966G II, 972G II
1584803
SPACER
980G II
980G II
1511702
SPACER
854K, 992K
854K, 992K
2822424
SPACER-SPECIAL
854K, 992K
854K, 992K
2642293
SPACER
992K, 993K
992K, 993K
9C6034
SPACER
5110B, 5130, 5130B, 5230, 5230B, 854K, 992K, 993K, PR-450C
5110B, 5130, 5130B, 5230, 5230B, 854K, 992K, 993K, PR-450C
2929604
SPACER
854K, 992K
854K, 992K
3084925
SPACER
988H, 993K
988H, 993K