4P8525 SPACER Caterpillar parts
120H, 135H, 140H, 143H, 14H, 160H, 163H, 16H, 3054, 3116, 3126, 3126B, 3126E, 3176, 3176B, 3176C, 3196, 345B, 345B II, 345B II MH, 345B L, 365B, 365B II, 365B L, 480, 572R II, 65E, 725, 730, 75, 75C, ...
Rating:
Alternative (cross code) number:
CA4P8525
4P-8525
4P8525
CA4P8525
4P-8525
4P8525
Weight: 0.07 pounds 0 kg.
Information:
ID
9
mm
MATERIAL THICKNESS
30
mm
OD
16
mm
ARTICULATED TRUCK, WHEELED EXCAVATOR,
Compatible equipment models: 4P8525:
Information:
Use this procedure to troubleshoot a problem with the air shutoff system. Also, use this procedure if one of the following diagnostic codes is active or easily repeated.
Table 1
J1939 Code and Description CDL Code and Description Comments
3667-2
Engine Air Shutoff Status : Erratic, Intermittent, or Incorrect E2088 (1)
Air Intake Shutoff Detection Circuit Detected but Not Installed The inlet air shutoff valve switch has been used, but the inlet air shutoff valve feature is set as "Disabled" in the configuration parameters.
3667-31
Engine Air Shutoff Status E2087 (3)
Air Intake Shutoff Closed The engine air shutoff valve has been activated. The engine was shutdown and injection is disabled. Perform a key cycle and reset the air inlet shutoff system. Note: The "Air Shutoff" parameter must be set to "Enabled" in order for the Electronic Control Module (ECM) to energize the air shutoff solenoid.
Illustration 1 g06171803
Table 2
Troubleshooting Test Steps Values Results
1. Check for Codes
A. Connect Cat® Electronic Technician (ET) to the service tool connector.
B. Determine if a code is active or logged.
Codes
Result: A code is active or logged.
Proceed to Test Step 2.
2. Check the Position of the Air Shutoff Doors
Air Shutoff
Result: The air shutoff doors are open.
Proceed to Test Step 3.
Result: The air shutoff doors are closed.
Repair: Manually open the air shutoff doors. Power Cycle the Electronic Control Module (ECM).
If the problem is not resolved, proceed to Test Step 3.
3. Check the Voltage of the Battery
A. Turn the keyswitch to the ON position.
B. Measure the voltage between the following:
- Terminal EA-T26 (20 Amp breaker) and engine ground
Battery Voltage
Result: The voltage is equal to the battery voltage.
Proceed to Test Step 4.
Result: The voltage is not equal to the battery voltage.
Repair: Reset the breaker if tripped. Repair or replace the problems found with the circuit breaker or terminal connection.
If the problem is not resolved, proceed to Test Step 4.
4. Check the Voltage at the Left-side Air Shutoff Proximity Sensor Connector
A. Disconnect the sensor connector from the wiring
Table 1
J1939 Code and Description CDL Code and Description Comments
3667-2
Engine Air Shutoff Status : Erratic, Intermittent, or Incorrect E2088 (1)
Air Intake Shutoff Detection Circuit Detected but Not Installed The inlet air shutoff valve switch has been used, but the inlet air shutoff valve feature is set as "Disabled" in the configuration parameters.
3667-31
Engine Air Shutoff Status E2087 (3)
Air Intake Shutoff Closed The engine air shutoff valve has been activated. The engine was shutdown and injection is disabled. Perform a key cycle and reset the air inlet shutoff system. Note: The "Air Shutoff" parameter must be set to "Enabled" in order for the Electronic Control Module (ECM) to energize the air shutoff solenoid.
Illustration 1 g06171803
Table 2
Troubleshooting Test Steps Values Results
1. Check for Codes
A. Connect Cat® Electronic Technician (ET) to the service tool connector.
B. Determine if a code is active or logged.
Codes
Result: A code is active or logged.
Proceed to Test Step 2.
2. Check the Position of the Air Shutoff Doors
Air Shutoff
Result: The air shutoff doors are open.
Proceed to Test Step 3.
Result: The air shutoff doors are closed.
Repair: Manually open the air shutoff doors. Power Cycle the Electronic Control Module (ECM).
If the problem is not resolved, proceed to Test Step 3.
3. Check the Voltage of the Battery
A. Turn the keyswitch to the ON position.
B. Measure the voltage between the following:
- Terminal EA-T26 (20 Amp breaker) and engine ground
Battery Voltage
Result: The voltage is equal to the battery voltage.
Proceed to Test Step 4.
Result: The voltage is not equal to the battery voltage.
Repair: Reset the breaker if tripped. Repair or replace the problems found with the circuit breaker or terminal connection.
If the problem is not resolved, proceed to Test Step 4.
4. Check the Voltage at the Left-side Air Shutoff Proximity Sensor Connector
A. Disconnect the sensor connector from the wiring
Cat SIS web machinery list:
Parts spacer Caterpillar catalog:
9D5943
SPACER
14G, 14H, 14H NA, 14M
14G, 14H, 14H NA, 14M
7D8857
SPACER
16G, 16H, 16H NA
16G, 16H, 16H NA
8X4869
SPACER
120H, 120H ES, 120H NA, 120K, 120K 2, 135H, 135H NA
120H, 120H ES, 120H NA, 120K, 120K 2, 135H, 135H NA
5I8405
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8406
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8407
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8408
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8409
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8410
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8411
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8412
SPACER-SPRING
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330 L, 330B, 330B L, 345B, 345B L, W330B
5I8413
SPACER-SPRING
330, 330 FM L, 330B L, 345B, 345B L, W330B
330, 330 FM L, 330B L, 345B, 345B L, W330B
4P0489
SPACER
16M, 24M, 349E, 349E L, 349E L HVG, 349E L VG, 3512C, 3516B, 374F L, 390F L, 621H, 623H, 627H, 75, 75C, 789D, 793D, 793F, 793F AC, 793F CMD, 793F OEM, 793F-XQ, 795F AC, 795F XQ, 85C, D6R, D6R II, D6R ...
16M, 24M, 349E, 349E L, 349E L HVG, 349E L VG, 3512C, 3516B, 374F L, 390F L, 621H, 623H, 627H, 75, 75C, 789D, 793D, 793F, 793F AC, 793F CMD, 793F OEM, 793F-XQ, 795F AC, 795F XQ, 85C, D6R, D6R II, D6R ...
8K3815
SPACER
235, 65, 65C, 75, 75C, 85C
235, 65, 65C, 75, 75C, 85C
8V3032
SPACER
216, 236, 267, 287, 65, 65C, 65E, 75, 75C, 75D, 75E, 85C, 85D, 85E, 95E, 988F II
216, 236, 267, 287, 65, 65C, 65E, 75, 75C, 75D, 75E, 85C, 85D, 85E, 95E, 988F II
4P4369
SPACER
120K, 120K 2, 12H, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 140G, 140H, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H, 14M, 160H, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H, 16H, 16M, 2290, 23...
120K, 120K 2, 12H, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 140G, 140H, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H, 14M, 160H, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H, 16H, 16M, 2290, 23...
1V8230
SPACER
140H, 143H, 14H, 160H, 163H, 16H, 235D, 3176, 3176B, 3176C, 3196, 3304, 3304B, 3306, 3306B, 330B L, 345B, 345B II, 345B II MH, 345B L, 3512C, 365B, 365B II, 365B L, 480, 572R II, 65E, 7271, 75, 75C, 7...
140H, 143H, 14H, 160H, 163H, 16H, 235D, 3176, 3176B, 3176C, 3196, 3304, 3304B, 3306, 3306B, 330B L, 345B, 345B II, 345B II MH, 345B L, 3512C, 365B, 365B II, 365B L, 480, 572R II, 65E, 7271, 75, 75C, 7...
7C3081
SPACER
140H, 143H, 14H, 14M, 160H, 163H, 16H, 16M, 3176, 3176B, 3176C, 3196, 345B, 345B II, 345B II MH, 345B L, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L, 349E L HVG, 349E L ...
140H, 143H, 14H, 14M, 160H, 163H, 16H, 16M, 3176, 3176B, 3176C, 3196, 345B, 345B II, 345B II MH, 345B L, 345C, 345C L, 345C MH, 345D, 345D L, 345D L VG, 349D, 349D L, 349E, 349E L, 349E L HVG, 349E L ...
4M1751
SPACER
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 30/30, 517, 527, 561M, 561N, 583...
120H, 120H ES, 120H NA, 120K, 120K 2, 12H, 12H ES, 12H NA, 12K, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 30/30, 517, 527, 561M, 561N, 583...
4S5719
SPACER
120, 120G, 120K, 120K 2, 12K, 130G, 140, 140K, 140K 2, 14H, 160K, 1673B, 1693, 16G, 16H, 215, 225, 245, 3114, 3116, 3126, 3126B, 3126E, 3176B, 3306, 3306C, 3406, 3406B, 3406C, 3406E, 3408, 3408C, 3408...
120, 120G, 120K, 120K 2, 12K, 130G, 140, 140K, 140K 2, 14H, 160K, 1673B, 1693, 16G, 16H, 215, 225, 245, 3114, 3116, 3126, 3126B, 3126E, 3176B, 3306, 3306C, 3406, 3406B, 3406C, 3406E, 3408, 3408C, 3408...
7T4952
SPACER
65, 65C, 65E, 75, 75C, 75D, 75E, 85C, 85D, 85E, 95E
65, 65C, 65E, 75, 75C, 75D, 75E, 85C, 85D, 85E, 95E
3W8846
SPACER
65, 65C, 65E, 70C, 75, 75C, 75D, 75E, 85C, 85D, 85E, 95E
65, 65C, 65E, 70C, 75, 75C, 75D, 75E, 85C, 85D, 85E, 95E
6I1418
SPACER
10-20B, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AW...
10-20B, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 135H NA, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AW...
7E0283
SPACER
65, 65C, 75, 75C, 75D
65, 65C, 75, 75C, 75D