1528732 SPRING GP-RECOIL Caterpillar parts
OEMS
Rating:
Alternative (cross code) number:
CA1528732
152-8732
1528732
CA1528732
152-8732
1528732
UNDERCARRIAGE,
Compatible equipment models: 1528732:
Number on catalog scheme:
1
For full view, you need register
Information:
You must read and understand the warnings and instructions contained in the Safety section of this manual before performing any operation or maintenance procedures.When a generator is in storage, moisture condenses in the windings. To minimize condensation, always put the generator in a dry storage area. If possible, use space heaters to keep generator windings dry during storage.After Storage
After removing the generator from storage, perform an insulation resistance check of the main stator windings. Use a megohmmeter (megger) to preform this check. Compare the resistance reading with the reading made prior to storage. If the readings are lower than specified in the Service Manual, it may be necessary to dry the windings.The insulation resistance check is described in Special Instruction SEHS9124. A reading of one megohm or less indicates that the winding has absorbed too much moisture.To remove moisture caused by high humidity, use one of the following methods to make the generator dry.1. Energize space heaters in generator, if so equipped.2. Put the generator in an oven at a temperature of not more than 85°C (185°F) for four hours.
If an oven is used for drying, use a forced air type rather than a radiant type. Radiant ovens can cause localized overheating.
3. Space heaters of the same type used in marine applications, can be installed on generators. (See the Parts Book.) These heaters heat the windings to remove moisture and should be connected at all times in high humidity conditions whenever the generator is not running.4. Use a canvas enclosure around the generator and heating lamps to increase the temperature. Make an opening in the top for release of moisture.5. Send a low voltage current through the windings to increase the temperature of the windings. Do not exceed 85°C (185°F).If the resistance test reads under one megohm after the drying, or if it goes below one megohm shortly after drying, contact your Caterpillar dealer. The insulation has deteriorated and should be reconditioned.
After removing the generator from storage, perform an insulation resistance check of the main stator windings. Use a megohmmeter (megger) to preform this check. Compare the resistance reading with the reading made prior to storage. If the readings are lower than specified in the Service Manual, it may be necessary to dry the windings.The insulation resistance check is described in Special Instruction SEHS9124. A reading of one megohm or less indicates that the winding has absorbed too much moisture.To remove moisture caused by high humidity, use one of the following methods to make the generator dry.1. Energize space heaters in generator, if so equipped.2. Put the generator in an oven at a temperature of not more than 85°C (185°F) for four hours.
If an oven is used for drying, use a forced air type rather than a radiant type. Radiant ovens can cause localized overheating.
3. Space heaters of the same type used in marine applications, can be installed on generators. (See the Parts Book.) These heaters heat the windings to remove moisture and should be connected at all times in high humidity conditions whenever the generator is not running.4. Use a canvas enclosure around the generator and heating lamps to increase the temperature. Make an opening in the top for release of moisture.5. Send a low voltage current through the windings to increase the temperature of the windings. Do not exceed 85°C (185°F).If the resistance test reads under one megohm after the drying, or if it goes below one megohm shortly after drying, contact your Caterpillar dealer. The insulation has deteriorated and should be reconditioned.
Caterpillar SIS machinery equipment:
Caterpillar parts catalog:
Parts spring Caterpillar catalog:
330, 330 FM L, 330 L, 330B, 330B L, OEMS
311, 311B, 312, 312B, 315, 315B, 315B L, 317, OEMS
318B, 320B, 320B L, OEMS
315B FM L, 317B LN, 318B, 320 L, 320N, OEMS
318B, 318C, 318E L, 319D, 319D L, 319D LN, 320 L, 320C, 320C FM, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 320N, 321C, 321D LCR, 32...
311C, 313D2 LGP, 315C, 315D L, 316E L, 318B, 318C, 318D L, 318D2 L, 318E L, 319C, 319D, 319D L, 319D LN, 320B, 320B FM LL, 320B L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 32...
315D L, 316E L, 318C, 318D L, 318E L, 319C, 319D, 319D L, 319D LN, 320 L, 320B, 320B L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, ...
320 L, 320B, 320B FM LL, 322B L, 325, 325 L, 325 LN, 325B, 325B L, OEMS
1090, 1190, 1190T, 1390, 2290, 2390, 322B L, 322C, 322C FM, 324D FM, 325 L, 325B L, 325C, 325C FM, 325C L, 511, 521, OEMS, TK711, TK721, TK741
322, 322 FM L, 322B, 322B L, 322B LN, OEMS
330, 330 FM L, 330B L, 330C FM, 330C L, 330C MH, 350, OEMS, TK1051
330, 330 FM L, 330 L, 330B, 330B L, OEMS
2487170
SPRING GP-RECOIL
330D L, 330D MH, 336D L, 336D LN, 340D L, 340D2 L, 521B
330D L, 330D MH, 336D L, 336D LN, 340D L, 340D2 L, 521B
2394335
SPRING GP-RECOIL
345B II, 345C, 345C L, 365B, 365B II, 365C, 365C L, 365C L MH
345B II, 345C, 345C L, 365B, 365B II, 365C, 365C L, 365C L MH
2487308
SPRING GP-RECOIL
365C L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L
365C L, 385C, 385C FS, 385C L, 385C L MH, 390D, 390D L
216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3, 242D, 246C, 247, 247B, 247B3, 248, 252B, 252B3, 256C, 257B, 257B3, 257D, 259B3, 259D, 262C, 267, 267B, 268B, 272C, 277C, ...
2945339
SPRING GP-RECOIL
308D, 308E, 308E CR, 308E SR, 308E2 CR
308D, 308E, 308E CR, 308E SR, 308E2 CR
5J4953
SPRING GP
D8H, D9G, D9H, D9L
D8H, D9G, D9H, D9L
311, 311B, 312, 312B, 312B L, 313B, E110B, E120B
4152796
SPRING GP-GAS
246D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP
246D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP
8X5433
SPRING GP
621H, 621K, 627E, 627F, 627G, 627H, 627K, 627K LRC, 637E, 637G, 657E, 657G
621H, 621K, 627E, 627F, 627G, 627H, 627K, 627K LRC, 637E, 637G, 657E, 657G
1453011
SPRING GP-RECOIL
365B II, 365C, 385B, 385C, 385C FS, 385C L, 5090B
365B II, 365C, 385B, 385C, 385C FS, 385C L, 5090B
1528562
SPRING GP-RECOIL
1290T, 1390, 2491, 2590, 330B L, 330C, 522B, 532, 541, 541 2, OEMS, TK732
1290T, 1390, 2491, 2590, 330B L, 330C, 522B, 532, 541, 541 2, OEMS, TK732