4190278 SUPPORT AS Caterpillar parts
316E L, 318E L
Rating:
Alternative (cross code) number:
CA4190278
419-0278
4190278
CA4190278
419-0278
4190278
Weight: 3 pounds 1 kg.
EXCAVATOR,
Number on catalog scheme:
9
For full view, you need register
Information:
Illustration 1 g00488507
System Schematic For Run Relay (RR)The contacts for the run relay (RR) are available for use by the customer. The RR is located within the relay module. The GSC activates the run relay (RR) during engine cranking and running.Note: Whenever the GSC activates the RR, "K5" is shown on the lower display. "K5" is also shown on the lower display when the GSC attempts to activate the crank terminate relay. When the RR is not activated, "K5" is not shown.ProcedureThe possible cause of this diagnostic code is an open coil or a shorted coil of the RR.The following response is the system response to this fault while the RR is activated:
If a CID 445 occurs, then any equipment that is connected to RM-24 is deactivated. Also, any equipment that is connected to RM-23 is activated.The following response is the system response to this fault while the RR is not activated:
If a CID 445 occurs, then any equipment that is connected to RM-24 is not activated. Also, any equipment that is connected to RM-23 remains activated.The GSC treats this diagnostic code as an alarm fault. Active alarm faults are shown on the display when the alarm codes key is pressed. Also, the active alarm faults are shown when the ECS is in any position except the OFF/RESET position. Clear the diagnostic code from the fault log after troubleshooting is complete.
Check the status of the diagnostic code (Active/Inactive).
Turn the ECS to OFF/RESET and then turn the ECS to STOP.
Press the alarm codes key.
Observe the upper display. Check that a CID 445 FMI 12 is showing.
If this diagnostic code is not showing, enter the service mode. View the fault log (OP1). Check that the diagnostic code is showing. Expected Result: A CID 445 FMI 12 is showing as a active fault or an inactive fault. Results:
No - A CID 445 FMI 12 has not occurred (NOT active and NOT inactive). STOP.
Yes - A CID 445 FMI 12 is active or inactive. Proceed to 2.
Check internal cable of relay module. Note: Only open the relay module in a dry environment. If the inspection takes more than twenty minutes replace the desiccant bag in the GSC housing. See Testing And Adjusting, "Relay Module Replace".
Turn the ECS to OFF/RESET.
Temporarily, remove the relay module from the GSC. See Testing And Adjusting, "Relay Module - Replace".
Check the cable that attaches the relay module to the GSC. Expected Result: The cable should be firmly seated in the connector. The clamp should be in place. The cable should not be damaged. Results:
OK - Reassemble the relay module to the GSC. Proceed to 3.
NOT OK - Replace the connector clamp if it is missing. If the cable is damaged, replace the GSC. STOP.
Perform a functional check for the RR.
Turn the ECS to OFF/RESET.
Disconnect all wires from RM-24 of the relay module. Remove the fuse "F4" from the relay module.
At the relay module, measure the resistance from RM-24 to RM-8. Resistance should be greater than 5000 ohms.
Turn the ECS
Caterpillar parts catalog:
Parts support Caterpillar catalog:
1192321
SUPPORT AS
315C, 315D L, 316E L, 318B, 318C, 319C, 319D, 319D L, 319D LN, 320B, 320C, 320D, 320D FM, 320D FM RR, 320D2, 320D2 L, 322B L, 322C, 323D L, 323D LN, 323D SA, 324D L, 325B L, 325C, 325D, 325D L, 330B L...
315C, 315D L, 316E L, 318B, 318C, 319C, 319D, 319D L, 319D LN, 320B, 320C, 320D, 320D FM, 320D FM RR, 320D2, 320D2 L, 322B L, 322C, 323D L, 323D LN, 323D SA, 324D L, 325B L, 325C, 325D, 325D L, 330B L...
4229963
SUPPORT AS
315C, 315D L, 316E L, 318B, 319D L, 319D LN
315C, 315D L, 316E L, 318B, 319D L, 319D LN
3276576
SUPPORT AS
307D, 308D, 308E, 308E2 CR, 311D LRR, 311F LRR, 312D, 312D L, 312D2, 312E, 312E L, 314D CR, 314D LCR, 314E CR, 314E LCR, 315D L, 316E L, 318D2 L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LN, 320D L...
307D, 308D, 308E, 308E2 CR, 311D LRR, 311F LRR, 312D, 312D L, 312D2, 312E, 312E L, 314D CR, 314D LCR, 314E CR, 314E LCR, 315D L, 316E L, 318D2 L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LN, 320D L...
3904172
SUPPORT AS
315D L, 316E L, 318D L, 318D2 L, 318E L
315D L, 316E L, 318D L, 318D2 L, 318E L
3119532
SUPPORT AS
315D L, 316E L, 318E L, 319D L, 319D LN
315D L, 316E L, 318E L, 319D L, 319D LN
315D L, 318E L, 319D, 319D L, 319D LN, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 GC, 320D2 L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 321D LCR, 323D L, 323D LN, 323D2 ...
3536296
SUPPORT AS
316E L, 318E L
316E L, 318E L
3505024
SUPPORT AS
316E L, 318E L
316E L, 318E L
3259160
SUPPORT
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LN, 336F L, 349E, 349E L, 349E L HVG, 349E L ...
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LN, 336F L, 349E, 349E L, 349E L HVG, 349E L ...
3346455
SUPPORT AS
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F ...
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F ...
4285841
SUPPORT AS
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 336D2, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 336D2, 336E, 336E H, 336E HVG, 336E L, 336E LH, 336E LN, 336F L
3273073
SUPPORT AS
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336D2, 336E, 336E H, 336E L, 336E LH, 336E LN, 336F L
312E, 312E L, 316E L, 318E L, 320E, 320E L, 320E LN, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336D2, 336E, 336E H, 336E L, 336E LH, 336E LN, 336F L
3938078
SUPPORT AS
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
312E, 312E L, 314E CR, 314E LCR, 316E L, 318E L
3700286
SUPPORT AS
316E L, 318E L
316E L, 318E L
3713118
SUPPORT AS
312E, 316E L, 318E L, 320E LN, 323E L, 324E LN
312E, 316E L, 318E L, 320E LN, 323E L, 324E LN
4166922
SUPPORT AS
316E L, 318E L
316E L, 318E L
3729649
SUPPORT AS
316E L, 318E L
316E L, 318E L
3515090
SUPPORT
316E L, 318E L
316E L, 318E L
3569549
SUPPORT AS
312E, 312E L
312E, 312E L
3569502
SUPPORT AS
312E, 312E L
312E, 312E L
3569496
SUPPORT AS
312E, 312E L
312E, 312E L
3569473
SUPPORT AS
312E, 312E L
312E, 312E L
3569557
SUPPORT AS
312E, 312E L
312E, 312E L
3284953
SUPPORT AS
312E, 316E L, 318E L, 320E, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E LN, 329E, 336E, 336E HVG, 349E L HVG
312E, 316E L, 318E L, 320E, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E LN, 329E, 336E, 336E HVG, 349E L HVG