3080859 SWITCH GP-LIQUID LEVEL Caterpillar parts
3406C, 3412C, C18, C32
Rating:
Alternative (cross code) number:
CA3080859
308-0859
3080859
CA3080859
308-0859
3080859
Weight: 1 pounds 0 kg.
GENERATOR SET,
This part in 4 request:
Show.
This information for suppliers only!
2022-09-27
2022-08-22
2020-03-10
2020-03-10
Number on catalog scheme:
3
For full view, you need register
Information:
Illustration 2 g03646387
Schematic of the Solenoid Return circuits
Note: The diagram above is a simplified schematic of the connections for the solenoid return circuits. The schematic is electrically correct. However, not all of the possible harness connectors are shown. Refer to the latest revision of the Electrical Schematic, UENR3102 for the complete schematic.Diagnostic Trouble Code Procedure
Note: Prior to beginning this procedure, inspect the harness connectors that are involved in this circuit. Poor connections can often be the cause of a problem in an electrical circuit. Verify that all connections in the circuit are clean, secure, and in good condition. If a problem with a connection is found, correct the problem and verify that the diagnostic code is active before performing a troubleshooting procedure. For sensors powered via the fuse panel, check the condition of the appropriate fuse before beginning the troubleshooting procedure.
Table 3
Troubleshooting Test Steps Values Results
1. Identify Active FMI Code Associated With Solenoid Circuit
Code present. FMI 3 diagnostic code, proceed to Test Step 2.
FMI 4 diagnostic code, proceed to Test Step 3.
FMI 5 diagnostic code, proceed to Test Step 5.
Begin Process For FMI 3 Troubleshooting HERE
2. Check The Machine Harness For A Short
A. Turn the key start switch and the disconnect switch OFF.
B. Disconnect the harness connection at solenoid.
C. Disconnect the harness connection at the ECM.
D. Measure the resistance of solenoid signal contact to all other ECM connections.
Each reading is greater than 5K ohms. OK - All resistance readings are greater than 5K ohms .
Proceed to Test Step 4.
NOT OK - One or more readings are less than 5 ohms.
Repair - A short exists between the signal contact and the circuit with the low resistance. Repair or replace the machine harness.
Note: A resistance that is greater than 5 ohms but less than 5K ohms would indicate a loose connection or a corroded connection in the circuit. A resistance measurement that is greater than 5K ohms would indicate an open in the circuit.
STOP
Begin Process For FMI 4 Troubleshooting HERE
3. Check The Machine Harness For An Open
A. Turn the key start switch and the disconnect switch OFF.
B. Disconnect the solenoid from the machine harness.
C. Disconnect the harness connection at the ECM.
D. Connect a jumper wire at the two contacts at the solenoid end of the wiring harness.
E. At the ECM side of the machine harness, measure the resistance from the signal to the return contact.
Each reading is less than 5 ohms. OK - The reading is less than 5 ohms, the harness is correct.
Proceed to Test Step 4.
NOT OK - The reading is greater than 5K ohms. Circuit open in machine harness.
Repair : The open is in the wire for the solenoid signal or the return wire for the solenoid. Repair or replace the machine harness.
Note: A resistance that is greater than 5 ohms but less than 5K ohms would indicate a loose connection or a corroded connection in the circuit. A resistance measurement that is greater than 5K ohms would indicate an open in the circuit.
STOP
4. Check If The Diagnostic
Caterpillar SIS machinery equipment:
Caterpillar SIS
C32 Ukraine Corvette Genset RNX00001-UP »
308-0859
SWITCH GP-LIQUID LEVEL
3406C Marine Auxiliary Generator Set PFH00001-UP »
308-0859
SWITCH GP-LIQUID LEVEL
3412C Marine Auxiliary Generator Set RLR00001-UP »
308-0859
SWITCH GP-LIQUID LEVEL
C32 Marine Auxiliary Generator Engine RNE00001-UP »
308-0859
SWITCH GP-LIQUID LEVEL
C18 Marine Generator Set JHL00001-UP »
308-0859
SWITCH GP-LIQUID LEVEL
C18 Marine Auxiliary Generator Set GBM00001-UP POWERED BY C18 Engine »
308-0859
SWITCH GP-LIQUID LEVEL
C32 Marine Generator SET RNF00001-UP »
308-0859
SWITCH GP-LIQUID LEVEL
Caterpillar parts catalog:
Parts switch Caterpillar catalog:
10 FT, 10-20B, 115, 120G, 12G, 130G, 140G, 143H, 14G, 160G, 163H NA, 16G, 215B, 215D, 219D, 225, 225D, 227, 229, 229D, 231D, 235, 235B, 235C, 235D, 245, 245B, 245D, 307, 317B LN, 318B, 3208, 320C, 330...
120B, 120G, 12E, 12G, 130G, 140B, 140G, 14E, 14G, 16, 160G, 1676, 16G, 205B, 206B, 211B, 212B, 213B, 214B, 215, 215B, 215C, 215D, 224B, 225, 225D, 227, 229, 229D, 231D, 235, 235B, 235C, 235D, 245, 245...
214, 3116, 320 L, 3208, 3304, 3304B, 3306, 3306B, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 3412D, 3508, 3512, 3516, 428, 436, D11N, D250B, D25C, D25D, D300B, D30C, D350C, D35C, D35HP, D400, D40D, E200B...
211B, 3114, 3116, 3126, 320 L, 3208, 325, 325 L, 325 LN, 330, 330 FM L, 330 L, 3304, 3306, 3306B, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 350, 3508, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 375, 375 L,...
3208, 3304, 3306, 3306B, 3406, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 3412D, 621G, 623G, 627G, 631G, 637G, 657G, AP-1000B, AP-1055B, AP-650B, AP-800C, AP-800D, AP-900B, BG-225B, BG-225C, BG-2455C, BG...
3114, 3116, 3126, 3208, 3304, 3304B, 3306, 3306B, 3306C, 3406B, 3406C, 3408, 3408B, 3408C, 3412, 3412C, 3412D, 3508, 3512, 3516, 480, AD40, AE40, G3406, G3408, G3412, R1700 II
120G, 12G, 130G, 14G, 16G, 3208, 3304, 3306, 3306B, 3406, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 3412E, 518, 528, 572G, 621, 621B, 627B, 633D, 637D, 769C, 773B, 777B, 834B, 836, 910, 931B, 988B, 992C...
120, 12F, 12G, 140, 140G, 14E, 14G, 16, 16G, 225, 225D, 227, 229, 3160, 3208, 3304, 3304B, 3306, 3306B, 3406, 3406B, 3406C, 3408, 3408C, 3408E, 3412, 3412C, 3412E, 3508, 3512, 3516, 594, 613, 621, 623...
225, 225D, 229, 229D, 231D, 3306, 3406, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 426, 428, 578, 589, D10N, D11N, D5B, D8L, D8N, D8R, D9L, D9N, G3408, G3412
3304, 3304B, 3306, 3306B, 3406, 3406B, 3406C, 3406E, 3408, 3408C, 3412, 3412C, 3412D, 3412E, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 3618, C12, C18, C280-12...
311, 311B, 3126B, 312B, 312C, 312C L, 313B, 314C, 315, 315B, 315B FM L, 315C, 317B LN, 318B, 318C, 319C, 320 L, 3208, 320B, 320B FM LL, 320B L, 320C, 320C FM, 320N, 321B, 322, 322 FM L, 325, 325 L, 32...
3208, 3306, 3306B, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 3508, 3508B, 3512, 3512B, 3512C, 3516, 3516B, 3516C, C15, C18, C27, C32, G3306, G3306B, G3406, G3408, G3412, G3508, G3512, G3512E, G3516, G35...
3191107
SWITCH GP-SHUTDOWN
R1700 II
R1700 II
2258542
SWITCH GP-POSITION
CB-434D, CB-534D, CB-564D
CB-434D, CB-534D, CB-564D
2581543
SWITCH GP-MAGNETIC
3516C, C175-16, G3508, G3512, G3516
3516C, C175-16, G3508, G3512, G3516
3156638
SWITCH GP-PRESSURE
3013C, C1.1, C1.5, C2.2, CB-22, CB-334E, CB-34, CB22B, CB24B, CB32B, CC24B
3013C, C1.1, C1.5, C2.2, CB-22, CB-334E, CB-34, CB22B, CB24B, CB32B, CC24B
3149918
SWITCH GP-PRESS & TEMP
236B, 252B, 3044C, 906H, 907H, 908H, C3.4
236B, 252B, 3044C, 906H, 907H, 908H, C3.4
3642297
SWITCH GP-DISCONNECT
CB22B, CB24B, CB32B, CB34B, CB34B XW, CC24B, CC34B
CB22B, CB24B, CB32B, CB34B, CB34B XW, CC24B, CC34B
120G, 12G, 130G, 140G, 14G, 160G, 16G, 215D, 225, 225D, 229, 229D, 231D, 235C, 235D, 245B, 245D, 311, 312, 315, 315B, 315B FM L, 317, 320 L, 320B, 320B FM LL, 320B L, 322 FM L, 322B, 322B L, 322B LN, ...
5W5879
SWITCH GP-ROTOR
206, 212, 214B, 224B
206, 212, 214B, 224B
1461852
SWITCH GP-COOLANT LEVEL
G3406, G3408, G3408C, G3412, G3412C
G3406, G3408, G3408C, G3412, G3412C
3346464
SWITCH GP-POSITION
312E, 312E L, 316E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LN, 349E, 349E L, 349E L VG, 568 FM LL
312E, 312E L, 316E L, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323E L, 324E, 324E L, 324E LN, 329E, 329E L, 329E LN, 336E, 336E HVG, 336E L, 336E LN, 349E, 349E L, 349E L VG, 568 FM LL
2626975
SWITCH GP-SHUTOFF
C1.5, C2.2
C1.5, C2.2
3032131
SWITCH GP-PRESSURE
3054C, AP-300
3054C, AP-300