5N8947 SWITCH AS-SPEED Caterpillar parts
3208, 3304, 3306, 3406, 3408, 3412, D346, D348, D379B, G379, G399
Rating:
Alternative (cross code) number:
CA5N8947
5N-8947
5N8947
CA5N8947
5N-8947
5N8947
Weight: 2 pounds 0 kg.
GAS ENGINE, MARINE ENGINE,
This part in 2 request:
Show.
This information for suppliers only!
2025-05-14
2021-09-30
Compatible equipment models: 5N8947:
Number on catalog scheme:
13
For full view, you need register
Information:
Illustration 1 g02724087
Connections of the Rear Axle Oil Temperature Sensor
This diagnostic code is associated with the Rear Axle Oil Temperature Sensor. The FMI 04 means that the ECM has determined that the voltage of the circuit for the sensor is below normal. The possible causes of this diagnostic code are listed below:
The signal circuit for the sensor is shorted to ground.
The sensor has failed.
The ECM has failed. The failure of the ECM is unlikely. Note: Before performing this procedure, inspect the harness connectors that are involved in the circuit. Poor connections can often be the cause of a problem in an electrical circuit. Verify that all of the connections in the circuit are clean and secure. If a problem with a connection is found, correct the problem and verify that this diagnostic code is active before performing this procedure.The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear the diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 0428 FMI 04 is active before performing this procedure. Note: Use a digital multimeter for the measurements in this procedure.Test Step 1. CHECK THE SENSOR
Turn the disconnect switch and the key start switch to the ON position.
Ensure that the diagnostic code is active.
Disconnect the sensor from the machine harness.
Observe the status of the diagnostic code. Expected Result:The diagnostic code remains active.Results:
OK - The diagnostic code remains active. The sensor is correct. Proceed to Test Step 2.
NOT OK - The diagnostic code changes from an FMI 04 to an FMI 03. The sensor has failed.Repair: Replace the sensor. Verify that the new sensor has corrected the problem.STOPTest Step 2. CHECK THE WIRING HARNESS OF THE SENSOR FOR A SHORT TO GROUND.
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness from the sensor.
Disconnect the machine harness connectors from the ECM.
At the machine harness connector for the ECM, measure the resistance from the signal contact J2-27 (wire 446-PU(Purple)) of the machine harness to all possible sources of ground. Measure the resistance to all contacts of the machine harness connectors for the ECM. Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - One or more resistance measurements are not correct. There is a short in the machine harness. Repair: The short is between signal contact J2-27 (wire 446-PU(Purple)) and the circuit with the low resistance measurement. Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE REMAINS.
Inspect the harness connectors. Clean the contacts of the harness connectors and check the wires for damage to the insulation that is caused by excessive heat, corrosion, or chafing.
Perform a 45 N (10 lb) pull test on each of the wires that are associated with the circuit.
Reconnect all harness connectors in order to make sure that the connectors are fully
Caterpillar parts catalog:
Parts switch Caterpillar catalog:
120, 12F, 12G, 140, 140G, 14E, 14G, 16, 16G, 225, 225D, 227, 229, 3160, 3208, 3304, 3304B, 3306, 3306B, 3406, 3406B, 3406C, 3408, 3408C, 3408E, 3412, 3412C, 3412E, 3508, 3512, 3516, 594, 613, 621, 623...
120B, 120G, 12G, 130G, 140B, 140G, 14G, 16G, 227, 235, 235C, 245, 245B, 245D, 3304, 3306, 3306B, 3406, 3406B, 3408, 3408C, 3412, 3412D, 3508, 3508C, 3512, 3516, 561D, 571G, 572G, 583K, 594H, 615, 651E...
1673C, 1674, 3116, 3208, 3304, 3306, 3406, 3406E, 3408, 35, 416, 428, 436, 446, 45, 65, 75, AP-200B, RT100, TH103, TH62, TH63, TH82, TH83
225, 225D, 229, 229D, 231D, 3306, 3406, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 426, 428, 578, 589, D10N, D11N, D5B, D8L, D8N, D8R, D9L, D9N, G3408, G3412
3304, 3304B, 3306, 3306B, 3406, 3406B, 3408, 3408B, 3412, 3508, 3512, 3516, AP-1000B, AP-1055B, AP-800C, BG-225B, BG-225C, BG-2455C, BG-245C, CB-534
3304, 3304B, 3306, 3306B, 3406, 3406B, 3406C, 3406E, 3408, 3408C, 3412, 3412C, 3412D, 3412E, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 3618, C12, C18, C280-12...
311, 311B, 3126B, 312B, 312C, 312C L, 313B, 314C, 315, 315B, 315B FM L, 315C, 317B LN, 318B, 318C, 319C, 320 L, 3208, 320B, 320B FM LL, 320B L, 320C, 320C FM, 320N, 321B, 322, 322 FM L, 325, 325 L, 32...
3208, 3306, 3306B, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 3508, 3508B, 3512, 3512B, 3512C, 3516, 3516B, 3516C, C15, C18, C27, C32, G3306, G3306B, G3406, G3408, G3412, G3508, G3512, G3512E, G3516, G35...
12E, 14E, 16, 1673C, 1674, 1676, 1693, 3304, 3306, 561B, 561C, 621, 627, 631C, 637, 641, 641B, 650B, 657, 657B, 666, 666B, 769, 824B, 834, 941, 950, 951B, 955K, 955L, 966C, 977H, 977K, 980, 988, 992, ...
225, 3160, 3208, 3304, 3306, 613, 613B, D342C, D346, D399, G343
3406, 3408, D348, D353C, D379B, D399, G399
120G, 12G, 130G, 140G, 14G, 160G, 16G, 231D, 245D, 3208, 518, 528B, 530B, 615C, 621E, 627E, 637E, 814B, 815B, 916, 936, 936F, 950B, 950B/950E, 963, 966D, 966F, 973, 980C, 980F, CS-643, D4H, D4H XL, D4...
4494976
SWITCH AS
424B, 424B HD
424B, 424B HD
311D LRR, 312D, 312D L, 314D CR, 314D LCR, 314E LCR, 315D L, 318E L, 319D, 319D L, 319D LN, 320B L, 320D, 320D L, 320D LRR, 320D RR, 320E L, 320E LN, 320E LRR, 321D LCR, 322B L, 323D L, 323D LN, 323D ...
3929277
SWITCH-ROCKER
236D, 242D, 246D, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP, CB-44B, CB-54B, CD-54B, CW-34
236D, 242D, 246D, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP, CB-44B, CB-54B, CD-54B, CW-34
3781010
SWITCH AS-ROCKER
236D, 242D, 246D, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP
236D, 242D, 246D, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP
4339721
SWITCH
236D, 242D, 246D, 257D, 259D, 262D, 272D, 277D, 279D, 287D, 289D, 299D
236D, 242D, 246D, 257D, 259D, 262D, 272D, 277D, 279D, 287D, 289D, 299D
236D, 242D, 246D, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP
330B L, 65, 75, 768C, 769C, 771C, 772B, 773B, 775B, 776C, 784B, 785, 785B, 789, 789B, 793B, 793C, 814F, 815F, 816F, 910E, 918F, 924F, 928F, 933, 936F, 938F, 939, 950F, 950F II, 960F, 966F, 966F II, 97...
225, 225D, 229, 229D, 231D, 3306, 3406, 3406B, 3406C, 3408, 3408C, 3412, 3412C, 426, 428, 578, 589, D10N, D11N, D5B, D8L, D8N, D8R, D9L, D9N, G3408, G3412
10 FT, 10-20B, 10B, 3304, 3306, 3408, 3412, 3412C, 3508, 3512, 3516, 8 FT, 8-16B, BG-2455C, G3408, G3412, G3512, G3516
428, 785, D10, D5H, D6H, D7H
4W2218
SWITCH AS
3208, 3304, 3306, 3408, 3412, 3512, 3516, G3408, G3412, G3512, G3516
3208, 3304, 3306, 3408, 3412, 3512, 3516, G3408, G3412, G3512, G3516
3208, 3304, 3304B, 3306, 3408, 3412, 3412C, 3508, 3508B, 3512, 3512B, 3516, 3516B, 3606, 3608, 3612, 3616, G3304, G3306, G3306B, G3406, G3408, G3412, G3508, G3512, G3516, G3606, G3608, G3612, G3616, G...