2862890 WASHER Caterpillar parts
120M, 12M, 2470C, 3056E, 320D GC, 320D L, 323D L, 323D2 L, 420E, 430E, 450E, 535D, 545D, 553C, 559, 613G, 914G, 924H, 924HZ, 924K, 928H, 928HZ, 930K, 938H, 938K, 950 GC, 953D, 963D, AP-600D, AP-655D, ...
Rating:
Alternative (cross code) number:
CA2862890
286-2890
2862890
CA2862890
286-2890
2862890
Weight: 0.01 pounds 0 kg.
ASPHALT PAVER, WHEELED EXCAVATOR,
Compatible equipment models: 2862890:
Number on catalog scheme:
20
For full view, you need register
Information:
The Electronic Control Module (ECM) detects the following conditions:172(1)
The delay at start-up is three minutes after the engine is in run mode.
The pressure difference between the atmospheric pressure and the turbocharger inlet pressure is 7.5 kPa (1.1 psi) for ten seconds.172(2)
The delay at start-up is three minutes after the engine is in run mode.
The pressure difference between the atmospheric pressure and the turbocharger inlet pressure is 9 kPa (1.3 psi) for ten seconds.System Response:172(1)The ECM generates an event code.172(2)The ECM generates an event code.Possible Performance Effect:172(1)The engine may experience low power due to the high inlet restriction.172(2)The engine power will be derated by two percent for each 1 kPa (0.15 psi) that is above 9 kPa (1.3 psi) to a maximum of ten percent. The derate will apply to rated power.Troubleshooting:Test Step 1. Check for Restrictions
Check the air intake for restrictions.
Inspect the air filter.
Clean the air filter or replace the air filter. Expected Result:There are no restrictions in the air intake. The air filter was cleaned or the air filter was replaced. Results:
OK - STOP
The delay at start-up is three minutes after the engine is in run mode.
The pressure difference between the atmospheric pressure and the turbocharger inlet pressure is 7.5 kPa (1.1 psi) for ten seconds.172(2)
The delay at start-up is three minutes after the engine is in run mode.
The pressure difference between the atmospheric pressure and the turbocharger inlet pressure is 9 kPa (1.3 psi) for ten seconds.System Response:172(1)The ECM generates an event code.172(2)The ECM generates an event code.Possible Performance Effect:172(1)The engine may experience low power due to the high inlet restriction.172(2)The engine power will be derated by two percent for each 1 kPa (0.15 psi) that is above 9 kPa (1.3 psi) to a maximum of ten percent. The derate will apply to rated power.Troubleshooting:Test Step 1. Check for Restrictions
Check the air intake for restrictions.
Inspect the air filter.
Clean the air filter or replace the air filter. Expected Result:There are no restrictions in the air intake. The air filter was cleaned or the air filter was replaced. Results:
OK - STOP
Cat SIS web machinery list:
Parts washer Caterpillar catalog:
525B, 525C, 533, 535B, 535C, 543, 545, 545C, 545D, 555D, 966G, 966G II, 966H, 966K, 972G, 972G II, 972H, 972K, HA770, HA771, HA870, HA871, TK370, TK371, TK380, TK381
120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 160G, 160H, 160H ES, 160H NA, 160K,...
120K, 120K 2, 120M, 120M 2, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16H NA, 777F, 777G
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 14...
120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, ...
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 14...
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 14...
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 14...
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 14...
120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 160G, 160H, 160H ES, 160H NA, 160K,...
120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, ...
120H, 120H ES, 120H NA, 120K, 120K 2, 120M, 120M 2, 12G, 12H, 12H ES, 12H NA, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 140M, 140M 2, 140M 3, ...
120M, 12M, 2470C, 320D GC, 320D L, 323D L, 420E, 430E, 450E, 553C, 559, 613G, 914G, 924H, 924HZ, 928H, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP1000E, AP1055E, AP555E, BG500E, BG600D, BG655D, C4.4...
308E2 CR, 450E, 854K, 992K, C13, C15, C15 I6, C18, C18 I6, C2.2, C3.3, C4.4, C6.6, CB22B, CB24B, CB32B, CB34B, CB34B XW, CC24B, CC34B, G3516B, PM3516, PMG3516
5R5927
WASHER
236D, 242D, 246D, 24H, 24M, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP, 345B II, 345B L, 345C, 345C L, 345D, 345D L, 349D, 349D L, 349E L, 349E L VG, 349F L, 365B, 365B I...
236D, 242D, 246D, 24H, 24M, 257D, 259D, 262D, 272D, 272D XHP, 277D, 279D, 287D, 289D, 299D, 299D XHP, 345B II, 345B L, 345C, 345C L, 345D, 345D L, 349D, 349D L, 349E L, 349E L VG, 349F L, 365B, 365B I...
3460007
WASHER
120M, 12M, 2470C, 320D GC, 320D L, 323D L, 323D2 L, 420E, 430E, 450E, 535D, 545D, 553C, 613G, 914G, 924H, 924HZ, 924K, 928HZ, 930K, 938H, 938K, 950 GC, 953D, AP-600D, AP-655D, AP1000E, AP1055E, AP555E...
120M, 12M, 2470C, 320D GC, 320D L, 323D L, 323D2 L, 420E, 430E, 450E, 535D, 545D, 553C, 613G, 914G, 924H, 924HZ, 924K, 928HZ, 930K, 938H, 938K, 950 GC, 953D, AP-600D, AP-655D, AP1000E, AP1055E, AP555E...
3202362
WASHER
420E, 430E, 450E, C4.4, CW-34, D3K XL, D4K XL, D5K LGP
420E, 430E, 450E, C4.4, CW-34, D3K XL, D4K XL, D5K LGP
3202361
WASHER
420E, 430E, 450E, C4.4, CW-34, D3K XL, D4K XL, D5K LGP
420E, 430E, 450E, C4.4, CW-34, D3K XL, D4K XL, D5K LGP
450E, 450F
2887233
WASHER-SPECIAL
450E, 450F
450E, 450F
450E, 450F, CP-533E, CP-54B, CP-56, CP-573E, CP-64, CP-663E, CP-68B, CP-74B, CP-76, CS-533E, CS-54, CS-54B, CS-56, CS-563D, CS-563E, CS-56B, CS-583E, CS-64, CS-64B, CS-663E, CS-66B, CS-683E, CS-68B, C...
2943032
WASHER-SPECIAL
120M, 12M, 2470C, 311D LRR, 312D, 312D L, 313D, 314D CR, 314D LCR, 315D L, 318D L, 319D, 319D L, 319D LN, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 321D LCR, 323D L, 323D...
120M, 12M, 2470C, 311D LRR, 312D, 312D L, 313D, 314D CR, 314D LCR, 315D L, 318D L, 319D, 319D L, 319D LN, 320D, 320D FM, 320D FM RR, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 321D LCR, 323D L, 323D...
3098006
WASHER
120M, 12M, 2470C, 320D GC, 320D L, 323D L, 420E, 430E, 450E, 553C, 559, 613G, 914G, 924H, 924HZ, 928H, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP1000E, AP1055E, AP555E, BG500E, BG600D, BG655D, C4.4...
120M, 12M, 2470C, 320D GC, 320D L, 323D L, 420E, 430E, 450E, 553C, 559, 613G, 914G, 924H, 924HZ, 928H, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP1000E, AP1055E, AP555E, BG500E, BG600D, BG655D, C4.4...
1600162
WASHER
120M, 12M, 3056, 420E, 430E, 450E, 559, 613G, 914G, 924G, 924GZ, 924H, 924HZ, 928H, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP555E, BG500E, BG600D, BG655D, C4.4, C6.6, CB-54, CB-54B, CB-64, CP-44, ...
120M, 12M, 3056, 420E, 430E, 450E, 559, 613G, 914G, 924G, 924GZ, 924H, 924HZ, 928H, 928HZ, 938H, 953D, 963D, AP-600D, AP-655D, AP555E, BG500E, BG600D, BG655D, C4.4, C6.6, CB-54, CB-54B, CB-64, CP-44, ...