3423702 WINDOW GP-CAB Caterpillar parts
311D LRR, 312D L, 319D LN, 320D L, 320D LRR, 324D L, 328D LCR, 329D L
Rating:
Alternative (cross code) number:
CA3423702
342-3702
3423702
CA3423702
342-3702
3423702
Weight: 21 pounds 9 kg.
EXCAVATOR, MOBILE HYD POWER UNIT,
Compatible equipment models: 3423702:
Number on catalog scheme:
1
For full view, you need register
Information:
Note: Maximum operating load is the load % indicated on the ECM panel.
Illustration 13 g06243162
Illustration 14 g06243148
Illustration 15 g06243169
Illustration 16 g06243174
Table 9
Temperature Correction Factor Look-up for Turbocharger Speed
Temperature Maximum
T max Current Inlet Air Temperature
T current
32°F 50°F 77°F 95°F 110°F 117°F 131°F 140°F
32°F 1.00
50°F .98 1.00
77°F .97 .98 1.00
95°F .96 .97 .99 1.00
110°F .95 .97 .98 .99 1.00
117°F .95 .96 .97 .98 .99 1.00
131°F .94 .96 .97 .97 .98 .99 1.00
140°F .93 .95 .96 .97 .97 .98 .99 1.00 Tmax - Maximum ambient temperature for the month in deg FTcurrent - Current ambient temperature in deg FTest Procedure - Fuel Correction Factor (FCF)
Start the engine
Monitor the FCF value using Cat ET
The FCF should be at 100 percent 10 percent above 50 percent load.
If, the FCF value is out of range, refer to "Adjustment Procedure - FuelCorrection Factor."Test Procedure - Fuel Analysis
Obtain Current Fuel Analysis
Use the methane number to determine desired timing.
Low Heat Value (LHV) is used for engine setup (configuration)
Specific Gravity (SG) is used for engine setup (configuration)
Specific Heat Ratio (SHR) (K) is used for engine setup (configuration)
With the system powered up and before starting the engine, use Cat ET to disable the feedback system.Disabling the feedback system will put the engine in open loop mode so the air/fuel ratio can be adjusted manually.
Start the engine
Allow the engine to warm up, then load the engine.
Verify that the engine O2 sensor is warmed up and operating.
Allow the emission analyzer NOx reading to stabilize.
If the engine speed is unstable, refer to the Testing and Adjusting procedures for Adjusting the following:
Engine Speed Parameters
Fuel Parameters
Waste-gate Adjustment
Desired Emissions Gain Adjustment PercentageUnburned Gas − Purge
The following events cause unburned gas to remain in the air inlet and in the exhaust manifold:
Emergency stop
Engine overspeed
The GSOV is commanded to close and the GSOV does not close.
Unsuccessful successive attempts to start the engineUnburned gas may remain in the air inlet and exhaust system after several unsuccessful attempts to start the engine. The unburned gas may increase to a concentration that may ignite during an attempt to start the engine.Perform the following procedure to purge the unburned gas:Note: This procedure will not work if the engine control does not control the GSOV.
Connect Cat ET to the engine.
Verify that the value of the "Engine Purge Cycle" parameter is equal to 10 seconds less than the value of the "Crank Cycle" parameter.
Set the engine control to the START mode. The engine will crank for the "Engine Purge Cycle" time. Then, the gas shutoff valve will be energized and the ignition will be enabled. The engine will start.
Continue with your previous procedure.
Illustration 13 g06243162
Illustration 14 g06243148
Illustration 15 g06243169
Illustration 16 g06243174
Table 9
Temperature Correction Factor Look-up for Turbocharger Speed
Temperature Maximum
T max Current Inlet Air Temperature
T current
32°F 50°F 77°F 95°F 110°F 117°F 131°F 140°F
32°F 1.00
50°F .98 1.00
77°F .97 .98 1.00
95°F .96 .97 .99 1.00
110°F .95 .97 .98 .99 1.00
117°F .95 .96 .97 .98 .99 1.00
131°F .94 .96 .97 .97 .98 .99 1.00
140°F .93 .95 .96 .97 .97 .98 .99 1.00 Tmax - Maximum ambient temperature for the month in deg FTcurrent - Current ambient temperature in deg FTest Procedure - Fuel Correction Factor (FCF)
Start the engine
Monitor the FCF value using Cat ET
The FCF should be at 100 percent 10 percent above 50 percent load.
If, the FCF value is out of range, refer to "Adjustment Procedure - FuelCorrection Factor."Test Procedure - Fuel Analysis
Obtain Current Fuel Analysis
Use the methane number to determine desired timing.
Low Heat Value (LHV) is used for engine setup (configuration)
Specific Gravity (SG) is used for engine setup (configuration)
Specific Heat Ratio (SHR) (K) is used for engine setup (configuration)
With the system powered up and before starting the engine, use Cat ET to disable the feedback system.Disabling the feedback system will put the engine in open loop mode so the air/fuel ratio can be adjusted manually.
Start the engine
Allow the engine to warm up, then load the engine.
Verify that the engine O2 sensor is warmed up and operating.
Allow the emission analyzer NOx reading to stabilize.
If the engine speed is unstable, refer to the Testing and Adjusting procedures for Adjusting the following:
Engine Speed Parameters
Fuel Parameters
Waste-gate Adjustment
Desired Emissions Gain Adjustment PercentageUnburned Gas − Purge
The following events cause unburned gas to remain in the air inlet and in the exhaust manifold:
Emergency stop
Engine overspeed
The GSOV is commanded to close and the GSOV does not close.
Unsuccessful successive attempts to start the engineUnburned gas may remain in the air inlet and exhaust system after several unsuccessful attempts to start the engine. The unburned gas may increase to a concentration that may ignite during an attempt to start the engine.Perform the following procedure to purge the unburned gas:Note: This procedure will not work if the engine control does not control the GSOV.
Connect Cat ET to the engine.
Verify that the value of the "Engine Purge Cycle" parameter is equal to 10 seconds less than the value of the "Crank Cycle" parameter.
Set the engine control to the START mode. The engine will crank for the "Engine Purge Cycle" time. Then, the gas shutoff valve will be energized and the ignition will be enabled. The engine will start.
Continue with your previous procedure.
Caterpillar SIS machinery equipment:
Caterpillar SIS
349D2 L Excavator GAX00001-UP (MACHINE) POWERED BY C13 Engine »
342-3702
WINDOW GP-CAB
311D LRR Excavator PNJ00001-UP (MACHINE) POWERED BY C4.2 Engine »
342-3702
WINDOW GP-CAB
312D L Excavator XGK00001-UP (MACHINE) POWERED BY C4.2 Engine »
342-3702
WINDOW GP-CAB
319D L & 319D LN Excavators KFM00001-UP (MACHINE) POWERED BY C4.2 Engine »
342-3702
WINDOW GP-CAB
320D L Excavator SPN00001-UP (MACHINE) POWERED BY C6.4 Engine »
342-3702
WINDOW GP-CAB
324D L Excavator PYT00001-UP (MACHINE) POWERED BY C7 Engine »
342-3702
WINDOW GP-CAB
328D LCR Excavator RMX00001-UP (MACHINE) POWERED BY C7 Engine »
342-3702
WINDOW GP-CAB
329D L Excavator WLT00001-UP (MACHINE) POWERED BY C7 Engine »
342-3702
WINDOW GP-CAB
320D LRR Excavator DHE00001-UP (MACHINE) POWERED BY C6.4 Engine »
342-3702
WINDOW GP-CAB
329D L Mobile Hydraulic Power Units L5G00001-UP (MACHINE) POWERED BY C7 Engine »
342-3702
WINDOW GP-CAB
Caterpillar parts catalog:
Parts window Caterpillar catalog:
3346388
WINDOW GP-CAB
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
3406695
WINDOW GP-CAB
312D, 312D L, 315D L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 323D L, 323D LN, 323D SA, 324D, 324D L, 328D LCR, 329D, 329D L, 329D LN, 330D, 336D, 336D L, 336D LN, 336D2, 345D, 345D L, 345D ...
312D, 312D L, 315D L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 323D L, 323D LN, 323D SA, 324D, 324D L, 328D LCR, 329D, 329D L, 329D LN, 330D, 336D, 336D L, 336D LN, 336D2, 345D, 345D L, 345D ...
311D LRR, 312C L, 312D, 312D L, 315C, 315D L, 318C, 319D L, 320C, 320C FM, 320C L, 320D, 320D L, 320D LN, 320D LRR, 320D RR, 320D2, 320D2 L, 322C, 323D L, 323D2 L, 324D, 324D L, 325C, 325C L, 325D, 32...
3276625
WINDOW GP-CAB
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
312D, 312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 32...
2358909
WINDOW GP-CAB
311D LRR, 311F LRR, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315D L, 318D L, 318D2 L, 319D L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2 L, 323D L, 324D, 324D L, 325D, 325D L...
311D LRR, 311F LRR, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315D L, 318D L, 318D2 L, 319D L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, 320D2 L, 323D L, 324D, 324D L, 325D, 325D L...
1397101
WINDOW GP-CAB
311D LRR, 311F LRR, 312C L, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315C, 315D L, 318C, 318D L, 318D2 L, 319D L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, ...
311D LRR, 311F LRR, 312C L, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315C, 315D L, 318C, 318D L, 318D2 L, 319D L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 320D LRR, 320D RR, ...
1761958
WINDOW GP-CAB
307C, 307D, 311C, 311D LRR, 311F LRR, 312C L, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315C, 315D L, 318C, 318D L, 318D2 L, 319D L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 3...
307C, 307D, 311C, 311D LRR, 311F LRR, 312C L, 312D, 312D L, 312D2, 312D2 GC, 313D, 313D2, 315C, 315D L, 318C, 318D L, 318D2 L, 319D L, 320C, 320C FM, 320C L, 320D, 320D FM, 320D GC, 320D L, 320D LN, 3...
3423483
WINDOW GP-CAB
311D LRR, 312D L, 319D LN, 320D L, 320D LRR, 324D L, 328D LCR, 329D L
311D LRR, 312D L, 319D LN, 320D L, 320D LRR, 324D L, 328D LCR, 329D L
307C, 307D, 311C, 311D LRR, 311F LRR, 312C, 312C L, 312D, 312D L, 312D2, 312D2 GC, 312D2 L, 313D, 313D2, 313D2 LGP, 315C, 315D L, 318C, 318D L, 318D2 L, 319C, 319D L, 320C, 320C FM, 320C L, 320D, 320D...
3835649
WINDOW GP-DOOR
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 324E L, ...
312D L, 312E, 312E L, 315D L, 316E L, 318E L, 319D L, 319D LN, 320D, 320D L, 320D LRR, 320D RR, 320E, 320E L, 320E LN, 320E LRR, 320E RR, 323D L, 323D LN, 323D SA, 323E L, 324D, 324D L, 324E, 324E L, ...
3406664
WINDOW GP-CAB
323E L, 324D L, 324E, 324E LN, 329D L, 329D LN, 329E, 329E LN, 336D L, 336D LN, 336E, 336E H, 336E LH, 336E LN, 345D, 345D L, 345D L VG, 349D L, 349E, 349E L VG, 374F L, 390F L
323E L, 324D L, 324E, 324E LN, 329D L, 329D LN, 329E, 329E LN, 336D L, 336D LN, 336E, 336E H, 336E LH, 336E LN, 345D, 345D L, 345D L VG, 349D L, 349E, 349E L VG, 374F L, 390F L
3423704
WINDOW AS-CAB
311D LRR, 312D L, 319D LN, 320D L, 320D LRR, 324D L, 328D LCR, 329D L
311D LRR, 312D L, 319D LN, 320D L, 320D LRR, 324D L, 328D LCR, 329D L
7V8820
WINDOW GP
834B, 988B, 992C
834B, 988B, 992C
3451168
WINDOW GP-DOOR
CD-54
CD-54
3389767
WINDOW GP-CAB
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
3389768
WINDOW GP-CAB
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
D3K XL, D3K2 LGP, D4K XL, D4K2 XL, D5K LGP, D5K2 XL, D6K2, D6K2 LGP
3881410
WINDOW GP-SLIDING
D6K LGP, PL61
D6K LGP, PL61
2065477
WINDOW GP
R1300
R1300
3576189
WINDOW GP-CAB
365C, 374D L, 385C, 385C L, 390D, 390D L
365C, 374D L, 385C, 385C L, 390D, 390D L
8X5205
WINDOW GP
621F, 623E, 623F, 627F
621F, 623E, 623F, 627F