WRENCH AS-SPNR 2994760 - Caterpillar

Illustration 8 g03623193If a fault condition exists for the entire duration of inducement level 2, the strategy advances to inducement level 3. A “Engine Fault Check Engine” message, and an “Emission Fault” message will appear on the monitor, the action lamp will flash, and an audible alarm will sound 20 seconds prior to the level 3 inducement. The engine will be taken to low idle or will be shut down. After the level 3 inducement you may cycle the key, which will allow 20 minutes of engine run time with full torque. After 20 minutes, the engine will be in level 3 final inducement and will allow idle only or be shut down until the issue has been resolved. Once shut down, the engine can be restarted for 5 minute periods at reduced speed and torque. If set to idle, the engine will idle indefinitely at reduced torque.Note: Contact your Cat dealer for repairs if a fault occurs.Inducement Emergency Override for Cat Engines Equipped with Selective Catalytic Reduction Systems (If Equipped)
Note: The inducement emergency override will only be allowed on a select number of machines that may be used in emergency situations. Contact your Cat dealer to find out if your machine is allowed to have this feature.Inducement emergency override can only be enabled using Caterpillar supplied passwords. The feature is disabled by default. The feature will be enabled at the factory if allowed. If the customer wants the feature enabled after delivery of engine, they will need to contact their Cat dealer. Inducement emergency override is regulated by the Environmental Protection Agency (EPA) and only allowed in the United States. The European Union and Japan do not allow the feature to be used. For detailed information on activating, deactivating, or resetting override, contact your Cat dealer. Before you attempt the procedures documented in this manual, make sure that you have read and understand the information in this document.The United States EPA requires the limiting of engine speed and/or power (derate) in certain conditions, to help ensure proper functioning of the engines emission control system. The EPA allows the temporary disabling of these limits (restoration of full engine speed and power capability) during a qualified emergency situation. The EPA defines a qualified emergency situation as a significant direct or indirect risk to human life. Below are examples of direct versus indirect risks.Direct - An emission control condition that inhibits performance of an engine being used to rescue a person from life-threatening situation.Indirect - An emission control condition that inhibits performance of an engine being used to provide electrical power to a data center that routes 911 emergency response communications.The emissions-related derate can be disabled for up to 120 hours of engine operation. The temporary disabling of emissions-related derate is referred to as "Inducement Emergency Override" and must be reported to the United States EPA. The override can only be enabled or disabled by an authorized Cat dealer using Caterpillar supplied passwords. Once enabled, the override can be activated thru