AVSPARE.COM
parts catalog

ELBOW 9V9005 - Caterpillar



9V9005 ELBOW Caterpillar parts 315B ELBOW
Rating:
23
Alternative (cross code) number:
CA9V9005
9V-9005
9V9005
Caterpillar 9V9005 ELBOW

Buy ELBOW 9V9005 Caterpillar genuine, new aftermarket tractor parts with delivery
EXCAVATOR,

Compatible equipment models: 9V9005:

EXCAVATOR  315B   Caterpillar
Number on catalog scheme: 7
 
  For full view, you need register

Information:

10/07/91Service Magazine; April 15, 1991; Page 4; "Simplified Battery Testing Procedure SEHS7633-02 And Battery Test Sheet SEHS9326 Available".In COSA, use form G1052 only for testing batteries in accordance with Special Instruction SEHS7633-02. This was announced in the COSA General Letter, CSD No. 12 dated May 15, 1990. DO NOT use form SEHS9326. Paragraph 3 and 4 of the article refer to an Open Circuit Voltage (OCV) of 12.40 as having sufficient charge to use, sell or load test the battery. This is correct providing it is a stabilized voltage. If the OCV was measured shortly after recharging, invariably the reading will be falsely high due to a surface charge on the plates. Remove the surface charge as described in Special Instruction SEHS7633-02 by applying a load of half the cold cranking amperes (cca) rating for 5 seconds. Allow the battery to recover and measure the OCV. If the OCV recovers to 12.40 or more, the battery can be put into use or load tested. If it does not, further charge the battery.
Always use a digital voltmeter for all battery voltage checks. If testing 8 or 6 volt batteries, the equivalent OCV is 8.27 and 6.20 volts, respectively.--------------- END SUPPLEMENT ---------------Reference: Special Instructions: SEHS7633-02, "Battery Test Procedure" and SEHS9326, "Battery Test Sheet". (IRM): PELE0187, BAT 91-4, "Simplified Battery Test Procedure"; PELE0172, BAT 90-7, "New Battery Test Tool Available" PELE0178, BAT 90-9A, "New Battery Load Tester".A new Battery Test Procedure, SEHS7633-02, has been published. The new procedure covers all aspects of testing batteries. It also covers charging and warranty determination.
You can save time and money by using this new, simplified method of testing batteries. Instead of using a hydrometer to measure the specific gravity of the acid in each cell, you simply touch a voltmeter to the battery terminals. The voltmeter reading will tell you the open circuit voltage which indicates state of charge. Any reading of 12.4 volts or more (in a 12 volt battery) means there is sufficient charge to use, sell, or load test. Any reading less than 12.4 means a recharge is needed.
Once the battery is at a sufficient state of charge (12.4 or more), a load test can be performed to determine if the battery is good or bad. Connect the battery to a load tester. Set at 1/2 the cold cranking amp (CCA) rating from the Parts Sales Kit, PEKP9100. After 15 seconds, the voltage should be 9.5 or more (for a 12 volt battery). Any lower reading indicates a bad battery.
Use a digital voltmeter for measuring the battery's state of charge. Analog-type (moving needle) testers are not accurate enough for battery work. A fully charged battery will measure 12.7 volts; 12.4 volts indicates a 75% charge; and 12.0 indicates the battery is almost dead.
Never load test a battery that reads less than 12.4 volts. It will always test bad. When the battery is charged, it may test good.
A Battery Test Sheet, SEHS9326, is now available. It follows the same step-by-step procedure used in

Caterpillar parts catalog:

Caterpillar parts catalog
315B & 315B L TRACK-TYPE EXCAVATORS 1SW00001-UP (MACHINE) POWERED BY 3046 ENGINE


Parts elbow Caterpillar catalog:

1619376 ELBOW
315B FM L, 320B FM LL
1354022 ELBOW
315B FM L, 320B FM LL
1235586 ELBOW
307B, 325B, 330B
2K0044 ELBOW
14E, 5S, 6A, 6S, 920, 950, 955H, 966C, 988, D5B, D6D, D6E, D6E SR, D6G, D6G SR, D6G2 LGP, D6G2 XL, D6H XL, D6R
1245332 ELBOW
572R, D6R, D6R II, D7R, D7R II, D8R II
9S7710 ELBOW-FLARED
518, 518C, 528, 528B, 530B, 572R, 572R II, 578, 583R, 583T, 587R, 587T, 589, 651E, 657E, 936, 950, 950B, 950F, D10N, D10R, D10T, D10T2, D4D, D4E, D6H, D6H XL, D6H XR, D6R, D6R II, D6R III, D6R STD, D6...
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.